2015 VAUXHALL ZAFIRA TOURER Fuel filter

Instruments and controls121
No.Vehicle message26Left rear turn signal failure27Right front turn signal failure28Right rear turn signal failure29Check trailer brake light30Check trailer reversing light31Check left trailer turn signal32Check right trailer turn signal33Check trailer rear fog light34Check trailer rear light35Replace battery in radio remote
control48Clean side blind zone alert
system49Lane departure warning
unavailable53Tighten gas cap54Water in diesel fuel filterNo.Vehicle message55Diesel particle filter is full
3 15956Tyre pressure imbalance on
front axle57Tyre pressure imbalance on
rear axle58Tyres without TPMS sensors
detected59Open and then close driver
window60Open and then close front
passenger window61Open and then close rear left
window62Open and then close rear right
window65Theft attempted66Service theft alarm system67Service steering wheel lock68Service power steeringNo.Vehicle message69Service suspension system70Service level control system71Service rear axle74Service AFL75Service air conditioning76Service side blind zone alert
system77Service lane departure warning79Top up engine oil81Service transmission82Change engine oil soon83Service adaptive cruise control84Engine power is reduced89Service vehicle soon94Shift to park before exiting95Service airbag128Bonnet open

154Driving and operatingStarting and operating
New vehicle running-in Do not brake unnecessarily hard for
the first few journeys.
During the first drive, smoke may
occur because of wax and oil
evaporating off the exhaust system.
Park the vehicle in the open for a
while after the first drive and avoid
inhaling the fumes.
During the running-in period, fuel and
engine oil consumption may be
higher and the cleaning process of
the diesel particle filter may take
place more often. Autostop may be
inhibited to allow for charging of the vehicle battery.
Diesel particle filter 3 159.Ignition switch positions0=Ignition off1=Steering wheel lock released,
ignition off2=Ignition on, for diesel engine:
preheating3=Starting
Retained power off
The following electronic systems can
work until the driver's door is opened
or at the latest for 10 minutes after the
ignition is switched off:
■ Power windows
■ Power outlets
Power to the Infotainment system will continue to operate for 30 minutes oruntil the key is removed from the
ignition switch, regardless of whether
any door will be opened.
Starting the engine
Manual transmission: operate clutch.
Automatic transmission: operate
brake and move the selector lever to
P or N.
Do not operate the accelerator pedal.

Driving and operating159Engine exhaust9Danger
Engine exhaust gases contain
poisonous carbon monoxide,
which is colourless and odourless and could be fatal if inhaled.
If exhaust gases enter the interior
of the vehicle, open the windows.
Have the cause of the fault
rectified by a workshop.
Avoid driving with an open load
compartment, otherwise exhaust
gases could enter the vehicle.
Diesel particle filter
The diesel particle filter system filters
harmful soot particles out of the
exhaust gases. The system includes
a self-cleaning function that runs
automatically during driving without
any notification. The filter is cleaned
by periodically burning off the soot
particles at high temperature. This
process takes place automatically
under set driving conditions and may
take up to 25 minutes. Typically it
needs between 7 and 12 minutes. Autostop is not available and fuel
consumption may be higher during
this period. The emission of smells
and smoke during this process is
normal.
Under certain driving conditions, e.g.
short distances, the system cannot
clean itself automatically.
If the cleaning of the filter is required
and if previous driving conditions did
not enable automatic cleaning, it will
be indicated by control indicator %.
Simultaneously Diesel partic. filter is
full continue driving or warning
code 55 appears in the Driver
Information Centre.
% illuminates when diesel particle
filter is full. Start cleaning process as
soon as possible.
% flashes when diesel particle filter
has reached the maximum filling
level. Start cleaning process
immediately to avoid damage to the
engine.
Cleaning process
To activate cleaning process,
continue driving, keep engine speed
above 2000 revolutions per minute.
Shift down if necessary. Diesel
particle filter cleaning is then started.
If g illuminates additionally,
cleaning is not possible, seek the
assistance of a workshop.Caution
If the cleaning process is
interrupted, there is a risk of
provoking severe engine damage.

Technical data281CapacitiesEngine oilEngineB14NELB14NET,
B14NET LPGA16XNT CNGA16SHT,
A16XHTA18XEL,
A18XERincluding Filter [l]4.04.04.55.54.5between MIN and MAX [l]1.01.01.01.01.0EngineB16DTHB16DTJA20DTLA20DTA20DTHA20DTRincluding Filter [l]5.05.04.54.54.54.5between MIN and MAX [l]1.01.01.01.01.01.0
Fuel tank
Petrol/diesel, refilling quantity [l]58Natural gas CNG, refilling quantity [kg] or [l]
Petrol, refilling quantity25 kg 4)
or 144 l
14Liquid gas LPG, refilling quantity [l]604) At 20 MPa/200 bar/2900 psi and 15°C.

