2015 AUDI S8 fuel cap

16 Instruments and warning/indicator lights
If the engine coolant level is correct, then the
radiator fan may be the cause of the malfunc­
tion.
• Coolant temperature too high! Please let
engine run with vehicle s tationary
If the indicator light turns on and the mes­
sage appears, let the engine run at idle for a
few minutes to cool down.
A WARNING
- If your vehicle should break down for
mechanical or other reasons, park at a
safe distance from moving traffic, turn
off the engine and turn on the hazard
warning lights¢
page 47, Emergency
flasher .
-Never open the hood if you see or hear
steam or coolant escap ing from the en­
gine compartment -you risk being scald­
ed . Wait until you can no longer see or
hear steam or coo lant escaping.
- The engine compartment of any veh icle
is a dangerous area. Before you perform
any wor k in the engine compartment,
turn of the eng ine and allow it to cool.
Follow the warning sticke rs
¢page 228.
(D Note
Do not continue driving if the . symbol
illuminates. There is a malfunction in the
engine cooling system -you could damage
your eng ine.
0 Battery
This warning/indicator light detects a mal­
function in the generator or in the vehicle's
electrical system .
The. warni ng/indicator light illuminates
when you switch on the ignition and must go
out after the engine has started .
• Alternator fault: Battery is not being
charged
If the indicator light turns on and the mes ­
sage appears, there is a malfunction in the
generator or vehicle electr ica l system . Drive to
your authorized Audi dealer or quali­
fied workshop immediate ly. Because the vehi­
cle battery is discharg ing, turn off all unnec ­
essary electrical equipment such as the rad io .
Seek professional assistance if the battery
charge level is too low .
r•j Low battery charge: battery will be
charged while driving
If the indicator light turns on and the mes­
sage appears, there may be limited starting
ability.
If this message turns off after a litt le while,
the battery charged enough while driving.
If the message does not turn off, have your
authorized Aud i dealer or qualified workshop
correct the malfunction.
L'h Engine
• Engine stopped: No power steering and
brake support.
The re is a malfunction in the engine or in the
fuel supply system.
A large amount of steering and braking force
is required when driving a rolling vehicle with
the engine stopped. Tr y to stop a rolling vehi­
cle carefu lly on the side of the road. See your
authorized Audi dealer or qualified repair fa­
cility.
A WARNING
-If the engine stops while driving, a large
amount of braking force is required. This
in creases the r isk of an accident. As long
as the vehicle rolls with the ignit ion
switched on and there is enough battery
cha rge, the power steering will sti ll work.
If not, a large amount of steering force is
r equired.
-

,....,
N ,....,
N
0 J:
'SI: ,...., \!) 1.1'1 ,...., 1.1'1 ,....,
Instruments and warning/indicator lights 21
switched on and will turn off after the engine
has started and has sett led at a constant idle
speed . This ind icates that the MIL is working
properly .
The warning light illuminates when there is a
malfunction in the engine e lectronic system .
Contact your author ized Audi dealer and have
the malfunction corrected .
An improperly closed fuel filler cap may also
cause the MIL light to illuminate
¢page 223.
For mo re in format ion ¢ page 29.
~. Diesel particulate filter clogged
Appl ies to vehicles: with d iesel e ngine and diese l pa rticu ­
late fi lte r
II Particulate filter: System fault See own­
er's manual
When the II symbol illum inates, you can al­
ter your driving style to assist the filter self­
cleaning process. Drive for approximately 15
minutes with the selector lever in the 5 posi­
tion at a minimum speed of 37 mph (60 km/
h) and an engine speed of approximately
2,000 RPM. The temperature increase that
will resu lt from this can burn off the soot in
the filter . The symbol will switch off when the
cleaning is successful. After a successful
cleaning , there is no need to bring the car to
an author ized dealer or qualified workshop
because this is part of normal vehicle ope ra­
tion .
If the symbol
II does not switch off, see your
author ized dealer or other qualif ied workshop
to have the problem corrected.
For more information on the diesel particu­
late filter , refer to¢
page 206 .
.,&. WARNING
Always adapt your speed to the current
weather, road and traffic conditions. You
should never disobey traffic laws in order
to follow driving recommendations.
