2016.5 VAUXHALL ZAFIRA TOURER warning light

Vehicle care231Charging the vehicle battery9Warning
On vehicles with stop-start
system, ensure that the charging potential does not exceed
14.6 volts when using a battery
charger. Otherwise the vehicle
battery might be damaged.
Jump starting 3 262.
Warning label
Meaning of symbols: ● No sparks, naked flames or smoking.
● Always shield eyes. Explosive gases can cause blindness or
injury.
● Keep the vehicle battery out of reach of children.
● The vehicle battery contains sulphuric acid which could cause
blindness or serious burn
injuries.
● See the Owner's Manual for further information.
● Explosive gas may be present in the vicinity of the vehicle battery.
Diesel fuel system bleeding If the tank has been run dry, the diesel
fuel system must be bled. Switch on
the ignition three times for
15 seconds at a time. Then crank the
engine for a maximum of 40 seconds. Repeat this process after
no less than five seconds. If the
engine fails to start, seek the
assistance of a workshop.Wiper blade replacement
Lift the wiper arm until it stays in the
raised position, press button to
disengage the wiper blade and
remove.
Attach the wiper blade slightly angled
to the wiper arm and push until it
engages.
Lower wiper arm carefully.

250Vehicle careAfter inflating, some driving may be
required to update the tyre pressure
values in the Driver Information
Centre. During this time w may
illuminate.
If w illuminates at lower temperatures
and extinguishes after some driving,
this could be an indicator for
approaching a low tyre pressure
condition. Check tyre pressure.
Vehicle messages 3 122.
If the tyre pressure must be reduced
or increased, switch off ignition.
Only mount wheels with pressure
sensors, otherwise the tyre pressure
will not be displayed and w
illuminates continuously.
A temporary spare wheel is not
equipped with pressure sensors. The
tyre pressure monitoring system is
not operational for these wheels.
Control indicator w illuminates. For
the further three wheels the system remains operational.
The use of commercially available
liquid tyre repair kits can impair the
function of the system. Factory-
approved repair kits can be used.Operating electronic devices or being
close to facilities using similar wave
frequencies could disrupt the tyre
pressure monitoring system.
Each time the tyres are replaced, tyre pressure monitoring system sensors
must be dismounted and serviced.
For the screwed sensor: replace
valve core and sealing ring. For
clipped sensor: replace complete
valve stem.
Vehicle loading status Adjust tyre pressure to load condition
according to the tyre information label or tyre pressure chart 3 288, and
select the appropriate setting in the Tyre load menu in the Driver
Information Centre 3 116. This
setting is the reference for the tyre
pressure warnings.
The menu Tyre Load only appears if
the vehicle is at a standstill and the
parking brake is applied. On vehicles
with automatic transmission the
selector lever must be in position P.
Select:
● Light for comfort pressure up to
3 people.
● Eco for Eco pressure up to
3 people.
● Max for full load.
Tyre pressure sensor matching process
Each tyre pressure sensor has a
unique identification code. The
identification code must be matched
to a new wheel position after rotating
the wheels or exchanging the
complete wheel set and if one or more tyre pressure sensors were replaced.

