2015 Citroen C4 PICASSO engine

312
Checks
12 V battery
The battery does not require any maintenance.
H owever,   check   that   the   terminals   are   clean a

nd   correctly   tightened,   particularly   in   summer
 a

nd   winter.Refer to the manufacturer's service   schedule   for   details   of   the  
r

eplacement   intervals   for   these  
c

omponents.
Air filter and passenger compartment filter
Replace the oil filter each time the e ngine   oil   is   changed.
Refer
  to   the   manufacturer's  
s

ervice   schedule   for   details   of  
t

he   replacement   interval   for   this  
c

omponent.
Oil filter
The presence of this label, in particular with
the   Stop   &   Start   system,   indicates   the   use   of  
a

  specific   12   V   lead-acid   battery   with   special  
t

echnology   and   specification.   The   involvement  
o

f   a   CITROËN   dealer   or   a   qualified   workshop  
i

s   essential   when   replacing   or   disconnecting  
t

he   battery.
Unless
  other wise   indicated,   check   these   components   in   accordance   with   the   manufacturer's   service   schedule   and   according   to   your   engine.
Other wise,   have   them   checked   by   a   CITROËN   dealer   or   a   qualified   workshop.
Depending on the environment (e.g. dusty a
tmosphere)   and   the   use   of   the   vehicle   (e.g.   city d

riving),
 r
eplace them twice as often if necessar y .
A
  clogged   passenger   compartment   filter   may   have
 a

n   adverse   effect   on   the   per formance   of   the   air
 c

onditioning   system   and   generate   undesirable
 o

dours.
Particle filter (Diesel)
The start of saturation of the
particle   filter   is   indicated   by   the  
f

ixed   illumination   of   this   warning  
l

amp   accompanied   by   a   warning  
m

essage.
As
 
soon   as   the   traffic   conditions   permit,  
r

egenerate   the   filter   by   driving   at   a  
s

peed
 
of   at   least   40   mph   (60   km/h)   until  
t

he
 
warning   lamp   goes   off.
If
 
the
 
warning   lamp   stays   on,   this  
i

ndicates   a   low   additive   level.
Refer
 
to   the   "Diesel   additive   level"  
s

ection.
on a n

ew vehicle, the first particle
filter
 
regeneration   operations   may   be  
a

ccompanied   by   a   "burning"   smell,  
w

hich
 
is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle
 
at   very   low   speed   or   at   idle,  
y

ou
 
may,   in   exceptional   circumstances,  
n

otice
 
the   emission   of   water   vapour   at  
t

he
 
exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
 
the
 
environment.
When
 
carrying
 
out
 
work
 
on
 
the
 
battery,
 
refer
 
t

o
 
the
 
"12
 
V
 
battery"
 
section
 
for
 
details
 
of
 
the
 
p

recautions
 
to
 
be
 
taken
 
before
 
disconnecting
 
t

he
 
battery
 
and
 
following
 
its
 
reconnection.
Checks

313
Brake wear depends on the style of   driving,   particularly   in   the   case  
o

f   vehicles   used   in   town,   over   short  
d

istances.   It   may   be   necessary   to  
h

ave
 
the
 
condition   of   the   brakes   checked,   even  
b

etween
 v
ehicle
 s
ervices.
Unless
 
there   is   a   leak   in   the   circuit,   a   drop   in  
t

he
 
brake
  fluid   level   indicates   that   the   brake  
p

ads
 
are
 
worn.
Brake pads
For information on checking brake d isc   wear,   contact   a   CITROËN   dealer  
o

r   a   qualified   workshop.
Brake disc wear
Only use products recommended by CITROËN   or   products   of   equivalent  
q

uality
 an
d
 sp
ecification.
In
  order   to   optimise   the   operation   of  
u

nits   as   important   as   those   in   the  
b

raking   system,   CITROËN   selects   and  
o

ffers   very   specific   products.
After
  washing   the   vehicle,   dampness,  
o

r   in   wintry   conditions,   ice   can   form  
o

n   the   brake   discs   and   pads:   braking  
e

fficiency   may   be   reduced.   Make   light  
b

rake   applications   to   dry   and   defrost  
t

he   brakes.
Electric parking brake
For more information, refer to the "Electric parking   brake   -   Operating   faults"   section.
This
  system   does   not   require   any  
r

