2015 TOYOTA AYGO steering

3878-2. Steps to take in an emergency
8
When trouble arises
AYGO_EE_OM99J92E
WARNING
■ Driving to spread the liquid sealant evenly
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in a loss of vehicle control and cause death or
serious injury.
● Drive the vehicle carefully at a low speed. Be especially careful when turn-
ing and cornering.
● If the vehicle does not drive straight or you feel a pull through the steering
wheel, stop the vehicle and check the following:
• Tire condition. The tire may have separated from the wheel.
• Tire inflation pressure. If tire inflation pressure is 130 kPa (1.3 kgf/cm2
or bar, 19 psi) or less, the tire may be severely damaged.
NOTICE
■ When performing an emergency repair
● A tire should only be repaired with the emergency tire puncture repair kit if
the damage is caused by a sharp object such as nail or screw passing
through the tire tread.
Do not remove the sharp object from the tire. Removing the object may
widen the opening and disenable emergency repair with the repair kit.
● The repair kit is not waterproof. Make sure that the repair kit is not
exposed to water, such as when it is being used in the rain.
● Do not put the repair kit directly onto dusty ground such as sand at the
side of the road. If the repair kit vacuums up dust etc., a malfunction may
occur.
■ Handling the emergency tire puncture repair kit
● The repair kit power source should be 12 V DC suitable for vehicle use. Do
not connect the repair kit to any other source.
● If gasoline splatters on the repair kit, the repair kit may deteriorate. Take
care not to allow gasoline to contact it.
● Place the repair kit in a storage to prevent it from being exposed to dirt or
water.
● Store the repair kit in the luggage compartment out of reach of children.
● Do not disassemble or modify the repair kit. Do not subject parts such as
the air pressure indicator to impacts. This may cause a malfunction.

3898-2. Steps to take in an emergency
8
When trouble arises
AYGO_EE_OM99J92E
One of the following may be the cause of the problem:
● One or both of the battery terminals may be disconnected.
● The battery may be discharged. (→P. 394)
● There may be a malfunction in the steering lock system (vehicles
with a smart entry & start system).
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional if the problem cannot be repaired, or if repair
procedures are unknown.
When the engine does not start, the following steps can be used as an
interim measure to start the engine if the engine switch is functioning
normally:
Set the parking brake.
Shift the shift lever to N.
Turn the engine switch to ACCESSORY mode.
Press and hold the engine switch for about 15 seconds while
depressing the brake pedal (multi-mode manual transmission) or
clutch pedal (manual transmission) firmly.
Even if the engine can be started using the above steps, the system
may be malfunctioning. Have the vehicle inspected by any authorized
Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional.
The starter motor does not turn over, the interior lights and head-
lights do not turn on, or the horn does not sound.
Emergency start function
1
2
3
4

4169-1. Specifications
AYGO_EE_OM99J92E
*1: Minimum pedal clearance when depressed with a force of 300 N (30.6 kgf,
67.4 lbf) while the engine is operating.
*2: Parking brake lever travel when pulled up with a force of 196 N (20 kgf,
44 lbf).
X14-inch tires (type A)*
X14-inch tires (type B)*
Brakes
Pedal clearance*1
Left-hand
drive vehicles94 mm (3.7 in.) Min.
Right-hand
drive vehicles93 mm (3.6 in.) Min.
Pedal free play1  6 mm (0.04  0.24 in.)
Parking brake lever travel*25  8 clicks
Fluid typeSAE J1704 or FMVSS No. 116 DOT 4
Steering
Free playLess than 30 mm (1.2 in.)
Tires and wheels
Tire size165/65R14 79T
Tire inflation pressure
(Recommended cold tire
inflation pressure)
Front: 230 kPa (2.3 kgf/cm2 or bar, 33 psi)
Rear: 230 kPa (2.3 kgf/cm2 or bar, 33 psi)
Wheel size14 × 4 1/2J
Wheel bolt torque103 N·m (10.5 kgf·m, 76 ft·lbf)
Tire size165/65R14 79T
Tire inflation pressure
(Recommended cold tire
inflation pressure)
Front: 220 kPa (2.2 kgf/cm2 or bar, 32 psi)
Rear: 220 kPa (2.2 kgf/cm2 or bar, 32 psi)
Wheel size14 × 4 1/2J
Wheel bolt torque103 N·m (10.5 kgf·m, 76 ft·lbf)

425What to do if... (Troubleshooting)
AYGO_EE_OM99J92E
●Vehicles with a multi-mode manual transmission
Do you turn the key with the brake pedal depressed firmly? ( →P. 151)
●Vehicles with a manual transmission
Do you turn the key with the clutch pedal depressed firmly? ( →P. 151)
●Is the battery discharged? (→P. 394)
●Vehicles with a multi-mode manual transmission
Did you press the engine switch while firmly depressing the brake pedal?
( →P. 154)
●Vehicles with a manual transmission
Did you press the engine switch while firmly depressing the clutch pedal?
( →P. 154)
●Is the electronic key anywhere detectable inside the vehicle? (→P. 113)
●Is the steering wheel unlocked? (→P. 157)
●Is the electronic key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( →P. 392)
●Is the battery discharged? (→P. 394)
●Vehicles without a smart entry & start system
Is the engine switch in the “ON” position?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in the “ON” position: →P. 390
●Vehicles with a smart entry & start system
Is the engine switch in IGNITION ON mode?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in IGNITION ON mode: →P. 390
If you think something is wrong
The engine does not start
(vehicles without a smart entry & start system)
The engine does not start
(vehicles with a smart entry & start system)
The shift lever cannot be shifted even if you depress the
brake pedal (vehicles with a multi-mode manual transmis-
sion)

426What to do if... (Troubleshooting)
AYGO_EE_OM99J92E
●Vehicles without a smart entry & start system
It is locked to prevent theft of the vehicle if the key is removed from the
engine switch. ( →P. 152)
●Vehicles with a smart entry & start system
It is locked automatically to prevent theft of the vehicle. ( →P. 157)
●The auto power off function will be operated if the vehicle is left in ACCES-
SORY or IGNITION ON mode (the engine is not operating) for a period of
time. ( →P. 156)
●The seat belt reminder light is flashing
Are the driver and the front passenger wearing the seat belts? ( →P. 355)
●The brake system warning light is on
Is the parking brake released? ( →P. 166)
Depending on the situation, other types of warning buzzer may also
sound. ( →P. 352)
●When a warning light turns on, refer to P. 352.
The steering wheel cannot be turned after the engine is
stopped
The engine switch is turned off automatically
(vehicles with a smart entry & start system)
A warning buzzer sounds during driving
A warning light turns on

428Alphabetical index
AYGO_EE_OM99J92E
Alphabetical index
A/C..................................... 256, 262
Air conditioning filter.............. 318
Automatic air conditioning
system ................................ 262
Manual air conditioning
system ................................ 256
ABS (Anti-lock Brake
System) .................................. 191
Function ................................ 191
Warning light ......................... 354
Air conditioning filter .............. 318
Air conditioning
system ............................ 256, 262
Air conditioning filter.............. 318
Automatic air conditioning
system ................................ 262
Manual air conditioning
system ............................... 256
Airbag manual on-off
system ...................................... 45
Airbags ....................................... 34
Airbag manual on-off
system .................................. 45
Airbag operating conditions .... 41
Airbag precautions for
your child .............................. 37
Airbag warning light .............. 354
Correct driving posture............ 28
Curtain shield airbag
operating conditions ............. 41
Curtain shield airbag
precautions ........................... 37
General airbag precautions..... 37
Locations of airbags................ 34
Modification and disposal
of airbags.............................. 40
Side airbag operating
conditions ............................. 41
Side airbag precautions .......... 37
Side and curtain shield
airbags operating
conditions ............................. 41
Side and curtain shield
airbags precautions .............. 37
SRS airbags............................ 34
Anchor brackets ........................ 62
Antennas (smart entry &
start system) .......................... 113
Anti-lock brake system
(ABS) ...................................... 191
Function ................................ 191
Warning light ......................... 354
Audio system*......................... 200
Audio input .................... 203, 226
AUX port ....................... 203, 226
Bluetooth® audio................... 242
iPod....................................... 211
Optimal use........................... 204
Portable music player ........... 203
Radio .................................... 206
Steering wheel audio
switch ................................. 202
USB memory ........................ 219
Automatic air conditioning
system .................................... 262
Air conditioning filter ............. 318
Automatic air conditioning
system ............................... 262
Automatic light control
system .................................... 169
AUX port*......................... 203, 226
A

430Alphabetical index
AYGO_EE_OM99J92E
Clock ......................................... 278
Condenser ................................ 303
Cooling system
Engine overheating ............... 398
Cup holders .............................. 272
Curtain shield airbags ............... 34
Customizable features ............ 421
Daytime running light
system .................................... 169
Defogger
Outside rear view
mirrors ........................ 258, 264
Rear window ................. 258, 264
Windshield .................... 258, 264
Dimension ................................ 406
Display
Multi-information display ......... 85
Trip information ....................... 85
Do-it-yourself maintenance .... 290
Doors
Back door .............................. 107
Door glasses ......................... 133
Door lock ....................... 102, 107
Open door warning buzzer.... 114
Open door warning light ........ 355
Outside rear view mirrors ...... 131
Rear door
child-protectors ................... 105
Side doors ............................. 102
Driving ...................................... 140
Break-in tips .......................... 142
Correct posture ....................... 28
Procedures............................ 140
Winter drive tips .................... 196
Electric Power Steering
(EPS)....................................... 191
Function ................................ 191
Warning light ......................... 354
Electronic key ............................ 92
Battery-saving function ......... 115
If the electronic key does not
operate properly ................. 391
Replacing the battery ............ 319
Emergency, in case of
If the electronic key does not
operate properly ................. 391
If the engine will not start ...... 388
If the shift lever cannot be
shifted ................................. 390
If the vehicle has discharged
battery ................................ 394
If the warning buzzer
sounds................................ 352
If the warning light
turns on .............................. 352
If you have a flat tire ..... 361, 374
If you lose your keys ............... 94
If you think something is
wrong.................................. 350
If your vehicle becomes
stuck ................................... 402
If your vehicle needs to be
towed .................................. 345
If your vehicle overheats ....... 398
Emergency brake signal ......... 191
Emergency flashers ................ 342
Emergency tire puncture
repair kit ................................. 374
D
E

431Alphabetical index
AYGO_EE_OM99J92E
Engine
“ACC” position....................... 151
Accessory mode ................... 156
Compartment ........................ 296
Engine switch ................ 151, 154
Hood ..................................... 293
How to start
the engine................... 151, 154
If the engine will not start ...... 388
Ignition switch
(engine switch) ........... 151, 154
Overheating .......................... 398
Engine coolant ......................... 301
Capacity ................................ 413
Checking ............................... 301
Preparing and checking
before winter....................... 196
Engine coolant
temperature
warning light .................. 352, 353
Engine immobilizer system ...... 69
Engine oil.................................. 298
Capacity ................................ 408
Checking ............................... 298
Preparing and checking
before winter....................... 196
Engine switch
(ignition switch) ............. 151, 154
EPS (Electronic Power
Steering) ................................. 191
Function ................................ 191
Warning light ......................... 354
Flat tire
Vehicles with a spare tire ...... 361
Vehicles without
a spare tire ......................... 374
Floor mats .................................. 26
Fluid
Brake .................................... 416
Washer ................................. 307
Fog lights ................................. 171
Replacing light bulbs..... 333, 336
Switch ................................... 171
Wattage ................................ 418
Follow me home system ......... 169
Front position lights ................ 167
Light switch ........................... 167
Replacing light bulbs............. 339
Front seats ............................... 123
Adjustment ............................ 123
Cleaning................................ 285
Correct driving posture ........... 28
Seat heaters ......................... 268
Front turn signal lights ........... 165
Replacing light bulbs............. 333
Turn signal lever ................... 165
Wattage ................................ 418
Fuel ........................................... 408
Capacity ................................ 408
Fuel gauge .............................. 83
Fuel pump shut off system.... 351
Information ............................ 419
Refueling............................... 177
Type .............................. 177, 408
Warning light ......................... 355
Fuel filler door.......................... 179
Refueling............................... 177
Fuel pump shut off system ..... 351
Fuses ........................................ 322
F