-
!'1 Engine speed limitation
App lies to veh icles: w it h e ngine speed lim itat io n
II! Engine speed maximum XXXX RPM
The engine speed is automatically limited to
the speed d isplayed in the driver information
system. This protects the engine from over·
heating.
The engine speed limitation deactivates once
the engine is no longer in the critical tempera­
ture range and you have released the accelera­
tor pedal once.
If the engine speed limitation was activated
by an engine control malfunction, the indica­
tor light
13:a also turns on . Make sure that the
speed does not go above the speed disp layed.
Drive to your authorized Audi dealer immedi­
ate ly to have the malfunction corrected.
~v, Engine oil sensor
• Oil level! Sensor defective
If the symbol illum ina tes, contact your au­
thorized Audi dea le r and have the oil sensor
inspected. Until you have this done, check the
oi l level each time you refue l just to be on the
safe side
¢ page 233.
f Request to warm engine by driving
0 Please warm up engine
Fuel has entered the engine o il because of low
outside temperat ures or frequent short
drives . Drive until the engine is warm so that
the fuel in the engine oil will vapori ze. Avoid
high eng ine speeds, full acceleration and
heavy engine load when doing this .
Bu Fuel level indicator
liD Please refuel
If the indicator light turns on for the firs t
time and the message appears, there are
about 4 gallons ( 15 liters) of fuel left in the
tank. Time to refuel
¢page 222 .
Ill Tank system malfunction! Contact dealer IJIJ,

Instrument s and warning /indicator lights 29
(D Note
To prevent sc ratches on the g lass covering
the Head-up Disp lay, do not place any ob ­
jects i n the projection opening.
(D} Tips
- Sunglasses with polarizat ion fi lters and
u nfavo rable lighting condit ions can af­
fect the display.
- A specia l windshield is needed for the
Head-up Display funct ion .
- Fo r information on cleaning, refe r to
c:!) table on page 216.
Open door/hood/rear lid warning
Fig. 16 Dis play: door s and rear lid o pe n
W ith the ignition swi tched on , the w arning il ­
l um ina tes when at le ast
one d oor or the hood
or the rear lid is not closed . The symbol also
shows you
which door(s) or lid is not closed.
I n the illus trati on
Q fig. 16 it i s the drive r's
door and the left rear door.
On-Board Diagnostic
system (OBD)
Malfunction Indicator Lamp (MIL)
The Malfunction In dica tor Lamp (M IL) ¢..ifl in
the ins trument clus ter is part of the On-B oard
D iagnostic (OB D II) system .
The warning/ind icator l ight illum ina tes when
the ign ition is switc hed o n and goes o ut afte r
the eng ine starts and the idle has stabilized.
This indicates that t he MIL is working proper ·
Ly .
If the light does not go out afte r th e engine
is starte d, or illumi nates while you are driv­
i ng , a mal function may e xist in the eng ine sys ­
tem .
If the light illumi nate s, the catalytic con­
verter could be d amaged .
Contin ue d riving
with reduced power (avo id­
i ng s usta ined h igh speeds and/or rapid accel ­
erations) and have the cond ition corrected .
Contact your authori zed Audi dea ler.
If the light illuminates, the electronic speed
li miter may also be malfunct ioning. For more
i nformation
Q page 30, Elec tronic speed
limiter.
An imprope rly closed fuel fille r cap may a lso
ca use the MIL light to ill uminate
~ page 223.
On-Board Diagnostics
Fig. 17 Locat io n of Data Link Co nn ector (D LC)
On- Boa rd Diagnost ics monitors the compo­
nents of your emiss ion cont ro l s ystem. Each
monitored component in your eng ine system
has been ass igned a code . In case of a mal­
funct ion, the component will be identified
and the fault stored as a code in the control
module memory.
T he MIL light may also illuminate if there is a
leak in the on -board fuel vapor recovery sys­
tem. If the lig ht illuminates after a refueling,
stop the vehicle a nd make sure the fuel fi ller
cap is prope rly closed
c:!) page 223.
In order to make an accurate diagnosis, the
stored data can on ly be displayed using spe­
c ia l diagnostic equipment (generic scan tool
furOBru.