Vehicle care251The tyre pressure sensor matching
process should also be performed
after replacing a spare wheel with a
road wheel containing the tyre
pressure sensor.
The malfunction light w and the
warning message or code should go
off at the next ignition cycle. The
sensors are matched to the wheel
positions, using a relearn tool, in the
following order: left side front wheel,
right side front wheel, right side rear
wheel and left side rear wheel. The
turn signal light at the current active
position is illuminated until sensor is
matched.
Consult your workshop for service or
to purchase a relearn tool. There are
two minutes to match the first wheel
position, and five minutes overall to
match all four wheel positions. If it
takes longer, the matching process stops and must be restarted.
The tyre pressure sensor matching
process is:
1. Apply the parking brake.
2. Turn the ignition on.3. On vehicles with automatic transmission: set the selector
lever to P.
On vehicles with manual
transmission: select neutral.
4. Press MENU on the turn signal
lever to select the Vehicle
Information Menu in the Driver
Information Centre.
5. Turn the adjuster wheel to scroll to
the tyre pressure menu.
6. Press SET/CLR to begin the
sensor matching process. A
message requesting acceptance
of the process should be
displayed.
7. Press SET/CLR again to confirm
the selection. The horn sounds
twice to indicate the receiver is in relearn mode.
8. Start with the left side front wheel.
9. Place the relearn tool against the tyre sidewall, near the valve stem.
Then press the button to activate
the tyre pressure sensor. A horn
chirp confirms that the sensor
identification code has been
matched to this wheel position.10. Proceed to the right side front wheel, and repeat the procedure
in Step 9.
11. Proceed to the right side rear wheel, and repeat the procedure
in Step 9.
12. Proceed to the left side rear wheel, and repeat the procedure
in Step 9. The horn sounds twice
to indicate the sensor
identification code has been
matched to the left side rear tyre,
and the tyre pressure sensor
matching process is no longer
active.
13. Turn off the ignition.
14. Set all four tyres to the recommended air pressure level
as indicated on the tyre pressure
label.
15. Ensure the tyre loading status is set according to the selected
pressure 3 116.
Tread depth
Check tread depth at regular
intervals.

301Child restraints.............................. 60
Child restraint systems ................60
Cigarette lighter .........................103
Climate control ............................. 15
Climate control systems .............150
Clock........................................... 101
Code ........................................... 122
Collision damage repair ..............295
Control indicators........................ 107
Control of the vehicle .................159
Controls ........................................ 97
Convex shape .............................. 28
Coolant and antifreeze ...............270
Cruise control ....................116, 179
Cupholders .................................. 67
Curtain airbag system .................. 58
Curve lighting.............................. 142
D Danger, Warnings and Cautions ...4
Daytime running lights ...............142
Declaration of conformity ............292
DEF ............................................ 166
Diesel exhaust fluid ....................166
Diesel fuel system bleeding .......231
Diesel particle filter .............114, 164
Door open .................................. 116
Door panel storage .......................68
Doors ............................................ 25
Driver assistance systems ..........179Driver Information Centre ...........116
Driving characteristics and towing tips .............................. 219
Driving hints ................................ 159
E Electric adjustment ......................28
Electrical system......................... 240
Electric parking brake .........112, 174
Electric parking brake fault .........112
Electronic climate control system 152
Electronic driving programmes ..171
Electronic Stability Control.......... 176
Electronic Stability Control and Traction Control system ..........113
Electronic Stability Control off..... 113
End-of-life vehicle recovery .......224
Engine compartment fuse box ...241
Engine coolant ........................... 227
Engine coolant temperature gauge ..................................... 106
Engine data ............................... 277
Engine exhaust .......................... 164
Engine identification ...................273
Engine oil ................... 226, 270, 274
Engine oil pressure ....................114
Entry lighting .............................. 148
Event data recorders ..................297
Exit lighting ................................ 149
Exterior care .............................. 265Exterior light ............................... 115
Exterior lighting ....................12, 138
Exterior mirrors ............................. 28
F
Fault ........................................... 171
First aid kit ................................... 92
Fixed air vents ........................... 157
Flex-Fix system ............................ 70
Fog light ..................................... 116
Fog lights ................................... 235
Folding mirrors ............................. 29
Folding tray .................................. 92
Following distance indication ......192
Forward collision alert................. 188
Front airbag system .....................57
Front fog lights ........................... 146
Front seats.................................... 38 Front storage ................................ 68
Fuel............................................. 209
Fuel consumption - CO 2-
Emissions ............................... 217
Fuel for diesel engines ..............209
Fuel for liquid gas operation .......210
Fuel for natural gas operation ...209
Fuel for petrol engines ...............209
Fuel gauge ................................. 105 Fuel selector .............................. 105
Fuses ......................................... 240

