2015 OPEL ZAFIRA TOURER stop start

220Vehicle care9Danger
The ignition system and Xenon
headlights use extremely high
voltage. Do not touch.
Bonnet
Opening
Pull the release lever and return it to
its original position.
Move the safety catch sideways to the left vehicle side and open the bonnet.
The bonnet is held open
automatically by a lifter.
If the bonnet is opened during an
Autostop, the engine will be restarted automatically for safety reasons.
Closing
Lower the bonnet and allow it to drop into the catch. Check that the bonnet
is engaged.
Engine oil
Check the engine oil level manuallyon a regular basis to prevent damage
to the engine. Ensure that the correct specification of oil is used.
Recommended fluids and lubricants
3 266.
Check with the vehicle on a level
surface. The engine must be at
operating temperature and switched
off for at least 5 minutes.
Pull out the dipstick, wipe it clean, insert it to the stop on the handle, pull
out and read the engine oil level.
Insert dipstick to the stop on the
handle and make half a turn.

224Vehicle care
The brake fluid level must be betweenthe MIN and MAX marks.
If fluid level is below MIN seek the
assistance of a workshop.
Brake and clutch fluid 3 266.
Vehicle battery Vehicles without stop-start system
will be equipped with a lead acid
battery. Vehicles with stop-start
system will be equipped with an
AGM battery which is not a lead acid
battery.
The vehicle battery is maintenance-
free, provided that the driving profile
allows sufficient charging of the
battery. Short-distance-driving and
frequent engine starts can discharge
the battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Laying up the vehicle for more than
4 weeks can lead to battery
discharge. Disconnect the clamp from the negative terminal of the vehicle
battery.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
Vehicle battery discharge protection
3 144.
Replacing the vehicle battery
Note
Any deviation from the instructions
given in this section may lead to
temporary deactivation of the stop-
start system.
When the vehicle battery is being
replaced, please ensure that there
are no open ventilation holes in the
vicinity of the positive terminal. If a
ventilation hole is open in this area, it
must be closed off with a dummy cap, and the ventilation in the vicinity of the
negative terminal must be opened.
Only use vehicle batteries that allow
the fuse box to be mounted above the
vehicle battery.
In vehicles with stop-start system, be
sure to have the AGM (Absorptive
Glass Mat) battery replaced with an
AGM battery again.

Vehicle care225
An AGM battery can be identified by
the label on the battery. We
recommend the use of an original
Opel vehicle battery.
Note
Using an AGM vehicle battery
different from the original Opel
vehicle battery may result in a lower performance of the stop-start
system.
We recommend that you have the
vehicle battery replaced by a
workshop.
Stop-start system 3 157.
Charging the vehicle battery9 Warning
On vehicles with stop-start
system, ensure that the charging potential does not exceed
14.6 volts when using a battery
charger. Otherwise the vehicle
battery might be damaged.
Jump starting 3 258.
Warning label
Meaning of symbols: ■ No sparks, naked flames or smoking.
■ Always shield eyes. Explosive gases can cause blindness or
injury.
■ Keep the vehicle battery out of reach of children.
■ The vehicle battery contains sulphuric acid which could cause
blindness or serious burn injuries.
■ See the Owner's Manual for further
information.
■ Explosive gas may be present in the vicinity of the vehicle battery.

238Vehicle care
No.Circuit15Engine control module16Starter17Transmission control module18Heated rear window19Front power windows20Rear power windows21Rear electrical centre22Left high beam (Halogen)23Headlamp washer system24Right low beam (Xenon)25Left low beam (Xenon)26Front fog lights27Diesel fuel heating28Stop-start system29Electric parking brake30ABS31Adaptive cruise controlNo.Circuit32Airbag33Adaptive forward lighting, auto‐
matic light control34Exhaust gas recirculation35Outside rear view mirror, rain
sensor36Climate control37Canister vent solenoid38Vacuum pump39Central control module40Windscreen washer, rear
window washer system41Right high beam (Halogen)42Radiator fan43Windscreen wiper44Windscreen wiper45Radiator fan46–No.Circuit47Horn48Radiator fan49Fuel pump50Headlamp levelling, adaptive
forward lighting51Air shutter52Auxiliary heater, diesel engine53Transmission control module,
engine control module54Vacuum pump, instrument
panel cluster, heating ventila‐
tion, air conditioning system
After having changed defective fuses
close the fuse box cover and press
until it engages.
If the fuse box cover is not closed
correctly, malfunction may occur.

