2015 KIA BORREGO maintenance schedule

Maintenance
16
7
G050600AUN
Vapor hose and fuel filler cap
The vapor hose and fuel filler cap should
be inspected at those intervals specified
in the maintenance schedule. Make sure
that a new vapor hose or fuel filler cap iscorrectly replaced.
G050700AUN
Vacuum crankcase ventilation hoses (if equipped)
Inspect the surface of hoses for evidence
of heat and/or mechanical damage. Hard
and brittle rubber, cracking, tears, cuts,
abrasions, and excessive swelling indi-
cate deterioration. Particular attention
should be paid to examine those hose
surfaces nearest to high heat sources,
such as the exhaust manifold. Inspect the hose routing to assure that the hoses do not come in contact with
any heat source, sharp edges or movingcomponent which might cause heat dam-
age or mechanical wear. Inspect all hose
connections, such as clamps and cou-
plings, to make sure they are secure, and
that no leaks are present. Hoses should
be replaced immediately if there is any
evidence of deterioration or damage. G050800AUN
Air cleaner filter
A Genuine Kia air cleaner filter is recom- mended when the filter is replaced.
G050900BUN
Spark plugs (for gasoline engine)
Make sure to install new spark plugs of
the correct heat range. G051000AHM
Valve clearance
(for 3.8L gasoline engine)
Inspect for excessive valve noise and/or
engine vibration and adjust if necessary.
An authorized Kia dealer should perform
the operation. G051100AHM Cooling system
Check the cooling system components,
such as the radiator, coolant reservoir,
hoses and connections for leakage and
damage. Replace any damaged parts.G051200AUN Coolant The coolant should be changed at the
intervals specified in the maintenance
schedule.
Automatic transmission fluid (if equipped)
Automatic transmission fluid should not be
checked under normal usage conditions.
But in severe conditions, the fluid should
be changed at an authorized Kia dealerin accordance to the scheduled mainte-
nance at the beginning of this chapter.
✽✽
NOTICE
Automatic transmission fluid color is
basically red.
As the vehicle is driven, the automatic
transmission fluid will begin to look
darker.
It is normal condition and you should
not judge the need to replace the fluid
based upon the changed color.
WARNING
Do not disconnect and inspect spark plugs when the engine is hot.
You may burn yourself.

719
Maintenance
G060200ASA Changing the engine oil and filter
Have engine oil and filter changed by an
authorized Kia dealer according to theMaintenance Schedule at the beginningof this section.G070000BHM The high-pressure cooling system has a
reservoir filled with year round antifreeze
coolant. The reservoir is filled at the fac-
tory.
Check the antifreeze protection and
coolant level at least once a year, at thebeginning of the winter season, and
before traveling to a colder climate.G070100BFD
Checking the coolant level
WARNING
Used engine oil may cause skin irri- tation or cancer if left in contact
with the skin for prolonged periods
of time. Used engine oil contains
chemicals that have caused cancer
in laboratory animals. Always pro-
tect your skin by washing your
hands thoroughly with soap and
warm water as soon as possibleafter handling used oil.
ENGINE COOLANT
WARNING
Removing radiatorcap
Never attempt to remove the radi- ator cap while the engine is oper-
ating or hot. Doing so might leadto cooling system and engine
damage. Also, hot coolant orsteam could cause serious per-
sonal injury.
Turn the engine off and wait until it cools down. Use extreme care
when removing the radiator cap.
Wrap a thick towel around it, and
turn it counterclockwise slowly to
the first stop. Step back while the
pressure is released from thecooling system.
When you are sure all the pres-
sure has been released, press
down on the cap, using a thick
towel, and continue turning coun-
terclockwise to remove it.
(Continued)
CAUTION
Do not drive with no enginecoolant. It may cause water pumpfailure and engine seizure, etc.
When the engine overheats from low engine coolant, suddenlyadding engine coolant may causecracks in the engine. To preventdamage, add engine coolant
slowly in small quantities.

