2015 FORD F150 transmission oil

Specification
Name
Penetrating and Lock Lubricant
MXL-1
If you use oil and fluids that do not meet
the defined specification and viscosity
grade, this may lead to:
• Component damage which is not
covered by the vehicle warranty.
• Longer engine cranking periods.
• Increased emission levels.
• Reduced engine performance.
• Reduced fuel economy.
• Degraded brake performance.
Only use fluid that meets Ford
specifications. Motor oils of the
recommended viscosity grade that meet
API SN requirements and display the API
Certification Mark for gasoline engines are
also acceptable. Do not use oil labeled
with API SN service category unless the
label also displays the API certification
mark. An oil that displays this symbol conforms
to current engine, emission system and
fuel economy performance standards of
the International Lubricant Standardization
and Approval Committee (ILSAC). Do not use supplemental engine oil
additives because they are unnecessary
and could lead to engine damage that may
not be covered by your vehicle warranty.
Note:
Ford recommends using DOT 4 Low
Viscosity (LV) High Performance Brake Fluid
or equivalent meeting WSS-M6C65-A2. Use
of any fluid other than the recommended
fluid may cause degraded brake
performance and not meet the Ford
performance standards. Keep brake fluid
clean and dry. Contamination with dirt,
water, petroleum products or other
materials may result in brake system
damage and possible failure.
Note: Automatic transmissions that require
MERCON LV transmission fluid should only
use MERCON LV transmission fluid. The
use of any other fluid may cause
transmission damage.
380
F-150 (), enUSA, First Printing Capacities and SpecificationsE142732

Multi-Point inspection
Hazard warning system operation
Accessory drive belt(s)
Horn operation
Battery performance
Radiator, cooler, heater and air conditioninghoses
Engine air filter
Suspension components for leaks ordamage
Exhaust system
Steering and linkage
Exterior lamps operation
Tires (including spare) for wear and properpressure**
Fluid levels *
; fill if necessary
Windshield for cracks, chips or pits
For oil and fluid leaks
Washer spray and wiper operation
Half-shaft dust boots
* Brake, coolant recovery reservoir, automatic transmission and window washer
** If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED
MAINTENANCE
Intelligent Oil-Life Monitor
Your vehicle is equipped with an Intelligent
Oil-Life Monitor that determines when you
should change the engine oil based on how
your vehicle is used. By using several
important factors in its calculations, the
monitor helps reduce the cost of owning
your vehicle and reduces environmental
waste at the same time. This means you do not have to remember
to change the oil on a mileage-based
schedule. Your vehicle lets you know when
an oil change is due by displaying ENGINE
OIL CHANGE DUE or OIL CHANGE
REQUIRED in the information display.
The following table provides examples of
vehicle use and its impact on oil change
intervals. It is a guideline only. Actual oil
change intervals depend on several factors
and generally decrease with severity of
use.
521
F-150 (), enUSA, First Printing Scheduled Maintenance

When to expect the OIL CHANGE REQUIRED message
Vehicle use and example
Interval
Normal
7500-10000 miles
(12000-16000 km) Normal commuting with highway driving
No, or moderate, load or towing
Flat to moderately hilly roads
No extended idling
Severe
5000-7499 miles
(8000-11999 km) Moderate to heavy load or towing
Mountainous or off-road conditions
Extended idling
Extended hot or cold operation
Extreme
3000-4999 miles
(4800-7999 km) Maximum load or towing
Extreme hot or cold operation
Normal Maintenance Intervals At every oil change interval as indicated by the information display
*
Change engine oil and filter. **
Rotate tires, inspect tire wear and measure tread depth.
Perform a multi-point inspection (recommended).
Inspect the automatic transmission fluid level (if equipped with dipstick). Consult your
dealer for requirements.
Inspect the brake pads, shoes, rotors, drums, brake linings, hoses and parking brake.
Inspect the engine cooling system strength and hoses.
Inspect the exhaust system and heat shields.
Inspect front axle and U-joints. Lubricate if equipped with grease fittings (Four –wheel
drive vehicles).
Inspect the half-shaft boots.
522
F-150 (), enUSA, First Printing Scheduled Maintenance

