Black plate (18,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
18 New Vehicle Limited Warranty
Chevrolet Volt Coverage
Propulsion Battery Warranty
Policy
Like all batteries, the amount of
energy that the high voltage
“propulsion”battery can store will
decrease with time and miles
driven. Depending on use, the
battery may degrade as little as
10% to as much as 30% of capacity
over the warranty period. A dealer
service technician will determine
if the battery energy capacity (kWh
storage) is within the proper limit,
given the age and mileage of the
vehicle. Typical tests can take up to
24 hours.
Repair
If possible, components will be
repaired or replaced, and the
original battery will be returned to
the vehicle.Replace (If Necessary)
Under warranty, the high voltage
battery may be replaced with either
a new or factory reconditioned high
voltage battery with an energy
capacity (kWh storage) level at or
above that of the original battery
prior to the failure.
Your Volt battery warranty
replacement may not return your
vehicle to an“as new”condition,
but it will make your Volt fully
operational appropriate to its age
and mileage.
Other Voltec/Electric Propulsion
Components
High Voltage Wiring, Voltec Control
Modules, E-Compressor, Traction
Power Inverter Module (TPIM),
Accessory Power Module (APM),
and Voltec/Electric Propulsion
On-Board Charger.Brakes
Brake Modulator Assembly
Electric Drive Unit
Electric drive unit assembly and
internal components, including the
auxiliary fluid pump, auxiliary pump
controller, and 3-phase cables.
What Is Not Covered
In addition to the”What Is Not
Covered“section previously, the
Voltec warranty does not cover the
following items:
Wear Items
Wear items, such as brake linings,
are not covered in the Voltec
warranty.
Black plate (31,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
Emission Warranty Parts List 31
Exhaust Gas Recirculation (EGR)
System
EGR Feed and Delivery Pipes
EGR Temperatuer Sensor
EGR Valve
EGR Valve Cooler
Secondary Air Injection System
Air Pump
Check Valves
Evaporative Emission Control
System (Gasoline Engines)
Canister
Canister Solenoid and Valve
Fuel Feed and Return Pipes and
Hoses
Fuel Filler Cap
Fuel Level Sensor
Fuel Limiter Vent Valve
Fuel Tank(s)Fuel Tank Filler Pipe (with restrictor)
Fuel Tank Vacuum or Pressure
Sensor
Hybrid
Auxiliary Transmission Fluid Pump
Battery Cooling Circuit
Battery Control Module *
Battery Pack Current Sensor
Brake Pedal Travel Sensor
Drive Motors and Resolvers
Drive Motor/Generator Control
Module *
Electro-Hydraulic Brake Control
Module *
Energy Storage Control Module *
Hybrid Batteries
Hybrid Battery Temperature and
Voltage Sensors
SGCM Coolant Circuit (fan,
relay, pump)
Starter GeneratorStarter Generator Control Module *
Starter Generator Drive Belt
Traction Power Inverter
Module (TPIM) *
Voltec Specific Components
Vehicle Interface Control Module *
Voltec RESS Battery *
Onboard Charger *
Charge Port
Charge Port Switches and Sensors
Voltec EVAP Canister Assembly
Voltec RESS Thermal Management
E-compressor *
Port Valves
Battery Temperature Sensors
Battery High Voltage Heater
Battery Coolant Pump
Power Electronics
Coolant Pump
Air and Coolant Temperature
Sensors
Rfg. Temperature and Pressure
Sensors