291
Child restraints.............................. 57
Child restraint systems ................57
Cigarette lighter .........................100
Climate control ............................. 15
Climate control systems .............144
Clock............................................. 98
Code ........................................... 120
Control indicators........................ 104
Control of the vehicle .................153
Controls ........................................ 93
Convex shape .............................. 28
Coolant and antifreeze ...............265
Cruise control ....................113, 173
Cupholders .................................. 63
Curtain airbag system .................. 55
Curve lighting.............................. 135
D Danger, Warnings and Cautions ...4
Daytime running lights ...............135
Declaration of conformity ............286
DEF ............................................ 160
Diesel exhaust fluid ....................160
Diesel fuel system bleeding .......225
Diesel particle filter .............111, 159
Door open .................................. 113
Door panel storage .......................64
Doors ............................................ 24
Driver assistance systems ..........173
Driver Information Centre ...........114Driving characteristics and
towing tips .............................. 212
Driving hints ................................ 153
E Electric adjustment ......................28
Electrical system......................... 234
Electric parking brake .........109, 168
Electric parking brake fault .........109
Electronic climate control system 146
Electronic driving programmes ..165
Electronic Stability Control.......... 171
Electronic Stability Control and Traction Control system ..........111
Electronic Stability Control off..... 111
End-of-life vehicle recovery .......218
Engine compartment fuse box ...236
Engine coolant ........................... 221
Engine coolant temperature gauge ..................................... 103
Engine data ............................... 272
Engine exhaust .......................... 159
Engine identification ...................268
Engine oil ................... 219, 265, 269
Engine oil pressure ....................112
Entry lighting .............................. 142
Event data recorders ..................288
Exit lighting ................................ 142
Exterior care .............................. 260
Exterior light ............................... 112Exterior lighting ....................12, 132
Exterior mirrors ............................. 28
F
Fault ........................................... 165
First aid kit ................................... 89
Fixed air vents ........................... 151
Flex-Fix system ............................ 67
Fog light ..................................... 113
Fog lights ................................... 229
Folding mirrors ............................. 28
Folding tray .................................. 89
Following distance indication ......186
Forward collision alert................. 183
Front airbag system .....................53
Front fog lights ........................... 139
Front seats.................................... 37
Front storage ................................ 64
Fuel............................................. 203
Fuel consumption - CO 2-
Emissions ............................... 211
Fuel for diesel engines ..............203
Fuel for liquid gas operation .......204
Fuel for natural gas operation ...203
Fuel for petrol engines ...............203
Fuel gauge ................................. 102
Fuel selector .............................. 102
Fuses ......................................... 234

293
Oil, engine.................. 219, 265, 269
Operate pedal ............................. 109
Outside temperature ....................97
Overhead console .......................64
Overrun cut-off ........................... 155
P Parking ................................ 18, 158
Parking assist ............................ 189
Parking brake ............................ 168
Parking lights ............................. 140
Particulate filter ........................... 159
Performance .............................. 276
Performing work ........................218
Pollen filter ................................. 152
Power outlets ............................... 99
Power seat adjustment ................40
Power steering............................ 110
Power steering fluid ....................221
Power windows ............................ 30
Preheating ................................. 111
Puncture ..................................... 250
Q
Quickheat ................................... 150
R Radio Frequency Identification (RFID) ..................................... 289
Radio remote control ...................20Reading lights ............................ 142
Rear carrier system ......................67
Rear floor storage cover ..............80
Rear fog light ............................. 113
Rear fog lights ........................... 140
Rear seats .................................... 43
Rear storage ................................. 78
Rear view camera ...................... 197
Rear window wiper/washer .......... 97 Recommended fluids and lubricants ........................ 265, 269
Reduced engine power ..............112
Refuelling ................................... 206
Retained power off .....................154
Reversing lights .........................140
Ride control system ....................170
Roller blinds ................................. 32
Roof .............................................. 33
Roof load ...................................... 91
Roof rack ..................................... 90
S Safety net .................................... 87
Seat adjustment ....................... 6, 37
Seat belt ........................................ 8
Seat belt reminder .....................107
Seat belts ..................................... 49
Seat position ................................ 37
Second row seats ........................43
Selective catalytic reduction .......160Selector lever ............................. 163
Service ............................... 152, 264
Service display .......................... 104
Service information ....................264
Service vehicle soon .................. 109
Side airbag system ......................54
Side blind spot alert ....................195
Sidelights .................................... 132
Side turn signal lights ................233
Spare wheel ............................... 253
Speed limiter............................... 175
Speedometer ............................. 101
Starting and operating ................154
Starting off ................................... 17
Starting the engine ....................154
Steering ...................................... 153
Steering wheel adjustment ......9, 93
Steering wheel controls ...............93
Stop-start system........................ 156
Storage ......................................... 62
Storage compartment ...................62
Storage compartments .................62
Sunvisor lights ........................... 142
Sun visors .................................... 32
Symbols ......................................... 4
T
Tachometer ............................... 102
Tail lights ................................... 230
Third row seats ............................ 47