2015 FIAT FREEMONT manual transmission

Master Cylinder — Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the “Brake Warning Light” indicates system failure.
Check the fluid level in the master cylinder when
performing underhood services.
Clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the
fluid level up to the requirements described on the
brake fluid reservoir.
Overfilling of fluid is not recommended because it may
cause leaking in the system.
Fluid level can be expected to fall as the brake pads
wear. Brake fluid level should be checked when pads are
replaced. However, low fluid level may be caused by a
leak and a checkup may be needed.NOTE:
If your vehicle is equipped with a manual
transmission, the brake fluid reservoir supplies fluid
to both the brake system and the clutch release sys-
tem. The two systems are separated in the reservoir,
and a leak in one system will not affect the other
system. The manual transmission clutch release
system should not require fluid replacement during the
life of the vehicle. If the brake fluid reservoir is low and
the brake system does not indicate any leaks or other
problems, it may be a result of a leak in the hydraulic
clutch release system. See your local authorized dealer
for service.
Use only manufacturer's recommended brake fluid.
Refer to “Fluids, Lubricants, and Genuine Parts” in
“Technical Specifications” for further information.
WARNING!
• Use only manufacturer's recom-
m en

ded brake fluid. Refer to “Fluids, Lu-
bricants, and Genuine Parts” in “Technical Speci-
fications” for further information. Using the
wrong type of brake fluid can severely damage
your brake system and/or impair its perfor-
mance. The proper type of brake fluid for your
vehicle is also identified on the original factory
installed hydraulic master cylinder reservoir.
(Continued)
350
KNOWINGYOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICINGAND C ARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the
transmission is disassembled for any reason.
MANUAL TRANSMISSION (for versions/
markets, where provided)
Lubricant Selection
Use only manufacturers recommended transmission
fluid. Do not add any materials (other than leak detec-
tion dyes). Refer to “Fluids, Lubricants, and Genuine
Parts” in “Technical Specifications” for further informa-
tion.
Frequency Of Fluid Change
Change the manual transmission fluid at the intervals
shown in the “Maintenance Schedule” in this manual.
REAR DRIVE ASSEMBLY (RDA) – AWD
MODELS ONLY
Lubricant Selection
Use only the manufacturer's recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Technical
Specifications” for further information.Fluid Level Check
Visually inspect the unit at each oil change for leakage.
If leakage is detected, check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 4 mm below the fill
hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
POWER TRANSFER UNIT (PTU) – AWD
MODELS ONLY
Lubricant Selection
Use only the manufacturer's recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Technical
Specifications” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage.
If leakage is detected, Check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 4 mm below the fill
hole.
Add fluid, if necessary, to maintain the proper level.
354
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICINGAND C ARE
TECHNICAL
SPECIFICATIONS
CONTENTS