302GGauges ....................................... 104
General information ...................218
Glass panel .................................. 34
Glovebox ..................................... 66
Graphic-Info-Display, Colour- Info-Display ............................ 120
H Halogen headlights ....................232
Hand brake ......................... 173, 174
Hazard warning flashers ............145
Headlight flash ........................... 140
Headlight range adjustment ......141
Headlights................................... 138
Headlights when driving abroad 141
Head restraint adjustment .............8
Head restraints ............................ 36
Heated mirrors ............................. 29
Heated rear window ..................... 33
Heated steering wheel .................97
Heating ........................................ 43
Heating and ventilation system . 150
High beam ......................... 115, 140
High beam assist ................115, 140
Hill start assist ........................... 175
Horn ....................................... 13, 98
I
Identification plate .....................272
Ignition switch positions .............160Immobiliser .......................... 28, 115
Indicators .................................... 104
Information displays.................... 116
Instrument cluster ......................104
Instrument panel fuse box .........243
Instrument panel illumination .....240
Instrument panel illumination control .................................... 147
Instrument panel overview ........... 10
Instrument panel storage ..............66
Interactive driving system ...........177
Interior care ............................... 267
Interior lighting ............................ 147
Interior lights ...................... 147, 239
Interior mirrors .............................. 30
Interruption of power supply ......171
Introduction .................................... 3
ISOFIX child restraint systems ....65
J Jump starting ............................. 262
K Keys ............................................. 19
Keys, locks ................................... 19
L
Lane departure warning .....113, 207
Lashing eyes ............................... 88
Lighting features .........................148
Light switch ................................ 138Load compartment ................25, 79
Load compartment cover .............82
Load compartment fuse box ......244
Loading information .....................94
Load rails and hooks ...................88
Low fuel ..................................... 115
Low washer fluid ........................116
M Malfunction indicator light ..........111
Manual anti-dazzle ......................30
Manual mode ............................. 170
Manual seat adjustment ...............39
Manual transmission .................. 172
Manual windows ..........................31
Memorised settings ......................23
Midlevel-Display ......................... 116
Mirror adjustment ........................... 8
Misted light covers .....................147
N New vehicle running-in ..............159
Number plate light .....................239
O Object detection systems ...........194
Odometer ................................... 104
Oil, engine .................. 226, 270, 274
OnStar ........................................ 133
Operate pedal ............................. 112
Outside temperature ..................100

304Tow bar....................................... 218
Towing ................................ 218, 263
Towing another vehicle .............264
Towing equipment .....................220
Towing the vehicle .....................263
Traction Control system ............. 176
Traction Control system off......... 114
Traffic sign assistant ...................204
Trailer coupling ........................... 218
Trailer stability assist .................222
Trailer towing ............................. 219
Transmission ............................... 16
Transmission display .................169
Tread depth ............................... 251
Trip computer ............................ 126
Trip odometer ............................ 104
Turn and lane-change signals ...145
Turn signal ................................. 110
Tyre chains ................................ 253
Tyre designations ......................247
Tyre pressure ............................ 247
Tyre pressure monitoring system ............................. 114, 248
Tyre pressures ........................... 288
Tyre repair kit ............................. 253
U Ultrasonic parking assist ...113, 194
Underseat storage .......................68
Upholstery .................................. 267Uplevel-Combi-Display ...............116
Upshift ........................................ 113
Using this manual ..........................3
V Vehicle battery ........................... 229
Vehicle checks............................ 225
Vehicle data ................................ 274
Vehicle data recording and privacy ..................................... 297
Vehicle detected ahead ..............116
Vehicle dimensions .................... 285
Vehicle Identification Number ....272
Vehicle jack ................................ 246
Vehicle messages .....................122
Vehicle personalisation .............129
Vehicle security ............................ 26
Vehicle specific data ......................3
Vehicle storage ........................... 224
Vehicle tools ............................... 246
Vehicle unlocking ........................... 6 Vehicle weight ........................... 283
Ventilation ................................... 150
W
Warning chimes .........................125
Warning lights ............................. 104
Warning triangle .......................... 92
Washer and wiper systems .........14
Washer fluid ............................... 229
Wheel changing .........................256Wheel covers ............................. 252
Wheels and tyres .......................247
Windows ....................................... 30
Windscreen................................... 30
Windscreen wiper/washer ...........98
Winter tyres ............................... 247
Wiper blade replacement ..........231