outine   servicing.   However,   in   the  
e

vent   of   a   problem,   have   the   system  
c

hecked   by   a   CITROËN   dealer   or   a  
q

ualified
 w
orkshop.
Manual gearbox
The gearbox does not require any m
aintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   the   checking   interval   for  
t

his
 c
omponent.
Electronic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   details   of   the   checking  
i

nterval   for   this   component.
Automatic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   details   of   the   level  
c

hecking   interval   for   this   component.To
  avoid   damaging   the   electrical   units,  
n

ever use   a   high   pressure   jet   wash   in  
t

he   engine   compartment.
8
Checks

314
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing u
rea,
 
a
 
catalytic
 
converter
 
turns
 
up   to   85%  
o

f
 
nitrous
 
oxides
 
(NOx)
 
into
 
nitrogen   and  
w

ater,
 
which
 
are
 
harmless
 
to
 
health   and   the  
e

nvironment. The
  AdBlue
® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
Checks

315
Range indicators
Once the AdBlue® tank is on reserve or after d
etection
 
of
 
a
 
fault   with   the   SCR   emissions  
c

ontrol
 
system,
 
when   the   ignition   is   switched  
o

n,
 
an
 
indicator
 
displays   an   estimate   of   the  
d

istance
 
that
 
can
 
be   covered,   the   range,   before  
e

ngine
 
starting
 
is
 
prevented.
In
 
the
 
event
 
of
 
simultaneous   system   fault   and  
l

ow
 
AdBlue
® level, the shortest range figure is t
he
 
one
 
displayed. Range greater than 1 500 miles (2 400 km)
When
  the   ignition   is   switched   on,   no  
i

nformation   on   range   is   displayed   automatically  
i

n   the   instrument   panel.
With   the   type   2   instrument   panel,   pressing   this  
b

utton   temporarily   displays   the   driving   range.
Above
  3   000   miles   (5   000   km),   the   value   is   not  
s

pecified.
In the event of the risk of non-starting related to a lack of AdBlue®
The engine start prevention system required   by   regulations   is   activated  
a

utomatically   once   the   AdBlue
® tank is e
m pt y.
8
Checks

316
Remaining range between 350 and
1500 miles (600 and 2 400 km)
When
  switching   on   the   ignition,   the  
U

REA warning   lamp   comes   on,   accompanied  
b

y   an   audible   signal   and   the   display   of   a  
m

essage   (e.g.:   "Top   up   emissions   additive:  
S

tarting   prevented   in   900   miles")   indicating  
t

he   remaining   range   expressed   in   miles   or  
k

ilometres.
When
  driving,   the   message   is   displayed   every  
2

00   miles   (300   km)   until   the   additive   tank   has  
be

en
 t
opped-up.
Go
  to   a   CITROËN   dealer   or   a   qualified  
w

orkshop   to   have   the   AdBlue
® tank topped-up.
Y
ou
 
can
 
also
 
top-up
 
the
 
tank
 
yourself.
Refer
 
to
 
the
 
"Topping-up"
 
section. Remaining range between 0 and 350 miles
(0 and 600 km)
When
  switching   on   the   ignition,   the   SERVICE  
w

arning   lamp   comes   on   and   the   UREA   warning  
l

amp   flashes,   accompanied   by   an   audible  
s

ignal   and   the   display   of   a   message   (e.g.   "Top  
u

p   emissions   additive:   Starting   prevented   in  
3

50   miles")   indicating   the   remaining   range  
e

xpressed   in   miles   or   kilometres.
When   driving,   the   message   is   displayed   every  
3

0   seconds   until   the   additive   tank   has   been  
t

opped-up.
Go   to   a   CITROËN   dealer   or   a   qualified  w
orkshop   to   have   the   AdBlue® tank topped-up.
Y
ou
 
can
 
also
 
top-up
 
the
 
tank
 
yourself.
Refer
 
to
 
the
 
"Topping-up"
 
section.
ot

her wise you will not be able to restart your
engine. Breakdown related to a lack of AdBlue
®
additive
When
 
switching
 
on
 
the
 
ignition,
 
the
 
SERVICE  
w

arning
 
lamp
 
comes
 
on
 
and
 
the
 
UREA
 
warning  
l

amp
 
flashes,
 
accompanied
 
by
 
an
 
audible
 
s

ignal
 
and
 
the
 
display
 
of
 
the
 
message
 
"Top   up  
e

missions
 
additive:
 