~

,....,
N ,....,
N
0 J:
'SI: ,...., \!) 1.1"1 ,...., 1.1"1 ,....,
(D Note
-Your vehicle warranty does not cover any
damages to the vehicle caused by using
roof racks or mount ing structures not
approved by Audi for your vehicle . The
same applies to damage resulting from i ncorrect roof rack installation .
- Always check the roof rack mountings
and hardware before each trip and dur ­
i ng a tr ip to make sure everythi ng is se­
curely tightened. If necessary, retighten
the mount ings and check the ent ire sys­
tem from t ime to t ime.
- After mounting a roof rack system, or
when you transport objects on the roof
of your veh icle, the height of the vehicle
is natura lly increased . Be careful when
driving under low bridges or in parking
garages for example. This could ca use
damage to the load and even the vehicle
i tself.
- Make sure the open rear lid and the sun­
roof* do not come into contact with the
roof rack .
Loading the roof rack
Always distribu te loads evenly. Make sure
any thing on the roof rock is securely tied
down .
.. Always distribute the loads on the roof rack
evenly .
.. Always attach items to the roof rack securely
before you drive off .
The maximum perm iss ible roof weight is
220 lb (100 kg ). The roof weight is the to tal
of the weight of the roof rack, the attach ­
ments and the cargo you are carrying . You
must also not exceed the maximum load
weight for the roof rack you are using.
When us ing a roof rack system which has a
lower load carry ing capac ity, you must not use
up the total max imum pe rm iss ib le load ca rry­
ing capacity specified above. I nstead , you
should lo ad the roof rack sys tem only to the
S eat s an d sto rage 73
maximum capacity specified by the manufac ­
turer of the roof rack syst em.
A WARNING
Weak , damaged or improper straps used
to secure items to the roof rack can fail
during hard braking or in a coll is ion and
cause ser ious persona l injury .
- Make sure the roof rack is installed exact­
ly as specif ied above
c> poge 72.
-Always use s uitable mount ing straps for
secur ing items to the roof rack to help
prevent items from sh ifting or flying for ­
ward .
- Items on the roof rack must always be
securely mounted .
- The use of a roof rack can negat ively af­
fect the way a veh icle hand les . Cargo
that is large, heavy, bulky, long or flat
will have a greater negat ive infl uence on
the vehicle's aerodynamics, center of grav ity and overall handling. Always
drive s lowly, avoid s udden braking and
maneuvers when transporting cargo on
the roof of your vehicle.
- Never exceed the maxim um permissible
load carrying capacity of the roof of your
vehicle, the permissible axle weights and the permissible total weight of your vehi­
cle
c> page 287, Weights.
@ For the sa ke of the environment
As a result of the increased wind resist­
ance created by a roof rack, your vehicle is
u s ing fuel unnecessarily . So remove the
roof rack after using it .

78 Warm and cold
Warm and cold Climate controls
Description
The climate control system warms, cools and
adds humidity to the air in the vehicle interior.
It is the most effect ive when the windows and
sunroof* are closed . If the temperature inside
the parked vehicle becomes very warm, open­ ing the window briefly will speed up the cool­
ing process.
I n all heating mode functions except
defrost,
the blower on ly switches to a higher speed
once the engine coolant has reached a certain
temperature.
Condensation from the cooling system can
drip and form a puddle of water under the ve­
hicle. This is normal and does not mean there
is a leak.
Pollutant filter
The pol lutant filter removes pollutants such
as dust and pollen from the air.
The air pollutants filter must be changed at
the intervals spec ified in you r Warranty
&
Maintenance booklet, so that the air condi­
tioner can properly work.
I f you drive your vehicle in an a rea with high
a ir po llution, the fi lter may need to be
changed more frequent ly than specified in
your Aud i Warranty
& Maintenance booklet. If
in doubt, ask your authorized Audi Service Ad­
visor for advice .
Key coded settings
The climate control settings are a utomat ically
stored and assigned to the remote control key
that is in use.
A WARNING
Reduced visibility is dangerous and can
cause accidents. -
- For safe driving it is very important that
all windows be free of ice, snow and con­
densation.
- Comp letely familiarize yourself with the
proper use and funct ion of the heat ing
and ventilation system and especially how to defog and defrost the windows.
- Never use the windshield wiper/washer
system in freez ing weather unt il you
have warmed the windshield first, using
the heating and ventilation system. The
washer solution may freeze on the wind­ sh ie ld and reduce visib ility.
(D Note
- If you suspect that the air conditioner has been damaged, switch the system
off to avoid further damage and have it
inspected by a qualified dealership.
- Repairs to the Audi air conditioner re­
quire special technical know ledge and
special tools. Contact an authorized Aud i
dea ler fo r assistance.
@ For the sake of the environment
By reducing the amount of fuel you use,
you also reduce the amount of pollutants
emitted into the air.
(D Tips
- Keep the air intake s lots (in fro nt of the
w indshield) free from ice, snow and de ­
bris in order to maintain the proper func­
tion of the climate control system.
- T he energy management system may
switch the seat heating* or rear window
defroster off temporari Ly . These systems
are available again as soon as the energy
balance has been restored.
- Air escapes through vents under the rear
window. When placing items of clothing
on the luggage compartment cover, en­
sure that the openings are not covered.

222 Fuel su ppl y and fillin g yo ur fu el t an k
Cold diesel engines normally produce louder
noises during winter conditions than during
warmer periods . In addition, the exhaust gas ­
es may be light blue in color until the engine has warmed up.
.&_ WARNING
Never use starting assist fluids. They may
be potentially explos ive or cause a "run­
away" engine condition . Th is could resu lt
in ser ious persona l injury and eng ine dam­
age.
- Your vehicle's diesel engine was de­ signed so ley for use with ULSD No. 2.
Therefo re, never use gaso line, heat ing
oi l or other fuels. These fuels contain
substances that will severely damage the
fuel system and the engine. Such dam­
age will not be covered by your New Ve­ hicle limited Warranty.
- If you put any amount of incorrect fue l in
the fue l tank, do not start the engine un­
der any circumstances. Immediately con­
tact the nearest authorized Audi dealer
or authorized Audi Service Facility for as­
s istance. These fuels contain substances
that can severely damage the fuel sys­
tem and the engine if the engine is start­
ed .
- Do not mix additives such as "flow im­
provers", gasoline or other substances
with ULSD No. 2.
Fuel tank
Fuel filler neck
The fuel filler neck is located on the right rear
side panel behind the fuel filler flap .
If the power locking system should fail, you
can still open the flap manually- for detailed instructions see
c> page 2 2 4 .
You can f ind the fue l tank ca pa city of your ve­
hicle in
<=> page 288.
The label on the inside of the fuel f iller flap
te lls you the correct fue l for your vehicle. For
more information about fuel specifications,
see
c> page 220.
Your vehicle fuel tank has an on board refuel­ ling vapor recovery system. This feature helps
to prevent fuel vapors from escaping from the
tank and polluting the environment while you
refuel your vehicle. In order to fill the tank
proper ly while protecting the environment,
please follow this refueling procedure careful­
ly .
.&_ WARNING
Under normal operating cond itions , never
ca rry addit ional fue l conta iners in your car .
Gas canisters and other containers used to
transport fuel can be dangerous. Such con­
tainers, fu ll or empty, may leak and could
cause a fire in a collision. If you must
transport fuel to use for your lawn mower,
snow b lower, etc ., be very careful and al­
ways observe local and state laws regard­
i ng the use, transportation and storage of
such fuel containers. Make certa in the con­
tainer meets industry standards (ANSI/
ASTM
F852 -86).
{(y Note
Never drive your veh icle until the fuel tank
i s completely empty. The irregula r supply
of fue l can cause misfir ing. Gasoline cou ld
enter the exhaust system and damage the
catalytic converter.

Refuelling
Fig. 190 Right rear vehicle sid e: Opening t he fuel filler
flap
Fig. 191 Fu el filler flap with attached fuel cap
When activating the central locking, the fuel
filler flap is automatically unlocked or locked.
Refuel the vehicle with the ignition switched
off.
Taking the fuel cap off
• Press the left side of the fuel filler flap to
open it¢
fig. 190 -arrow- .
• Unscrew fuel filler cap counter-clockwise
and hang it on the fuel filler flap
r;, fig. 191.