246Vehicle care
Select:■ Light for comfort pressure up to
3 people
■ Eco for Eco pressure up to
3 people
■ Max for full loading
TPMS Sensor Matching
Process
Each TPMS sensor has a unique
identification code. The identification
code must be matched to a new tyre/
wheel position after rotating the tyres
or exchanging the complete wheel set and if one or more TPMS sensors
were replaced. The TPMS sensor
matching process should also be
performed after replacing a spare tyre
with a road tyre containing the TPMS
sensor.
The malfunction light and the warning
message or code should go off at the
next ignition cycle. The sensors are
matched to the tyre/wheel positions,
using a TPMS relearn tool, in the
following order: left side front tyre,
right side front tyre, right side rear tyre and left side rear tyre. The turn signal
light at the current active position is
illuminated until sensor is matched.
Consult your workshop for service or
to purchase a relearn tool. There are
two minutes to match the first tyre/
wheel position, and five minutes
overall to match all four tyre/wheel
positions. If it takes longer, the
matching process stops and must be
restarted.The TPMS sensor matching process
is:
1. Apply the parking brake; on vehicles with automatic
transmission set the selector lever
to P.
2. Turn the ignition on.
3. Use the MENU button on the turn
signal lever to select the Vehicle
Information Menu in the Driver
Information Centre (DIC).
4. Turn the adjuster wheel to scroll to
the tyre pressure menu.
5. Press the SET/CLR button to
begin the sensor matching
process. A message requesting
acceptance of the process should
display.
6. Press the SET/CLR button again
to confirm the selection. The horn sounds twice to signal the
receiver is in relearn mode.
7. Start with the left side front tyre.
8. Place the relearn tool against the tyre sidewall, near the valve stem.Then press the button to activate
the TPMS sensor. A horn chirp

Technical data277PerformanceEngineB14NELB14NET
B14NET
LPGB16XNT
CNGMaximum speed 3)
[km/h]Manual transmission
with Stop-start system190
192200
202195
–200
–Automatic transmission–197––3) The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment could reduce the specified maximum
speed of the vehicle.EngineA16SHTA16XHTA18XELA18XERMaximum speed 3)
[km/h]Manual transmission
with Stop-start system–
225–
–185
–195
–Automatic transmission–208––3) The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment could reduce the specified maximum
speed of the vehicle.

278Technical dataEngineB16DTHB16DTJA20DTLA20DT
A20DTH
121 kWA20DTH
96 kW
A20DTR
Maximum speed 3)
[km/h]Manual transmission
with Stop-start system–
193–
186183
–191
193208
209–
––
218Automatic transmission––––205192–3) The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment could reduce the specified maximum
speed of the vehicle.

295
Oil, engine.................. 220, 266, 270
Operate pedal ............................. 110
Outside temperature ....................98
Overhead console .......................65
Overrun cut-off ........................... 156
P Parking ................................ 18, 159
Parking assist ............................ 190
Parking brake ............................ 169
Parking lights ............................. 141
Particulate filter ........................... 160
Performance .............................. 277
Performing work ........................219
Pollen filter ................................. 153
Power outlets ............................. 100
Power seat adjustment ................41
Power steering............................ 111
Power steering fluid ....................222
Power windows ............................ 31
Preheating ................................. 112
Puncture ..................................... 251
Q Quickheat ................................... 151
R
Radio Frequency Identification (RFID) ..................................... 290
Radio remote control ...................21Reading lights ............................ 143
Rear carrier system ......................68
Rear floor storage cover ..............81
Rear fog light ............................. 114
Rear fog lights ........................... 141
Rear seats .................................... 44
Rear storage ................................. 79
Rear view camera ...................... 198
Rear window wiper/washer .......... 98
Recommended fluids and lubricants ........................ 266, 270
Reduced engine power ..............113
Refuelling ................................... 207 Retained power off .....................155
Reversing lights .........................141
Ride control system ....................171
Roller blinds ................................. 33
Roof .............................................. 34
Roof load ...................................... 92
Roof rack ..................................... 91
S Safety net .................................... 88
Seat adjustment ....................... 6, 38
Seat belt ........................................ 8
Seat belt reminder .....................108
Seat belts ..................................... 50 Seat position ................................ 38
Second row seats ........................44
Selective catalytic reduction .......161Selector lever ............................. 164
Service ............................... 153, 265
Service display .......................... 105
Service information ....................265
Service vehicle soon .................. 110
Side airbag system ......................55
Side blind spot alert ....................196
Sidelights .................................... 133
Side turn signal lights ................234
Spare wheel ............................... 254
Speed limiter............................... 176
Speedometer ............................. 102
Starting and operating ................155
Starting off ................................... 17
Starting the engine ....................155
Steering ...................................... 154
Steering wheel adjustment ......9, 94
Steering wheel controls ...............94
Stop-start system........................ 157
Storage ......................................... 63
Storage compartment ...................63
Storage compartments .................63
Sunvisor lights ........................... 143
Sun visors .................................... 33
Symbols ......................................... 4
T
Tachometer ............................... 103
Tail lights ................................... 231
Third row seats ............................ 48