At every oil change interval as indicated by the information display
*
Inspect the steering linkage, ball joints, suspension, tire-rod ends, driveshaft and U-
joints. Lubricate any areas with grease fittings.
Inspect the wheels and related components for abnormal noise, wear, looseness or
drag.
* Do not exceed one year or 10000 miles (16000 kilometers) between service intervals.
** Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. Other maintenance items
1
Replace climate-controlled (heated and cooled) seat filter
(if equipped).
Every 30000 miles (48000
km)
Replace engine air filter.
Change engine coolant.2
At 100000 miles (160000
km)
Replace spark plugs.
Every 100000 miles
(160000 km) Inspect accessory drive belt(s). 3
Change automatic transmission fluid and filter.
Every 150000 miles
(240000 km) Change front axle fluid (Four-wheel drive vehicles).
Change rear axle fluid.
Change transfer case fluid (Four-wheel drive vehicles).
Replace accessory drive belt(s).
1 Perform these maintenance items within 3000 miles (4800 kilometers) of the last
engine oil and filter change. Do not exceed the designated distance for the interval.
2 Initial replacement at six years or 100000 miles (160000 kilometers), then every three
years or 50000 miles (80000 kilometers).
3 After initial inspection, inspect every other oil change until replaced.
523
F-150 (), enUSA, First Printing Scheduled Maintenance

SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE
If you operate your vehicle primarily in any
of the following conditions, you need to
perform extra maintenance, as indicated.
If you operate your vehicle
occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician. Perform the services shown in the
following tables when specified or within
3000 mi (4,800 km)
of the OIL CHANGE
REQUIRED message appearing in the
information display.
• Example 1
: The OIL CHANGE
REQUIRED message comes on at
28,751 mi (46,270 km). Perform the
30000 mi (48,000 km) automatic
transmission fluid replacement.
• Example 2
: The OIL CHANGE
REQUIRED message has not come
on, but the odometer reads 30000 mi
(48,000 km)
(for example, the
Intelligent Oil-Life Monitor was reset
at
25000 mi (40,000 km)). Perform
the engine air filter replacement. Towing a trailer or using a car-top carrier
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Sched-
uled Maintenance chart.
As required
Inspect and lubricate U-joints.
Inspect frequently, service
as required
See axle maintenance items under
Exceptions.
Change transfer case fluid (Four-wheel drive vehicles).
Every
60000 mi
(96,000 km) Replace spark plugs.Extensive idling or low-speed driving for long distances, as in heavy commercial use
(such as delivery, taxi, patrol car or livery)
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Sched-
uled Maintenance chart.
As required
Replace engine air filter.
Inspect frequently, service
as required
Change transfer case fluid (Four-wheel drive vehicles).
Every
60000 mi
(96,000 km) Replace spark plugs.
524
F-150 (), enUSA, First Printing Scheduled Maintenance

