2015 KIA SOUL stop start

627
What to do in an emergency
8. With the engine start/stop buttonposition on or ignition switch posi-
tion on, switch on the compressor
and let it run for approximately 5~7
minutes to fill the sealant up to
proper pressure. (refer to the Tire
and Wheels, chapter 8). The infla-
tion pressure of the tire after filling
is unimportant and will be
checked/corrected later.
Be careful not to overinflate the tire
and stay away from the tire when
filling it. 9. Switch off the compressor.
10. Detach the hoses from the
sealant bottle connector and
from the tire valve.
Return the Tire Mobility Kit to its stor-
age location in the vehicle.Distributing the sealant
11. Immediately drive approximately 4~6miles (7~10km or, about
10min) to evenly distribute the
sealant in the tire.
Do not exceed a speed of 50 mph
(80 km/h). If possible, do not fall
below a speed of 12 mph (20 km/h).
While driving, if you experience any
unusual vibration, ride disturbance or
noise, reduce your speed and drive
with caution until you can safely pull
off of the side of the road.
Call for road side service or towing.
When you use the Tire Mobility Kit,
the tire pressure sensors and wheel
may be damaged by sealant, remove
the sealant stained with tire pressure
sensors and wheel and inspect in
authorized dealer.
WARNING - Carbon monoxide
Do not leave your vehicle run-
ning in a poorly ventilated area
for extended periods of time.
Carbon monoxide poisoning
and suffocation can occur.
WARNING- Tire pressure
Do not attempt to drive your
vehicle if the tire pressure is
below 29 PSI(200kpa). This
could result in an accident due
to sudden tire failure.

Maintenance
26
7
Brake discs, pads, calipers
and rotors
Check the pads for excessive wear,
discs for run out and wear, and
calipers for fluid leakage.
For more information on checking
the pads or lining wear limit, we rec-
ommend you to refer to the Kia web-
site.
(http://www
.kiatechinfo.com)
Exhaust pipe and muffler
Visually inspect the exhaust pipes,
muffler and hangers for cracks, dete-
rioration, or damage. Start the
engine and listen carefully for any
exhaust gas leakage. Tighten con-
nections or replace parts as neces-
sary.
Suspension mounting bolts
Check the suspension connections
for looseness or damage. Retighten
to the specified torque.
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine
off, check for excessive free-play in
the steering wheel.
Check the linkage for bends or dam-
age. Check the dust boots and ball
joints for deterioration, cracks, or
damage. Replace any damaged
parts.
Drive shafts and boots
Check the drive shafts, boots and
clamps for cracks, deterioration, or
damage. Replace any damaged
parts and, if necessary, repack the
grease.
Air conditioning refrigerant
Check the air conditioning lines and
connections for leakage and dam-
age.

Maintenance
72
7
Engine compartment fuse panel
Description Fuse rating Protected component
IG1 40A IGN_SW(B1), BUTTON_START_RLY(IG1), BUTTON_START_RLY(ACC)
BLOWER 40A BLOWER_RLY, BLOWER_MOTOR
RR HTD 40A REAR_GLASS_HEATED_RLY,
ECU 2 30A MAIN_RLY, MAIN_RLY_COIL
ECU 3 15A ECU(AFTER_AIN_RELAY)
IGN COIL 20A IGNITION_COIL(POWER)
ECU 1 20A ECU(AFTER_MAIN_RELAY)
SENSOR 1 10A STOP_LAMP_SW(NORMAL_CLOSE), O2_SNSR, PURGE_CONTROL_SOLENOID_VALVE, OCV,
SENSOR 2 10A CMP, COOLING_FAN_LOW_RLY_COIL
INJECTOR 10A -
B/UP LAMP 10A RR_COMBI_LAMP(BACK_UP_LAMP)
WIPER 10A ECU(WIPER_SWITCH)
F/PUMP15AFUEL_PUMP_MOTOR
HORN15AHORN_RLY, HORN_RLY_COIL, HORN
H/LAMP WASHER20AHEAD_LAMP_WASHER_RLY, HEAD_LAMP_WASHER_RLY_COIL, HEAD_LAMP_WASHER_MOTOR

795
Maintenance
Do not operate the engine in con-fined or closed areas (such as
garages) any more than what is
necessary to move the vehicle in or
out of the area.
When the vehicle is stopped in an open area for more than a short
time with the engine running,
adjust the ventilation system (as
needed) to draw outside air into the
vehicle.
Never sit in a parked or stopped vehicle for any extended time with
the engine running.
When the engine stalls or fails to start, excessive attempts to restart
the engine may cause damage to
the emission control system.Operating precautions for catalyt-
ic converters
WARNING- Catalytic converter
Keep away from the catalytic
converter and exhaust system
while the vehicle is running or
immediately thereafter. The
exhaust and catalytic systems
are very hot and may burn you.
WARNING- Fire
Do not park, idle or drive the vehicle over or near flamma-
ble objects, such as grass,
vegetation, paper, leaves, etc.
A hot exhaust system can
ignite flammable items under
your vehicle.
Also, do not remove the heat sink around the exhaust sys-
tem, do not seal the bottom of
the vehicle or do not coat the
vehicle for corrosion control.
It may present a fire risk under
certain conditions.

Index
2I
A/V Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
62
Active ECO system. . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-42Active ECO operation . . . . . . . . . . . . . . . . . . . . . . . 5-42
Limitation of Active ECO operation . . . . . . . . . . . . 5-42
When Active ECO is activated . . . . . . . . . . . . . . . . . 5-42
Air bag collision sensors . . . . . . . . . . . . . . . . . . . . . . . 3-54
Air bag inflation conditions . . . . . . . . . . . . . . . . . . . . . 3-54
Air bag operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-38
Air bag warning label . . . . . . . . . . . . . . . . . . . . . . . . . . 3-60
Air bag warning light . . . . . . . . . . . . . . . . . . . . . . . . . . 3-40
Air bags. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 3-37 Air bag collision sensors . . . . . . . . . . . . . . . . . . . . . 3-54
Air bag inflation conditions . . . . . . . . . . . . . . . . . . . 3-54
Air bag warning label. . . . . . . . . . . . . . . . . . . . . . . . 3-60
Air bag warning light . . . . . . . . . . . . . . . . . . . . . . . . 3-40
Curtain air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-53
Driver's and passenger's front air bag . . . . . . . . . . . 3-49
Occupant Detection System (ODS) . . . . . . . . . . . . . 3-44
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-38
Side air bag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-52
SRS components and functions . . . . . . . . . . . . . . . . 3-41
Air cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-35\
Air Conditioning refrigerant label . . . . . . . . . . . . 4-109,122
Airconditioning system . . . . . . . . . . . . . . . . . . . . 4-100,110 Automatic climate control system . . . . . . . . . . . . . 4-110
Manual climate control system . . . . . . . . . . . . . . . 4-100 Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-143
Anti-lock brake system (ABS) . . . . . . . . . . . . . . . . . . . 5-27
Appearance care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-86
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-86
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-91
Armrest (rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
Audio remote control . . . . . . . . . . . . . . . . . . . . . . . . . 4-144
Audio system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-143 Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-143
Audio remote control . . . . . . . . . . . . . . . . . . . . . . . 4-144
Aux, USB and iPod
®port . . . . . . . . . . . . . . . . . . . 4-145
Speaker lightings . . . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Auto light position . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Auto start . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
44
Auto stop. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
5-43
Automatic climate control system . . . . . . . . . . . . . . . 4-110 Air Conditioning refrigerant label . . . . . . . . . . . . . 4-122
Automatic heating and air conditioning. . . . . . . . . 4-111
Checking the amount of air conditioner refrigerantand compressor lubricant . . . . . . . . . . . . . . . . . . . 4-121
Climate control air filter. . . . . . . . . . . . . . . . . . . . . 4-120
Manual heating and air conditioning . . . . . . . . . . . 4-112
System operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-118
Automatic transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17 Automatic transaxle operation . . . . . . . . . . . . . . . . . 5-17
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 5-22
Ignition key interlock system . . . . . . . . . . . . . . . . . . 5-22
Shift lock system . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
A

I3
Index
Shift-lock override . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
Sports mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-19
Aux, USB and iPod
®port. . . . . . . . . . . . . . . . . . . . . . 4-145
Base curb weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-65
Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 7-43
Battery replacement (Remote keyless entry) . . . . . . . . . 4-7
Battery replacement (Smart key) . . . . . . . . . . . . . . . . . 4-16
Battery saver function . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
Before driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 Before entering vehicle . . . . . . . . . . . . . . . . . . . . . . . 5-4
Before starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4
Necessary inspections . . . . . . . . . . . . . . . . . . . . . . . . 5-4
Brake system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23 Anti-lock brake system (ABS) . . . . . . . . . . . . . . . . . 5-27
Electronic stability control (ESC) . . . . . . . . . . . . . . 5-29
Good braking practices . . . . . . . . . . . . . . . . . . . . . . 5-35
Hill-start assist control (HAC) . . . . . . . . . . . . . . . . . 5-34
Parking brake - Hand type . . . . . . . . . . . . . . . . . . . . 5-25
Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23
Vehicle stability management (VSM) . . . . . . . . . . . 5-33
Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
Bulb replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-74
Bulb wattage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Button start/stop, see engine start/stop button . . . . . . . . 5-9 Capacities (Lubricants) . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Care
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-86
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-91
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-46\
Cargo area cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-139
Cargo weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-65
Center console storage . . . . . . . . . . . . . . . . . . . . . . . . 4-128
Central door lock switch. . . . . . . . . . . . . . . . . . . . . . . . 4-19
Certification label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-63
Checking tire inflation pressure . . . . . . . . . . . . . . . . . . 7-47
Child restraint system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-29 Lower anchor system . . . . . . . . . . . . . . . . . . . . . . . . 3-35
Seat belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-31\
Tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . 3-34
Child-protector rear door lock . . . . . . . . . . . . . . . . . . . 4-21
Clean air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
127
Climate control air filter . . . . . . . . . . . . . . . 4-108,120,7-37
Clothes hanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137
Combined instrument, see instrument cluster . . . . . . . 4-50
Compact spare tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20
Compact spare tire replacement . . . . . . . . . . . . . . . . . . 7-50
Cool box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
129
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 7-29
Cooling fluid, see engine coolant . . . . . . . . . . . . . . . . . 7-29
Crankcase emission control system . . . . . . . . . . . . . . . 7-93
B
C