Starting
 
prevented".
The
 Ad

Blue
® tank  is  empty:  t he  s ystem  r equired  b
y
 
regulations   prevents   engine   starting.
To
 
be
 
able   to   start   the   engine,  
w

e
 
recommend   that   you   call   on  
a

 
CITROËN   dealer   or   a   qualified  
w

orkshop   for   the   top-up   required.   If  
y

ou
 
carry   out   the   top-up   yourself,   it   is  
e

ssential   to   add   at   least   3.8   litres   of  
Ad

Blue
® to the tank.
R
efer
 
to
  the   "Topping-up"   section.
Checks

317
In the event of a fault with the the SCR emissions control system
In the event of the detection of a fault
The  UREA,   SERVICE   and   diagnostic   warning  
l

amps   comes   on,   accompanied   by   an   audible  
s

ignal   and   the   display   of   the   message  
"

Emissions
 f
ault".
The
  alert   is   triggered   when   driving   when   the  
f

ault   is   detected   for   the   first   time,   then   when  
s

witching   on   the   ignition   for   subsequent  
j

ourneys,   while   the   fault   persists. During an authorised driving phase (between
650 miles and 0 miles) (1 100 km and 0 km)
If
  a   fault   with   the   SCR   system   is   confirmed   (after
 3

0   miles   (50   km)   covered   with   the   permanent
 d

isplay   of   the   message   signalling   a   fault),   the
 S

ERVICE   and   engine   diagnostic   warning   lamps
 c

ome   on   and   the   UREA   warning   lamp   flashes,
 a

ccompanied   by   an   audible   signal   and   the
 d

isplay   of   a   message   (e.g.:   "Emissions   fault:
 S

tarting   prevented   in   150   miles")   indicating   the
 r

emaining   range   express   in   miles   or   kilometres.
While
  driving,   the   message   is   displayed   every
 3

0   seconds   while   the   fault   with   the   SCR   system
 p

ersists.
The
  alert   is   repeated   when   switching   on   the
 ig

nition.
You
  should   go   to   a   CITROËN   dealer   or   a
 q

ualified   workshop   as   soon   as   possible.
ot

her wise, you will not be able to restart your
engine.
A
  system   that   prevents   engine   starting   is   activated   automatically   from   650   miles   (1   100   km)   after   confirmation   of   a   fault   with   the   SCR   emissions  
c

ontrol   system.   Have   the   system   checked   by   a   CITROËN   dealer   or   a   qualified   workshop   as   soon   as   possible.
If   it   is   a   temporary   fault,   the   alert  
d

isappears   during   the   next   journey,  
a

fter   self-diagnosis   of   the   SCR   system. Starting prevented
Every
  time   the   ignition   is   switched   on,   the  
S

ERVICE   and   engine   diagnostic   warning  
l

amps   come   on   and   the   UREA   warning   lamp  
f

lashes,   accompanied   by   an   audible   signal   and  
t

he   display   of   the   message   "Emissions   fault:  
St

arting
 p
revented".
You
  have   exceeded   the   authorised  
d

riving   limit:   the   starting   prevention  
s

ystem   inhibits   engine   starting.
To
  be   able   to   start   the   engine,   you   must  
c

all   on   a   CITROËN   dealer   or   a   qualified  
w

orkshop.
8
Checks

319
Recommendations on storage
AdBlue® freezes at about -11°C and d
eteriorates   above   25°C.   It   is   recommended  
t

hat
 
bottles   be   stored   in   a   cool   area   and  
p

rotected   from   direct   sunlight.
Under
 
these   conditions,   the   additive   can   be  
k

ept
 
for
 
at   least   a   year.
If
 
the
 
additive   has   frozen,   it   can   be   used   once   it  
h

as
 
completely   thawed   out.
Procedure
Before topping-up, ensure that the vehicle is parked   on   a   flat   and   level   sur face.
In
  wintry   conditions,   ensure   that   the  
t

emperature   of   the   vehicle   is   above   -11°C.  
O

ther wise,   by   freezing,   the   AdBlue
® cannot
be
 
poured
 
into
 
its
 
tank.
 
Park
 
your
 
vehicle   in   a  
w

armer
 
area
 
for
 
a
 
few
 
hours
 
to
 
allow   the   top-up  
t

o
 
be
 
carried
 
out.
F
 
P

ress
 
the
 
START/STOP
 
button
 
to   switch  
o

ff
 
the
 
engine. F
 F or   access   to   the   AdBlue® tank, raise the b
oot
 
floor,
 
or
 
on
 
7-seat
 
versions,   unfold   the  
r

ight
 
hand
 
seat
 
in
 
the
 
third
  row.
Never
 
store
 
bottles
 
of
 
AdBlue
® in your
vehicle. F
 W ithout   pressing,   turn   the   black   cap   a  
q

uarter   turn   anti-clockwise   and   lift   it   off.
F
 
T
urn   the   blue   cap   a   6
th of a turn anti-
c
lockwise.
F
 
L

ift
 
off
 
the
 
cap.
F
 
O

btain
 
a
 
bottle
 
of
 
AdBlue
®. After first c
hecking
 
the
 
use-by
 
date,
  read   carefully  
t

he instructions on use on the label before
pouring
 
the
 
contents
 
of
 
the   bottle   into   your  
v

ehicle's
 Ad

Blue
® tank.
8
Checks

320
Important:   if   your   vehicle's  Ad
Blue® tank is completely empty - w
hich
 
is
  confirmed   by   the   alert  
m

essages   and   the   impossibility   of  
s

tarting
 
the   engine,   you   must   add   at  
l

east
 
3.8   litres   (so   two   1.89   litre   bottles).
Never
  dispose   of   AdBlue
® additive b
ottles
 
in
 
the
 
household
 
waste.   Place  
t

hem
 
in
 
a
 
special
 
container   provided  
t

his
 p

urpose
 o

r
 t

ake
 t

hem
 t
o
 y
our
 d
ealer.
Important:
 w

hen topping up after
running out of additive ,
  signalled  
b

y
 
the
 
message
 
"Top
 
up
 
emissions  
a

dditive:
 
Starting
 
prevented",   you   must  
w

ait
 
for
 
approximately
 
5
 
minutes   before  
s

witching
 
on
 
the
 
ignition,
 
without
opening the driver's door, unlocking
the vehicle, placing the key of the
"Keyless Entr y and Star ting" system
inside the vehicle or inser ting the
electronic key in the reader.
Switch
 
on
 
the
 
ignition,
 
wait   for  
1

0 seconds,
 
then
 
start
 
the   engine.
If
 
any
 
additive
 
is
 
split
 
or
 
splashed,
 
wash
 
i

mmediately
 
w

ith
 
c

old
 
w

ater
 
o

r
 
w

ipe
 
w

ith
 
a

 
damp
 
cloth.
If
 
the
 
additive
 
has
 
crystallised,
 
clean
 
it
 
o

ff
 
using
 
a
 
sponge
 
and
 
hot
 
water.
F
 
A

fter
 
emptying
 
the
 
bottle,
 
wipe
 
away
 
any
 
s

pillage
 
around
 
the
 
tank
 
filler
 
using
 
a
 
damp
 
c

loth.
F
 
R

efit
 
the
 
blue
 
cap
 
to
 
the
 
tank
 
and
 
turn
 
it
 
a
 
6th of a turn clockwise, to its stop.
F
 R
efit   the   black   cap   and   turn   it   a   quarter   of  
a

 
turn   clockwise   without   pressing.   Ensure  
t

hat   the   indicator   on   the   cap   lines   up   with  
t

he   indicator   on   the   support. F
 
D
epending   on   equipment,   return   the   spare  
w

heel   and/or   the   storage   box   to   the   bottom  
o

f   the   boot.
F  
R
efit   the   boot   carpet   and   close   the   tailgate.
Checks