CHASSIS
ComponentFluids and Lubricants Specs (Genuine Parts)
Automatic Transmission (for
versions/markets, where provided) Totally synthetic lubricant that meets FIAT Classification 9.55550-AV4
(TUTELA TRANSMISSION FORCE4, Contractual Technical Reference
No F108.F11).
Manual Transmission (for versions/
markets, where provided) Grade SAE 75W synthetic lubricant that meets FIAT Classification 9.55550-
MZ6 (TUTELA TRANSMISSION GEARFORCE Contractual Technical Refer-
ence N° F002.F10)
Brake/Clutch Master Cylinder Synthetic fluid that meets FIAT Classification 9.55597, FMVSS n° 116, DOT 4,
ISO 4925, SAE J-1704 (TUTELA TOP 4, Contractual Technical Reference
N° F001.A93)
Power Steering Reservoir Totally synthetic lubricant that meets FIAT Classification 9.55550-AV4
(TUTELA TRANSMISSION FORCE4, Contractual Technical Reference
N° F108.F11)
Windshield/Rear Window Washer
Fluid Mixture of alcohol, water and surfactants that meets FIAT Classification
9.55522, CUNA NC 956-11 (TUTELA PROFESSIONAL SC35, Contractual
Technical Reference N° F201.D02)
387
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Brake Assist System . . . . . . ..................143
Brake Control System, Electronic ...............141
Brake, Parking ........................... .242
Brakes . . . . . . . . . . . . . . . . . .............140, 349
Brake System . . . ..................... .140, 349
Anti-Lock (ABS) . . . . . . . .................141
Fluid Check . . . . . . . ................... .350
Master Cylinder . ...................... .350
Parking ............................. .242
Warning Light . . . . . . . . ..................276
Brake/Transmission Interlock . .................248
Break-In Recommendations, New Vehicle ..........237
Brightness, Interior Lights . . . ..................96
Bulb Replacement . . ................... .300, 301
Bulbs, Light .......................... .236, 300
Camera, Rear . . ......................... .165
Capacities, Fluid .......................... .384
Caps, Filler Fuel ............................... .190
Oil (Engine) . . . . ............... .332, 334, 337
Power Steering . . . . .................... .150
Radiator (Coolant Pressure) ................348
Carbon Monoxide Warning . . .................234
Cargo Area Cover . . . . .................... .134
Cargo Area Features . . . . . ...................131
Cargo Compartment . . .................... .131
Light ............................... .131
Luggage Carrier . . . . . .................. .137
Cargo Load Floor . . ....................... .132
Cargo Management System . ..................132
Rollaway Tonneau Cover . .................134
Tri-Fold Load Floor . . . . . .................132Cargo Tie-Downs
......................... .133
Cargo (Vehicle Loading) ..................... .132
Cellular Phone ........................... .190
Chains, Tire ............................ .378
Char

t, Tire Sizing ......................... .362
Checking Your Vehicle For Safety ...............233
Checks, Safety ........................... .233
Child Safety Locks ........................ .121
Clean Air Gasoline ........................ .380
Cleaning Wheels ............................. .356
Windshield Wiper Blades ..................342
Climate Control ...........................70
Automatic .............................79
Manual................................70
Coin Holder ............................ .108
Cold Weather Operation ................... .239
Compact Disc (CD) Maintenance ...............189
Compact Spare Tire ....................... .374
Computer, Trip/Travel ........................30
Connector UCI ............................... .189
Universal Consumer Interface (UCI) ...........189
Conserving Fuel ............................29
Console, Floor .......................... .108
Console, Overhead ....................... .105
Coolant Pressure Cap (Radiator Cap) ............348
Cooling System .......................... .345
Adding Coolant (Antifreeze) ................347
Coolant Capacity ...................... .384
Coolant Level ..................... .346, 348
Diesel Engine ......................... .345
Disposal of Used Coolant ..................348
392
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICINGAND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

License . . . . . . . . . . . . ..................307
Lights On Reminder . . . . . . . . . . . ............94
Low Fuel ............................7,24
LowTire .............................275
Malfunction Indicator (Check Engine) ..........273
Map Reading . . . . . . . . . . . . ...............96
Parade Mode (Daytime Brightness) ............96
Park ............................... .301
Passing ...............................95
Reading ...............................96
RearFog ..........................278, 303
Rear Servicing . ........................ .305
Rear Tail Lamps ........................ .305
Seat Belt Reminder ..................... .276
Service .......................... .300, 301
Service Engine Soon (Malfunction Indicator) ......273
Side Marker .......................... .301
Side Repeater . . . ...................... .304
Tire Pressure Monitoring (TPMS) .........151, 275
Traction Control . . . .................... .147
Turn Signal ...............95, 236, 274, 301, 305
Vanity Mirror ...........................69
Warning (Instrument Cluster Description) .......273
Load Floor, Cargo ........................ .132
Loading Vehicle Tires ................................366
Locks . ................................ .119
Automatic Door . . . . . . . .................121
Auto Unlock ......................... .121
Child Protection . . . . . . ..................121
Door .............................. .119
Power Door . . . . . . . . . ..................120
Steering Wheel ..........................20 Low Tire Pressure System
................... .151
Lubrication, Body ......................... .341
LuggageRack(RoofRack)................... .137
Lug Nuts .............................. .282
Maintenance Free Battery ................... .338
Maintenance, General ...................... .335
Maintenance Pr

