2015 Citroen C ZERO battery

88
C-zero_en_Chap08_info-pratiques_ed01-2014
As a safety measure, the motor will
not start when the charging cable is
connected to the vehicle's socket.
Also, any attempt to start the motor
interrupts the charging procedure. It will
then be necessary to disconnect and
reconnect the charging cable plug to
continue charging.After charging, close the charging
socket cover and flap.
Take care to avoid the ingress of water
or dust to the socket and its cover
or the charging plug (risk of fire or
electrocution).
The charge lamp in the instrument panel going
off and flashing of the green CHARGING
lamp
indicate that charging is complete.
F
Pr

ess the button to remove the charging
plug.
F
Re

fit the protective cover to the charging
cable.
F
Cl

ose the charging socket cover, then the
flap.
F
Di

sconnect the charging cable from the
power point.
F
St

ow the charging cable in the bag
provided. If the 12V ancillaries battery is
discharged, it is not possible to charge
the main battery.
If you wear a pacemaker or other
electrical medical device, you must not
stay inside or near the vehicle during
charging.
It is also important that you take advice
from your doctor on the precautions to
take and observe.While charging, do not do anything
under the bonnet, even with the ignition
off, as the cooling fan may start at any
time (risk of injury).
You must wait for at least one hour
after the end of the charging procedure
before doing anything under the bonnet,
as some areas can be extremely hot
(risk of burns).
After removing the charging plug from
the vehicle's socket, do not leave
the cable connected to the electric
power point (risk of short circuit or
electrocution if it is contacted or
immersed in water).
Practical information

89
C-zero_en_Chap08_info-pratiques_ed01-2014
To optimise the ser vice life of the
main battery, recharge it completely
ever y 15 days.
For a complete charge, follow the
normal charging procedure (domestic
power point) without interruption, until it
stops automatically (charging warning
lamp off in the instrument panel).
In addition, ever y 3 months, carr y out
this complete recharge of the main
batter y from a state of charge of
2
b
ars or less .Vehicle out of use for a long
period
When your vehicle is going to be out
of use for a long period, charge the
main battery completely every three
months (following the normal charging
procedure).
Before charging, check that the
ancillaries battery is not disconnected
or discharged. If this is the case, refer
to the "ancillaries battery" section for
reconnecting or charging the battery.
In the event of an accident or an impact
to the underbody of the vehicle (contact
with a high kerb, a terminal, street
furniture, .
..), the electric circuit or the
main battery may be damaged. Have
your vehicle checked by a CITROËN
dealer or a qualified workshop.
Never touch the 300 V components, nor
the orange cables.
In the event of serious damage to
the main battery, never touch liquids
coming from this component.
In the event of contact with your body,
wash abundantly with water and contact
a doctor without delay.
8
Practical information

i
92
C-zero_en_Chap08_info-pratiques_ed01-2014
F Check that the charging warning
lamp in the instrument panel is on
fixed.
Fast charging stops automatically when
the battery is around 80 % charged.
It is possible to attain a level of 100
%
c

harged by restarting the procedure.
However, the time taken by this
additional charge will be relatively long,
as the charging rate is reduced. During the fast charge, the vehicle's air
conditioning may start automatically,
if needed to cool the main battery. It is
therefore per fectly normal to hear the
noise of a fan running from outside the
vehicle and to see a puddle of water
form under the vehicle. As a safety measure, the motor will
not start when the charging cable is
connected to the vehicle's socket.
Also, any attempt to start the motor
interrupts the charging procedure. It
will then be necessary to disconnect
and reconnect the charging cable
plug to continue charging, following
the instructions for using the charging
station.If the ambient temperature is below
0
°
C, the charging time may be longer.
If the ambient temperature is below -25
°
C,
charging may not be possible.
If this is not the case, charging has not started;
check the operating instructions for the
charging station. The charging warning lamp in the instrument
panel goes off when charging is complete.
F
Di
sconnect the charging cable following
the instructions for the charging terminal.
F
Cl
ose the charging socket cover and the
flap.
After charging, close the charging
socket cover and flap.
Take care to avoid the ingress of water
or dust to the socket and its cover
or the charging plug. Risk of fire or
electrocution.
Vehicle out of use for a long
period
When your vehicle is going to be out
of use for a long period, charge the
main battery completely every three
months (following the normal charging
procedure).
Before charging, check that the
ancillaries battery is not disconnected
or discharged. If this is the case, refer
to the "ancillaries battery" section for
reconnecting or charging the battery.
Practical information

