2015 FIAT 500E battery

Cav-
ity
Maxi
Fuse
Mini
Fuse
Description
FPT9 – 15 Amp
Blue
Battery Pack Control
Module (BPCM)
Power Inverter
Module (PIM)
FPT13 – 10 Amp
Red
EAC
(AC Compressor)
On Board Charging
Module (OBCM)
FPT16 – 5 Amp
Ta n
Intelligent Battery
Sensor (IBS)
FPT17 – 10 Amp
Red
EAC
(AC Compressor)
Radiator Fan
Cav-
ity
Maxi
Fuse
Mini
Fuse
Description
FPT20 – 10 Amp
Red
Electronic Vehicle
Control Unit (EVCU)
CavityCartridge Fuse Description
FPT325 Amp White Battery Coolant
Pump
FPT520 Amp Lt. Blue Inverter Coolant
Pump
328 MAINTAINING YOUR VEHICLE

VEHICLE STORAGE
The preferred way of storing your vehicle for a long
period of time is to leave it attached to a Level 1 or Level
2 charger. The vehicle has a wake-up feature that will
wake the system every 3 weeks and do a maintenance
charge on the 12 Volt battery and also top off the high
voltage battery if necessary.
Anytime you store your vehicle, or keep it out of service
(e.g., vacation) for two weeks or more, run the air
conditioning system at idle for about five minutes in the
fresh air and high blower setting. This will ensure
adequate system lubrication to minimize the possibility
of compressor damage when the air conditioning system
is started again.
REPLACEMENT BULBS
Interior Bulbs
Bulb Number
Overhead LampC5W
Courtesy LampW5W
Exterior Bulbs
Bulb Number
Front Low and High
Beam Headlamp
HIR2LL
Front Parking/Daytime
Running Lamps
W21/5W
Front Fog Lamps H11LL
Front Side Marker Lamps W3W
Front Turn Signal Lamps WY21W
7
MAINTAINING YOUR VEHICLE 329

5. Remove the backup lamp bulb by pulling straight out.
6. Replace lamps as required and reinstall lamp.
Center High Mounted Stop Lamp (CHMSL)
1. Remove the two guard caps and the two fastening
screws.
2. Remove the center high mounted stop lamp assembly.
3. Disconnect the electric connector.
4. Remove the two screws.
5. Replace the CHMSL assembly.
6. Reinstall the two screws.
FLUID CAPACITIES
SystemsU.S.Metric
Power Electronics Cooling System3.6 Quarts3.5 Liters
Battery Thermal Management Cooling System7.0 Quarts6.7 Liters
Single-Speed Transmission0.8 Quart750 ml
7
MAINTAINING YOUR VEHICLE 333

MAINTENANCE SCHEDULE
Once A Month Or Before A Trip:
•Check windshield washer fluid level
•Check the tire inflation pressures and look for unusual
wear or damage
•Check the fluid levels of the coolant reservoirs and
brake master cylinder
•Check function of all interior and exterior lights
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Service Interval:
•Rotate the tires.Rotate at the first sign of irregu-
lar wear.
•Inspect brake pads, shoes, rotors, drums, and
hoses.
•Inspect battery cooling system protection and
hoses.
•Check and adjust hand brake.
338 MAINTENANCE SCHEDULES

Mileage or time passed
(whichever comes first)
20,00030,00040,00050,00060,00070,00080,00090,000100,000110,000120,000130,000140,000150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,00048,00064,00080,00096,000112,000128,000144,000160,000176,000192,000208,000224,000240,000
Inspect parking brake function.Adjust as necessary.XXX X X X X
Additional Maintenance
Replace cabin air filter.XXXXXXX
Clean and lube sun roof tracks. X X XXXXX
Flush and replace the PowerElectronics and Battery ThermalLoop Systems at 10 years or150,000 miles (240,000 km)whichever comes first.
XX
340 MAINTENANCE SCHEDULES

Adding Washer Fluid......................311
Air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59
Air Bag
Air bag Operation.......................62
Air Bag Warning Light....................72
Driver Knee Air Bag......................63
Enhanced Accident Response................69
Event Data Recorder (EDR).................75
Front Air Bag . . . . . . . . . . . . . . . . . . . . . . . . . . .59
If A Deployment Occurs...................68
Knee Impact Bolsters.....................63
Maintaining Your Air Bag System............74
Air bag Deployment........................59
Air bag Light.............................72
Air bag Maintenance........................74
Air Conditioner Maintenance.................308
Air Conditioning Refrigerant.................308
Air Conditioning System....................202
Air Pressure, Tires.........................249
Alterations/Modifications, Vehicle...............8
Anti-Lock Brake System (ABS)................228
Anti-Lock Warning Light....................158
Appearance Care.........................314
Automatic Dimming Mirror..................103
Automatic Temperature Control (ATC)..........202
Automatic Transaxle........................32
Automatic Transmission....................215
Gear Ranges...........................218
Battery.................................306
Keyless Transmitter Replacement (RKE)........37
Belts, Seat...............................96
Body Mechanism Lubrication.................309
B-Pillar Location..........................242
Brake Assist System.......................230
Brake Fluid.............................334
Brake, Parking...........................226
Brakes.................................312
354 INDEX

Key, Sentry (Immobilizer)....................34
Lane Change and Turn Signals................158
Lane Change Assist........................125
Lap/Shoulder Belts.........................49
Latches.................................98
Hood................................120
Life of Tires.............................257
Liftgate (Sedan)...........................45
Light Bulbs..............................98
Lights..................................98
Airbag................................72
Anti-Lock.............................158
Brake Assist Warning....................233
Brake Warning.........................158
Bulb Replacement.......................330
Exterior...............................98
Fog . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..158
High Beam............................123
High Beam Indicator.....................158
Park................................123
Passing..............................123
Seat Belt Reminder......................158
Service...............................330
Tire Pressure Monitoring (TPMS)............158
Traction Control........................233
Turn Signal............................98
Warning (Instrument Cluster Description)......158
Loading Vehicle
Ti re s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..242
Locks
Automatic Door.........................43
Door.................................40
Power Door............................42
Lubrication, Body.........................309
Lug Nuts...............................275
Maintenance Free Battery....................306
358 INDEX

General Information.....................247
High Speed...........................250
Inflation Pressures.......................249
Life of Tires...........................257
Load Capacity.........................242
Pressure Warning Light...................158
Quality Grading........................350
Radial...............................250
Replacement...........................258
Rotation..............................261
Safety...............................235
Sizes................................236
Snow Tires............................252
Spinning.............................256
Tread Wear Indicators....................257
Tire Safety Information.....................235
Tire Service Kit...........................276
To Open Hood...........................120
Towing................................269
Disabled Vehicle........................293
Recreational...........................270
Towing Vehicle Behind a Motorhome...........270
Traction................................222
Traction Control..........................231
Trailer Towing...........................269
Transaxle
Automatic.............................32
Transmission
Automatic............................215
Capacities............................333
Fluid................................334
Transmitter Battery Service (Remote Keyless Entry) . .37
Transporting Pets..........................95
Tread Wear Indicators......................257
Turn Signals.............................124
UCI Connector...........................199
Uniform Tire Quality Grades.................350
362 INDEX