2015 Ram 5500 Chassis Cab air filter

3. Remove the air cleaner filter element from the housingassembly.
Open Air Cleaner Filter Assembly
1 — Air Cleaner Cover
2 — Air Cleaner Filter
Air Cleaner Filter
1 — Air Cleaner Filter
2 — Air Cleaner Filter Inspection Surface
7
MAINTAINING YOUR VEHICLE 499

Engine Air Cleaner Filter Installation
NOTE:Inspect and clean the housing if dirt or debris is
present before replacing the air filter element.
1. Install the air cleaner filter element into the housing assembly with the air cleaner filter inspection surface
facing downward.
2. Install the air cleaner cover onto the housing assembly locating tabs.
3. Latch the spring clips and lock the air cleaner cover to the housing assembly.
Accessory Drive Belt Inspection
WARNING!
•Do not attempt to inspect an accessory drive belt
with vehicle running.
(Continued)
WARNING! (Continued)
•When working near the radiator cooling fan, dis-
connect the fan motor lead. The fan is temperature
controlled and can start at any time regardless of
ignition switch position. You could be injured by
the moving fan blades.
• You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the proper equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
When inspecting accessory drive belts, small cracks that
run across ribbed surface of belt from rib to rib, are
considered normal. These are not a reason to replace belt.
However, cracks running along a rib (not across) are not
500 MAINTAINING YOUR VEHICLE

only the manufacturer ’s specified transmission fluid.
Refer to “Fluids, Lubricants, and Genuine Parts” in this
section for fluid specifications. It is important to maintain
the transmission fluid at the correct level using the
recommended fluid. No chemical flushes should be used
in any transmission; only the approved lubricant should
be used.
CAUTION!
Using a transmission fluid other than the manufac-
turer ’s recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder, and will require more frequent fluid and
filter changes. Refer to “Fluids, Lubricants, and
Genuine Parts” in this section for fluid specifica-
tions.
Special Additives
The manufacturer strongly recommends against using
any special additives in the transmission. Automatic
Transmission Fluid (ATF) is an engineered product and
its performance may be impaired by supplemental addi-
tives. Therefore, do not add any fluid additives to the
transmission. The only exception to this policy is the use
of special dyes for diagnosing fluid leaks. Avoid using
transmission sealers as they may adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
7
MAINTAINING YOUR VEHICLE 525

CAUTION!
If the fluid temperature is below 50°F (10°C) it may
not register on the dipstick. Do not add fluid until
the temperature is elevated enough to produce an
accurate reading. Run the engine at idle, in PARK, to
warm the fluid.
9. Reinsert the dipstick. Check for leaks. Release the parking brake.
NOTE: To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
sure that the dipstick cap is properly reseated. It is
normal for the dipstick cap to spring back slightly from
its fully seated position, as long as its seal remains
engaged in the dipstick tube.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filters if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Appearance Care And Protection From Corrosion
Protection Of Body And Paint From Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice, and chemicals that are sprayed
on trees and road surfaces during other seasons, are
highly corrosive to the metal in your vehicle. Outside
parking, which exposes your vehicle to airborne contami-
nants, road surfaces on which the vehicle is operated,
528 MAINTAINING YOUR VEHICLE

•Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission and fill as needed.
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting. 8
MAINTENANCE SCHEDULES 561

Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Inspect the brake linings, parking
brake function. XXX X X X X
Additional Maintenance
Replace engine air filter. XX X XX
Replace spark plugs
(5.7L engine).** X
Replace spark plugs
(6.4L engine).** X
Flush and replace the engine
coolant at 10 years or
150,000 miles (240,000 km)
whichever comes first. XX
8
MAINTENANCE SCHEDULES 563

Adding Engine Coolant (Antifreeze)............515
Adding Fuel ............................ .426
Additives, Fuel .......................... .424
Adjustable Pedals ........................ .167
Airbag.................................64
Air Bag Advance Front Air Bag ....................65
Air bag Operation .......................67
Air Bag Warning Light ....................71
Enhanced Accident Response ................70
Event Data Recorder (EDR) .................74
FrontAirBag...........................64
If A Deployment Occurs ...................69
Knee Impact Bolsters .....................68
Maintaining Your Air Bag System ............73
Air bag Deployment ........................64
Air bag Light .............................71
Air bag Maintenance ........................73
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .496 Air Conditioner Maintenance
.................503
Air Conditioning ......................... .283
Air Conditioning Controls ...................283
Air Conditioning, Operating Tips ..............303
Air Conditioning Refrigerant .................503
Air Conditioning System ....................283
Air Pressure, Tires ........................ .395
Alarm Light ............................ .206
Alarm, Panic .............................26
Alarm (Security Alarm) ......................20
Alarm System (Security Alarm) ................20
Alterations/Modifications, Vehicle ...............7
Antifreeze (Engine Coolant) ..................514
Capacities ........................... .554
Disposal ............................. .518
Anti-Lock Brake System (ABS) ................371
Anti-Lock Warning Light ....................201
Appearance Care ........................ .528
Ashtray ............................... .182
578 INDEX

Overheating.......................... .460
Engine Oil Viscosity ...................... .495
Enhanced Accident Response Feature ............70
Entry System, Illuminated ....................22
Ethanol ............................... .422
Event Data Recorder ........................74
Exhaust Gas Caution ...................... .109
Exhaust System .......................... .109
Exterior Lighting ......................... .151
Exterior Lights ...........................112
Filters Air Cleaner .......................... .496
Engine Fuel .......................... .555
Engine Oil ........................... .496
Engine Oil Disposal .....................496
Flashers Turn Signal ............................112
Flat Tire Stowage ........................ .472Flooded Engine Starting
....................331
Fluid, Brake ............................ .558
Fluid Capacities ......................... .554
Fluid Leaks .............................112
Fluid Level Checks Automatic Transmission ..................526
Brake ............................... .521
Power Steering ........................ .366
Fluids, Lubricants and Genuine Parts ...........555
Fog Lights ............................. .155
Four-Way Hazard Flasher ...................460
Four Wheel Drive ........................ .351
Freeing A Stuck Vehicle .....................477
Front Axle (Differential) .....................523
Fuel .................................. .421
Adding ............................. .426
Additives ............................ .424
Clean Air ............................ .422
Ethanol ............................. .422
10
INDEX 583