93
C-zero_en_Chap08_info-pratiques_ed01-2014
ancillaries battery
All of the electrical components of your vehicle
(other than the electric motor, the heating and
the air conditioning) are powered by this 12
V
anc

illaries battery.
It is located in the front compartment and is
recharged by the main battery, during phases
of operation ("Ready" lamp on in the instrument
panel) and charging.
If the ancillaries battery is discharged,
it will not be possible to start the
motor and the main battery cannot be
charged. F
Op

en the front bonnet using the interior
release lever, then the exterior safety
catch.
F
Se

cure the bonnet stay.
F
Sl

acken nut 1.
F
Re

move the battery protective cover for
access to the two terminals.Access to the battery
Disconnecting the battery is not
recommended.
However, if the vehicle is not to be
used for a prolonged period of more
than a month, it may be necessary to
disconnect and store it to avoid the
electrolyte freezing.
After prolonged disconnection of the
battery, you must contact a CITROËN
dealer or a qualified workshop to have
the electronic control unit reinitialised.
8
Practical information

94
C-zero_en_Chap08_info-pratiques_ed01-2014
F Lift the protective cover on the (+) terminal.F
Co
nnect one end of the red cable to the
(+) terminal of your discharged battery A ,
then the other end to the (+) terminal of the
battery on the other vehicle B .
Starting using a battery on
another vehicle
F Connect one end of the green or black
c
able to the (-) terminal of the battery on
the other vehicle B .
F
Co

nnect the other end the green or black
cable to the earth point C of your vehicle.
Ensure that the electrolyte is not frozen.
Check the electrolyte level and top up
with distilled water if necessary (refer
to the "checking levels" section in this
document).
Check that the battery on the other
vehicle is a 12
V b

attery.
Practical information

95
C-zero_en_Chap08_info-pratiques_ed01-2014
Charging the battery using
a battery charger
F Start the other vehicle and wait a few
minutes.
F
Tu

rn the ignition key on your vehicle, until
the "Ready" lamp comes on.
F
Di

sconnect the cables in the reverse order.
F
Re

fit the battery protective cover and
tighten the fixing screw.
If the "Ready" lamp does not come on, proceed
as follows:
F
Le

ave the cables connected.
F
Re

turn the ignition switch on your vehicle
to the " LOCK" position.
F
Pu

t the main battery on charge, following
the procedure for normal charging (see the
"charging the main battery" section).
F
Wh

en the charging warning lamp in
the instrument panel comes on fixed,
disconnect the cables.
F
Le

ave the battery on charge for at least
one hour.
F
Tu

rn the ignition key on your vehicle, until
the "Ready" lamp comes on.
If the problem persists, contact a
CITROËN
d

ealer or a qualified workshop. F Re
move the protective cover from the
battery.
Ensure that the electrolyte is not frozen.
Check the electrolyte level and top up
with distilled water if necessary (refer to
the "checking levels" section). F
Sl

acken nut 1 and lift off the retaining bar.
8
Practical information

96
C-zero_en_Chap08_info-pratiques_ed01-2014
Never charge the battery without
first disconnecting the terminals and
removing it from the vehicle.
Do not disconnect the terminals when
the "Ready" lamp is on, nor when the
vehicle is being charged.
Before disconnecting
You must wait 2 minutes after switching
off the ignition before disconnecting the
battery.Batteries contain harmful substances
such as sulphuric acid and lead. They
must be disposed of in line with legal
requirements and never put out with
household waste.
Take used batteries to an authorised
collection point.
F
Di

sconnect the negative (-) terminal.
F
Li

ft the protective cover on the (+) terminal 2 .
F
Sl

acken nut 3 .
F
Di

sconnect the positive (+) terminal.
F
Re

move the battery.
F
Ch

arge the battery following the
instructions given by the manufacturer of
the battery charger.
F
Re

connect the battery starting with the (+)
cable.
After reconnecting
After reconnecting the battery, switch
on the ignition and wait 1 minute
before starting, to allow initialisation
of the electronic systems. However,
if minor problems persist after doing
this, contact a CITROËN dealer or a
qualified workshop.
Remember to enter the radio code
yourself, referring to the relevant
section.
Ensure that the battery posts and cable
terminals are clean. If they are covered
with sulphates (whitish or greenish
deposit), disconnect and clean them.
Practical information

117
C-zero_en_Chap08_info-pratiques_ed01-2014
Fuse N°Rating Functions
1 -Not used.
2 30 AInternal fuse.
3 40 AElectric motor.
4 40 ARadiator fan.
5 40 AElectric windows.
6 30 AVacuum pump.
7 15 AMain battery ECU.
8 15 AThird brake lamp.
9 15 AFront foglamps.
10 15 AWater pump.
Front compartment fuses
The fusebox is placed in the front compartment
under the heating system reservoir. Only these
fuses can be replaced.
The replacement of fuses for other units
(vacuum pump and battery accessories)
requires the involvement of a CITROËN
dealer or a qualified workshop.
8
Practical information