721
Maintenance
For mixture percentage, refer to the fol-
lowing table.G070200AHM Changing the coolant
Have the coolant changed by an author-
ized Kia dealer according to theMaintenance Schedule at the beginningof this section.
WARNING
Radiator cap
Do not remove the radiator cap when the engine and radiator are
hot. Scalding hot coolant and
steam may blow out under pres-
sure causing serious injury.
OHM072004N
CAUTION
Put a thick cloth around the radiator cap before refilling the coolant inorder to prevent the coolant from overflowing into engine parts suchas the alternator.
WARNING - Coolant
Do not use radiator coolant or antifreeze in the washer fluid
reservoir.
Radiator coolant can severely obscure visibility when sprayed
on the windshield and may cause
loss of vehicle control or damage
the paint and body trim.
-15°C (5°F) 35 65
-25°C (-13°F) 40 60
-35°C (-31°F) 50 50
-45°C (-49°F) 60 40
Ambient
Temperature Mixture Percentage (volume)
Antifreeze Water

727
Maintenance
Replace the filter according to the
Maintenance Schedule.
If the vehicle is operated in extremelydusty or sandy areas, replace the ele-ment more often than the usual recom-
mended intervals. (Refer to“Maintenance under severe usage condi-tions” in this section.)
G170100BEN Filter inspection The climate control air filter should be replaced according to the maintenance
schedule. If the vehicle is operated in
severely air-polluted cities or on dusty
rough roads for a long period, it shouldbe inspected more frequently and
replaced earlier. When you replace the
climate control air filter, replace it per-
forming the following procedure, and be
careful to avoid damaging other compo-
nents. G170200AEN Filter replacement
1. Open the glove box and remove thesupport rod (1).
CAUTION
Do not drive with the air cleaner
removed; this will result in exces-sive engine wear.
When removing the air cleaner fil- ter, be careful that dust or dirt
does not enter the air intake, ordamage may result.
Use a Kia genuine part. Use of non-genuine parts could damagethe air flow sensor or turbocharg-
er.
CLIMATE CONTROL AIR FILTER (IF EQUIPPED)
OHM079014

Maintenance
68
7
EMISSION CONTROL SYSTEM (IF EQUIPPED)
G270000AHM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty infor-
mation contained in the Warr anty &
Maintenance book in y our vehicle.
Your vehicle is equipped with an emis-
sion control system to meet all applicable
emission regulations. There are three emission control sys-
tems, as follows.
(1) Crankcase emission control system
(2) Evaporative emission control system(3) Exhaust emission control system In order to assure the proper function of
the emission control systems, it is rec-
ommended that you have your vehicle
inspected and maintained by an author-
ized Kia dealer in accordance with the
maintenance schedule in this manual. Caution for the Inspection and
Maintenance Test (With Electronic
Stability Program (ESP) system)
To prevent the vehicle from misfir-
ing during dynamometer testing,
turn the Electronic Stability
Program (ESP) system off by press-
ing the ESP switch.
After dynamometer testing is com- pleted, turn the ESP system back on
by pressing the ESP switch again. G270100AUN
1. Crankcase emission control
system
The positive crankcase ventilation sys-
tem is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valveinto the induction system. G270200AEN
2. Evaporative emission control system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos-
phere.

Index
4
I
Defroster (Rear window) ···············································4-88
Defrosting (Windshield) ··············································4-114
Digital clock ·································································4-123Dimensions ······································································8-2
Displays, see instrument cluster ····································4-47
Display illumination, see instrument panel illumination ··· 4-49
Door courtesy lamp bulb replacement ····························7-60
Door locks ·······································································4-14 Central door lock switch ··········································4-15
Child-protector rear door lock ·································4-17
Downhill brake control (DBC) ······································5-37
Drinks holders, see cup holders ···································4-121
Driver's air bag ·······························································3-48
Driver position memory system······································4-33
Driving at night ······························································5-51
Driving in flooded areas ················································5-52
Driving in the rain ··························································5-52
Economical operation ····················································5-48
Electric chromic mirror (ECM) ·····································4-40
Electric chromic mirror (ECM) with compass ··············4-41
Electronic stability program (ESP) ·································5-33
Emergency starting ··························································6-4 Jump starting ······························································6-4
Push starting ·······························································6-5
Emergency tailgate safety release ··································4-19 Emergency towing ·························································6-19
Emergency while driving ·················································6-2
Emergency commodity ··················································6-22
Emission control system ················································7-68
Crankcase emission control system ·························7-68
Evaporative emission control system ·······················7-68
Exhaust emission control system ·····························7-69
Engine compartment ················································2-4, 7-2
Engine coolant ·······························································7-19
Engine number ·································································8-8
Engine oil ·······································································7-18
Engine overheats ······························································6-6
Engine start/stop button ···················································5-6
Engine temperature gauge ·············································4-50
Engine will not start ·························································6-3
Evaporative emission control system ····························7-68
Exhaust emission control system ···································7-69Explanation of scheduled maintenance items ················7-15
Exterior care ···································································7-62
Exterior features ···························································4-128 Roof rack ································································4-128
Side step ··································································4-129
Flat tire ·············································································6-7 Changing tires ····························································6-9
Compact spare tire ···················································6-14
E
F

I7
Index
Lighting ··········································································4-75
Battery saver function ··············································4-75
Rescue mode function ···············································4-75
Locking differential ························································5-40
Lubricants and capacities ·················································8-4
Luggage box ·································································4-119Luggage net (holder) ····················································4-126
Luggage rack, see roof rack ·········································4-128
Lumbar support ······················································3-9, 3-13
Main fuse ········································································7-48 Maintenance Explanation of scheduled maintenance items ···········7-15Maintenance services ················································· 7-4
Maintenance under severe usage conditions ·············7-13 Normal maintenance schedule ····································7-9
Owner maintenance ····················································7-6
Scheduled maintenance service ·································7-8
Tire maintenance ······················································7-40
Maintenance services ·······················································7-4
Manual climate control system ······································4-90 Air conditioning ·······················································4-96
Climate control air filter ·········································4-102
Heating and air conditioning ····································4-92
Manual heating and air conditioning ···························4-106
Memory fuse ··································································7-47 Mirrors ···········································································4-40
Day/night rearview mirror ·······································4-40
Electric chromic mirror (ECM) ·······························4-40
Electric chromic mirror (ECM) with compass ········4-41
Inside rearview mirror ··············································4-40
Outside rearview mirror ···········································4-45
Moonroof, see panorama sunroof ··································4-29
Multi box·······································································4-119
Neck restraints, see headrest ··································3-5, 3-14Odometer ·······································································4-52
Oil (Engine) ···································································7-18
Outside rearview mirror ·················································4-45
Outside thermometer·····················································4-124
Overheats ·········································································6-6
Owner maintenance ·························································7-6
Panorama sunroof ··························································4-29
Parking assist system ······················································4-70
Parking brake inspect ·····················································7-24
Parking brake ·································································5-29
O
M
N
P

Index
8
I
Passenger's front air bag ················································3-48
Position light bulb replacement ····························7-55, 7-57
Power adjustable pedals ··················································4-36
Power brakes ··································································5-28
Power outlet ·································································4-122
Power steering ································································4-37
Power steering fluid ·······················································7-23
Power window lock button ············································4-23
Pre-tensioner seat belt ····················································3-27
Push starting ·····································································6-5
Rear combination light bulb replacement ······················7-58
Rear fog light bulb replacement ····································7-60
Rear seat ·········································································3-14
Rear parking assist system ·············································4-67
Rearview camera ····························································4-74
Recommended cold tire inflation pressures ··················7-35
Recommended lubricants and capacities ·························8-4
Recommended SAE viscosity number ······················8-5
Remote keyless entry ·······················································4-9
Rescue mode function·····················································4-75
Road warning ···································································6-2
Rocking the vehicle ·······················································5-50
Roof rack ·····································································4-128 Scheduled maintenance service ·······································7-8
Normal maintenance schedule ····································7-9
Maintenance under severe usage conditions ·············7-13
Seat belts ········································································3-21 Pre-tensioner seat belt ··············································3-27
3 point rear center belt ·············································3-24
Lap belt ····································································3-25
Lap/shoulder belt ······················································3-22
Seat belt warning ···························································3-22
Seat warmer ·····································································3-9
Seatback pocket ·····························································3-11Seats ·················································································3-2 Air ventilation seat ····················································3-10Armrest ·····································································3-16
Headrest ····························································3-5, 3-14
Folding the rear seat ·················································3-17
Front seat adjustment - manual ··································3-4
Front seat adjustment - power ··································3-12
Lumbar support ·················································3-9, 3-13
Rear seat ···································································3-14
Seatback pocket ························································3-11
Seat warmer ································································3-9
Shift lock system ···························································5-15
Side impact air bag ························································3-50
Side repeater light bulb replacement ·····························7-57
R
S