Fuel Quality....................................................169
Choosing the Right Fuel With a Flex Fuel
Vehicle (If Equipped)................................... 169
Choosing the Right Fuel Without a Flex Fuel Vehicle (If Equipped)................................... 169
Octane Recommendations............................ 169
Fuel Shutoff...................................................278
Fuses................................................................288
Fuse Specification Chart..........................288 Passenger Compartment Fuse
Panel.................................................................. 293
Power Distribution Box................................... 288
G
Garage Door Opener See: Universal Garage Door Opener.............151
Gauges................................................................97 Engine Coolant Temperature Gauge............99
Engine Oil Pressure Gauge............................... 99
Fuel Gauge............................................................. 99
Information Display........................................... 100
Transmission Fluid Temperature Gauge................................................................ 100
Type 1 and 2............................................................ 97
Type 3....................................................................... 98
General Information on Radio Frequencies...................................................55
Intelligent Access................................................. 55
General Maintenance Information........518 Multi-Point Inspection..................................... 520
Owner Checks and Services........................... 519
Protecting Your Investment............................ 518
Why Maintain Your Vehicle?.......................... 518
Why Maintain Your Vehicle at Your Dealership?...................................................... 518
Getting Assistance Outside the U.S. and Canada.........................................................285
Getting the Services You Need...............282 Away From Home.............................................. 282
H
Handbrake See: Parking Brake.............................................. 192
Hazard Warning Flashers
..........................278
HDC See: Using Hill Descent Control................... 200Head Restraints
..............................................141
Adjusting the Head Restraint......................... 142
Heated Seats..................................................147 Rear Heated Seats............................................. 148
Heated Windows and Mirrors..................139 Heated Exterior Mirror....................................... 139
Heated Rear Window........................................ 139
Heating See: Climate Control......................................... 133
Hill Start Assist
..............................................195
Switching the System On and Off...............196
Using Hill Start Assist....................................... 196
Hints on Controlling the Interior Climate...........................................................137
Cooling the Interior Quickly............................ 138
General Hints........................................................ 137
Heating the Interior Quickly............................. 137
Recommended Settings for Cooling ..........138
Recommended Settings for Heating..........138
Side Window Defogging in Cold Weather............................................................. 139
Hints on Driving With Anti-Lock Brakes............................................................192
Hood Lock See: Opening and Closing the Hood...........297
I
Ignition Switch
..............................................160
In California (U.S. Only)............................283
Information Display Control.......................79
Information Displays
...................................105
General Information.......................................... 105
Information....................................................478 911 Assist.............................................................. 484
Alerts...................................................................... 484
Calendar............................................................... 484
Sirius Travel Link................................................. 481
SYNC Services (If Equipped, United States Only).................................................................. 478
Vehicle Health Report (If Equipped, United States Only)................................................... 486
539
F-150 (), enUSA, First Printing Index

W
Warning Lamps and Indicators..............100
Adaptive Cruise Control.................................. 100
Anti-Lock Braking System.............................. 100
Automatic High Beam...................................... 100
Auto Start-stop.................................................. 100
Battery..................................................................... 101
Blind Spot Monitor.............................................. 101
Brake System........................................................ 101
Check 4X4.............................................................. 101
Cruise Control....................................................... 101
Direction Indicator............................................... 101
Door Ajar................................................................. 101
Electric Park Brake.............................................. 101
Electronic Locking Differential....................... 101
Engine Coolant Temperature.......................... 101
Engine Oil.............................................................. 102
Fasten Safety Belt.............................................. 102
Four-Wheel Drive Indicators.......................... 102
Front Airbag.......................................................... 102
Front Fog Lamps................................................ 102
High Beam............................................................. 102
Hill Descent........................................................... 102
Low Fuel Level..................................................... 103
Low Tire Pressure Warning............................. 103
Parking Lamps..................................................... 103
Powertrain Malfunction/Reduced Power/Electronic Throttle Control.........103
Service Engine Soon.......................................... 103
Sport Mode........................................................... 103
Traction and Stability Control....................... 103
Traction and Stability Control Off...............104
Transmission Tow/Haul................................... 104
Washer Fluid Check...................................308
Washers See: Cleaning the Exterior............................... 319
See: Wipers and Washers.................................. 81
Waxing.............................................................320
Wheel Nuts See: Changing a Road Wheel....................... 350
Wheels and Tires..........................................327 General Information.......................................... 327
Technical Specifications................................. 358
Windows and Mirrors...................................90
Windshield Washers.....................................82 Windshield Wipers.........................................81
Speed dependent wipers (if
equipped)........................................................... 81
Wipers and Washers......................................81
546
F-150 (), enUSA, First Printing Index