I5
Index
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Engine Coolant Temperature guage . . . . . . . . . . . . . . . 4-53
Engine number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
27
Engine overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . . . 5-9Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . 5-9
Illuminated engine start/stop button. . . . . . . . . . . . . . 5-9
Starting the engine with a smart key . . . . . . . . . . . . 5-11
Engine will not start . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
Evaporative emission control System . . . . . . . . . . . . . . 7-93
Exhaust emission control system . . . . . . . . . . . . . . . . . 7-94
Explanation of scheduled maintenance items . . . . . . . 7-23
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-86
Exterior features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-141 Mounting bracket for roof carrier . . . . . . . . . . . . . 4-141
Exterior overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Flat tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 6-13 Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Compact spare tire . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-13
Removing and storing the spare tire . . . . . . . . . . . . 6-15
Tire Mobility Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-23
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137 Fluid
Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Folding the rear seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89
Front seat adjustment - Manual . . . . . . . . . . . . . . . . . . . 3-5
Front seat adjustment - power . . . . . . . . . . . . . . . . . . . . 3-6
Front wiper deicer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-70
Fuel filler lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54\
Fuel requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 Do not use methanol . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
Gasoline containing alcohol and methanol . . . . . . . . 1-3
Gasoline containing MMT . . . . . . . . . . . . . . . . . . . . . 1-4
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-63\
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 7-61 Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-63
Fuse/relay panel description. . . . . . . . . . . . . . . . . . . 7-66
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . 7-62
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-65
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-52 Engine Coolant Temperature guage . . . . . . . . . . . . . 4-53
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
F
G

Index
6I
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
Outside Temperature Gauge . . . . . . . . . . . . . . . . . . . 4-55
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
GAW (Gross axle weight) . . . . . . . . . . . . . . . . . . . . . . 5-65
GAWR (Gross axle weight rating) . . . . . . . . . . . . . . . . 5-65
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12\
8
Glove box lamp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-97
Gross vehicle weight. . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
GVW (Gross vehicle weight) . . . . . . . . . . . . . . . . . . . . 5-65
GVWR (Gross vehicle weight rating) . . . . . . . . . . . . . 5-65
Hazard warning flasher . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Hazardous driving conditions . . . . . . . . . . . . . . . . . . . . 5-50
Headlamp escort . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
Headlight bulb replacement . . . . . . . . . . . . . . . . . . . . . 7-75
Headlight position. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
Headrest(front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Headrest(rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Heated steering wheel. . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-100 Automatic climate control system . . . . . . . . . . . . . 4-110
Manual climate control system . . . . . . . . . . . . . . . 4-100
High beam operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Hight adjustment (seat belt) . . . . . . . . . . . . . . . . . . . . . 3-19
Highway driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54 Hill-start assist control (HAC) . . . . . . . . . . . . . . . . . . . 5-34
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 4-29
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 4-42
How to use this manual . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Ignition key interlock system . . . . . . . . . . . . . . . . . . . . 5-22
Ignition switch position . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
Illuminated engine start/stop button . . . . . . . . . . . . . . . . 5-9
Illuminated ignition switch . . . . . . . . . . . . . . . . . . . . . . . 5-6
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Indicator light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-79
Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
Instrument cluster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
52
Instrument panel illumination . . . . . . . . . . . . . . . . . 4-51
LCD Display Control . . . . . . . . . . . . . . . . . . . . . . . . 4-51
Transaxle Shift Indicator . . . . . . . . . . . . . . . . . . . . . 4-56
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . . . 7-62
Instrument panel overview . . . . . . . . . . . . . . . . . . . . . . . 2-5
Interior care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-91\
Interior features. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-131 Cargo area cover. . . . . . . . . . . . . . . . . . . . . . . . . . . 4-140
Clothes hanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137
Cup holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-131
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . 4-138
Luggage net holder. . . . . . . . . . . . . . . . . . . . . . . . . 4-139
H
I