2015 OPEL VIVARO spare wheel

166Vehicle care
5. Unscrew wheel bolts completelyby turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 166.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench
locates securely. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.Note
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).
11. Stow the replaced wheel 3 166
and the vehicle tools 3 156.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 192.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 162.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a flat rear tyre.
Wheel changing 3 165.

Vehicle care167
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied. Vehicle tools 3 156.
9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,loosen bolt 1, ensuring it is not fully
removed. Fully remove bolt 2, then
pull the carrier to the left, until it clears bolt 1, and lower the carrier assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Do not drive faster than 80 km/h.
■ Drive particularly carefully on wet and snow-covered road surfaces.

Technical data183Vehicle weight
Kerb weight, basic model
Optional equipment and accessories increase the kerb weight.
Loading information 3 73.ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 2)3)VanR9ML1H1100027001661120029001661H2120029001760-1771L2H1120029001691-1695H21200290017752)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.

184Technical data
ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight2)3)Combi, BusR9ML1H1100027001901120029001901L2H11200290019012)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 2)3)Platform cabR9ML2H11200290015502)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.

192Technical dataTyre pressuresTyreTyre pressure with full load8)Front
[kPa/bar] (psi)Rear
[kPa/bar] (psi)205/65 R16 C380/3.8 (55)420/4.2 (61)215/65 R16 C310/3.1 (45)340/3.4 (49)195/75 R16 C380/3.8 (55)420/4.2 (61)215/60 R17 C350/3.5 (51) 9)390/3.9 (57)10)8)
The spare wheel should be set to the highest applicable pressure shown in the table.
9) Combi/Bus: 320/3.2 (46) for non-motorway driving below 160 km/h.
10) Combi/Bus: 350/3.5 (51) for non-motorway driving below 160 km/h.

199
Manual transmission .................. 121
Messages ..................................... 91
Mirror adjustment ........................... 8
Mirrors .................................... 38, 39
Misted light covers .......................98
N
New vehicle running-in ..............113
Number plate light .....................150
O Object detection systems ...........130
Octane rating .............................. 182
Odometer ..................................... 81
Oil ............................................... 140
Oil, engine .......................... 176, 181
Oil pressure .................................. 88
Outside temperature ....................78
Overcab storage ..........................70
Overrun cut-off ........................... 117
P Parking ................................ 20, 119
Parking assist ............................ 130
Parking brake ............................ 123
Particulate filter ........................... 120
Performing work ........................139
Pollen filter ................................. 111
Power button ........................ 18, 114
Power outlets ............................... 79Power steering fluid....................142
Power windows ............................ 40
Preheating ........................... 88, 116
Puncture ..................................... 165
R Radio Frequency Identification (RFID) ..................................... 194
Radio remote control ...................21
Rear air conditioning system .....105
Rear doors ................................... 31
Rear fog light ............................... 89
Rear fog lights ........................ 95, 98
Rear heating system .................. 105
Rear seats .................................... 47
Rear view camera ...................... 132
Rear windows .............................. 41
Rear window wiper/washer .......... 77 Recommended fluids and lubricants ........................ 176, 181
Refuelling ................................... 134
Remote control ............................. 21
Reversing light ........................... 150
Reversing lights ........................... 98
Ride control systems ..................124
Roof load ...................................... 73
Roof rack ..................................... 73S
Safety belts ................................... 50
Safety net .................................... 71
Seat adjustment ....................... 7, 45
Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 50
Seat folding .................................. 46
Seat heating ................................. 47
Seat position ................................ 44
Seats ............................................ 69
Service ............................... 111, 174
Service display ............................ 82
Service information ....................174
Service vehicle soon .................... 86
Side airbag system ......................57
Sidelights ...................................... 95
Side turn signal lights ................149
Sliding door .................................. 31
Spare wheel ............................... 166
Spare wheel security tool ...........156
Speed limiter......................... 80, 130
Speedometer ............................... 80
Starting and operating ................113
Starting off ................................... 18
Starting the engine ...............18, 116
Steering ...................................... 113
Steering column controls ..............76
Steering wheel adjustment ......9, 75