ocedures .................... .335
Maintenance Schedule . . . ................... .321
Maintenance, Sunroof ...................... .119
Malfunction Indicator Light (Check Engine) .........273
Manual Transaxle ......................... .354
Fluid Level Check ...................... .354
Lubricant Selection ..................... .354
Manual Transmission ....................... .245
Frequency of Fluid Change .................354
Lubricant Selection ..................... .354
Map/Reading Lights ..........................96
Marker Lights, Side ........................ .301
Master Cylinder (Brakes) .................... .350
Mini-Trip Computer .........................30
Mirrors............................. .66, 106
Automatic Dimming ......................66
Electric Powered .........................67
Electric Remote .........................67
Exterior Folding .........................68
Heated ...............................69
Outside ...............................66
Rearview ..............................66
Vanity ................................69
Mode Fuel Saver .............................29
Modifications/Alterations, Vehicle .................5
397
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Replacement . . ....................... .377
Rotation . . . . . . . . . ................... .359
Safety ........................... .361, 369
Sizes ............................... .362
SnowTires ............................372
Spare Tire ........................... .284
Spinning . . . . . . ....................... .375
Trailer Towing ........................ .264
Tread Wear Indicators ................... .376
Tire Safety Information . .................... .361
Tire Service Kit .......................... .293
Tongue Weight/Trailer Weight . . . . . ............262
To Open Hood .......................... .136
Towing . ............................... .258
Disabled Vehicle . . . . . . . .................318
Guide . . . . . . . . . . . . . . . . ...............262
Recreational .......................... .270
Weight . . . . . . . . . . . . . .................262
Towing Eyes ............................ .315
Towing Vehicle Behind a Motorhome . ............270
Traction . . . . . . ......................... .256
Traction Control ......................... .144
Trailer Sway Control (TSC) . . . . . . . ............149
Trailer Towing ........................... .258
Cooling System Tips . . . . .................269
Hitches ............................. .269
Minimum Requirements . . . . ...............263
Tips ............................... .268
Trailer and Tongue Weight .................262
Wiring . . . . . . . . . . . . . . . ...............265
Trailer Towing Guide . . . . . . . . . . .............262
Trailer Weight . . . ........................ .262Transaxle
Manual ............................. .354
Transmission Automatic ........................ .246, 351
Filter ............................... .354
Fluid ............................... .354
Man

ual ............................. .245
Transmitter Battery Service (Remote Keyless Entry) . . .14
Transmitter Programming (Remote Keyless Entry) . .13, 14
Transmitter, Remote Keyless Entry (RKE) ..........13
Transporting Pets ......................... .233
Tread Wear Indicators ...................... .376
Trip Odometer .......................... .275
Turn Signals ....................... .95, 274, 305
UCI Connector .......................... .189
Uconnect® Screen Activated Features ...................31
Underhood Fuses ......................... .310
Universal Consumer Interface (UCI) Connector .....189
Unleaded Gasoline ........................ .379
Untwisting Procedure, Seat Belt ................197
Upholstery Care ......................... .357
Vanity Mirrors .............................69
Vehicle Identification Number (VIN) .............360
Vehicle Loading .......................... .366
Vehicle Modifications/Alterations .................5
Vehicle Security Alarm (Security Alarm) ............16
Vehicle Storage ........................ .89, 359
Video Entertainment System™ (Rear Seat Video System)...............................168
Viscosity, Engine Oil ....................... .337
401
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS