2015 HYUNDAI I20 torque

!

$#'#"'"' %'$%'&&&%
8.Insert the jack handle into the jackand turn it clockwise, raising the
vehicle until the tire clears the ground. Make sure the vehicle is
stable on the jack. 9.Loosen the lug nuts with the wheel
lug nut wrench and remove them
with your fingers. Remove the
wheel from the studs and lay it flat
on the ground out of the way.
Remove any dirt or debris from the
studs, mounting surfaces, and
wheel.
10. Install the spare tire onto the studs of the hub.
11. Tighten the lug nuts with your fin- gers onto the studs with the
smaller end of the lug nuts clos-
est to the wheel.
12. Lower the vehicle to the ground by turning the jack handle coun-
terclockwise. 13. Use the wheel lug nut wrench to
tighten the lug nuts in the order
shown. Double-check each lug
nut until they are tight. After
changing tires, we recommend
that an authorized HYUNDAI
dealer tighten the lug nuts to their
proper torque as soon as possi-
ble. T
T
he wheel lug nut should be
tightened to 11~13 kgf.m (79~94
lbf.ft).
OIB067008
OIB067007

When driving with the compact spare
tire mounted to your vehicle:
• Check the tire pressure afterinstalling the compact spare tire.
The compact spare tire should be
inflated to 420 kPa (60 psi).
• Do not take this vehicle through an automatic car wash while the com-
pact spare tire is installed.
• Do not use the compact spare tire on any other vehicle because this
tire has been designed especially
for your vehicle.
• The compact spare tire’s tread life is shorter than a regular tire.
Inspect your compact spare tire
regularly and replace worn com-
pact spare tires with the same size
and design, mounted on the same
wheel.
• Do not use more than one compact spare tire at a time.
• Do not tow a trailer while the com- pact spare tire is installed.
IInformation
When the original tire and wheel are
repaired and reinstalled on the vehi-
cle, the lug nut torque must be set cor-
rectly to prevent wheel vibration. The
correct lug nut tightening torque is
11~13 kgf.m (79~94 lbf.ft).
To prevent damaging the compact
spare tire and your vehicle:
• Drive slowly enough for the road condition s to avoid all hazards,
such as a potholes or debris.
• Avoid driving over obstacles. The compact spare t ire diameter is
smaller than the diameter of a con-
ventional tire and reduces the
ground clearance appr oximately
25 mm (1 inch).
• Do not use tire chains on the com- pact spare tire. Because of the
smaller siz e, a tire chain will not fit
properly.
• Do not use the compact spare tire on any other wheels, nor shoul d
standard tires, snow tires, wheel
covers or trim rings be used with
the compact spare wheel.NOTICE
i
!
$#'#"'"' %'$%'&&&%

1.%$
,204/3424-3
PParking brakeInspect the parking brake system
including the parking brake pedal
and cables. Brake discs, pads, calipers and
rotorsCheck the pads for excessive wear,
discs for run out and wear, and
calipers for fluid leakage.Suspension mounting boltsCheck the suspension connections
for looseness or damage. Retighten
to the specified torque.
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine
off, check for excessive free-play in
the steering wheel.
Check the linkage for bends or dam-
age. Check the dust boots and ball
joints for deterioration, cracks, or damage. Replace any damaged
parts.
Drive shafts and bootsCheck the drive shafts, boots and
clamps for cracks, deterioration, or
damage. Replace any damaged
parts and, if necessary, repack the
grease.Air conditioning refrigerant
(if equipped)Check the air conditioning lines and
connections for leakage and dam-
age.

!

+'-"-'($-),%**),%#+&*-,")&#($-),
$(%)&'!))#
When replacing tires, use the same size originally supplied with the vehicle.
Using tires of a different size can damage the related parts or make it work irregularly.
CAUTION
*\f : Normal load : Up to 2 personsItem
Tire size Wheel size Inflation pressure (psi)
Wheel lug nut
torque
kgf•m (lbf•ft, N•m)
Normal load *
\fMaximum load
Front Rear Front Rear
Full size tire 5 Door
\f85/70R\f4 5.5J x \f4 230 (33) 2\f5(3\f) 230(33) 230(33)
\f\f~\f3
(79~94, \f07~\f27)
\f95/55R\f6 6.0J x \f6 230 (33) 2\f5(3\f) 230(33) 230(33)
Cross \f85/65R\f5 5.5J x \f5 230 (33) 2\f5(3\f) 230(33) 230(33)
\f95/55R\f6 6.0J x \f6 230 (33) 2\f5(3\f) 230(33) 230(33)
• Only steel wheel provided as a spare wheel with all variants of vehicle.
• Spare tire make can be from any tire manuafacturer i.e. Bridgestone/MRF/Apollo.
• It is permissible to add 20 kPa (3 psi) to the standard tire pressure specification if colder temperatures are expect\b
ed soon. Tires typically lose 7 kPa (\f psi) for every 7°C (\f2°F) temperature drop. If extreme temperature variations
are expected, rec
heck your tire pressure as necessary to keep them properly inflated.
• An air pressure generally decreases, as you drive up to a high\baltitude area above sea level. Thus, if you plan to drive a high\baltitude area, check the tire pressures in advance. If necessary, inflate them to a proper level (Air infla\b
tion per altitude: +\f0 kPa/\f km (+2.4 psi/\f mile).
NOTICE