• Check the label on the inside of the fuel fill­
er flap to determine if the vehicle must be
fueled with gasoline or diesel fuel.
Refuelling procedure
• Insert the fuel nozzle from the gasoline
pump into the fuel filler neck as far as it will
go.
• Select a medium refuelling rate so that the
nozzle switches off automatically when the
tank is full.
Putting the fuel cap back on
• After filling your tank, twist the fuel filler
cap clockwise as far as it will go.
• Close the fuel filler flap.
Fuel supply and filling your fuel tank 223
To avoid fuel spilling or evaporating from the
fuel tank always close fuel filler cap properly
and completely. An improperly closed fuel fill­
er cap may also cause the MIL lamp¢
page 29
to come on (only vehicles with gasoline en­
gine).
A WARNING
-
Improper refueling or handling of fuel can
cause fire, explosion and severe burns.
- Fuel is highly flammable and can cause
severe burns and other injuries.
- Failure to shut the engine off while refu­
eling and/or to insert the pump nozzle
fully into the fuel filler neck could cause
fuel to spray out of filler neck or to over­
flow. Fuel spray and overflowing fuel can
cause a fire.
- Never use a cellular telephone while re­
fueling. The electromagnetic radiation
can cause sparks that can ignite fuel va­
pors and cause a fire.
- Never get back into your vehicle while re­
fueling. If in exceptional circumstances
you must get back in your vehicle while
refueling, make certain that you close
the door and touch metal to discharge
static electricity before touching the fill­
er nozzle again. Static electricity can
cause sparks that can ignite fuel vapors
released during refueling .
- Never smoke or have an open flame any­
where in or near your vehicle when refu­
eling or filling a portable fuel container.
- For your safety, we strongly recommend
that you do not travel with a portable
fuel container in your vehicle. The con­
tainer, full or empty may leak and could
cause a fire, especially in a crash.
- If, under exceptional circumstances, you
must transport a portable fuel container,
please observe the following:
- Never fill a portable fuel container
while it is anywhere in or on the vehicle
(for example, in the luggage compart­
ment, or on the trunk). Static electrici­
ty can build up while filling and can ig-
nite fuel vapors causing a fire. .,.
'------------=---------

224 Fuel supply and filling your fuel tank
-Always place a portable fuel container
on the ground before filling.
- Always keep the fi ller nozzle complete­
ly inside the portable conta iner before
and during filling.
- If filling a portable container made of
metal , the filler nozz le must always be
in contact with the container. This will
help prevent static electricity from dis­
charging and cause a fire .
- Never spill fuel inside the vehicle or
luggage compartment. Fuel vapors are
highly flammable .
- Always observe local and state/provin­
cial laws regarding the use, storage
and transportation of fuel conta iners .
- Make certain the fuel container meets
industry standards (ANSI/ ASTM
F852 -86) .
Q) Note
If any fuel has spilled onto the car, it
should be removed immediately to prevent
damage to the paint.
@ For the sake of the environment
As soon as the correctly operated nozzle
sw itches off automatically for the first
time, the tank is full. Do not try to add
more fuel because fuel may spill out. In
add ition, the expansion space in the fuel
tank will be filled -caus ing the fue l to
overflow when it becomes warm and pol­
lute the env ironment.
@ Tips
- Running yo ur engine while refuelling
may cause vapors to escape or
even
cause fue l to spill out of the tank. This
would then shut off the fuel nozzle be­
fore the tank is full.
- Do not refuel your vehicle with the igni­
tion switched on . The fuel gauge may
otherwise not indicate the correct fuel
level after refuelling.
- Diesel vehicles* are equipped with a die­
se l m isfueling protector.
It allows the vehicle to be
fueled only with a diesel
fuel pump nozzle . A worn or damaged
nozzle or a nozzle that is too small may
not be ab le to open the diesel misfueling
protector. If this is the case, try turning
the nozzle before inserting it in the fuel
filler neck, use a different fuel pump or
see your authorized Aud i dealer or au­
thorized repair facility for assistance.
- The fuel filler flap of your vehicle is not
locked when you lock the vehicle from
the inside .
Fuel filler flap emergency release
You can open the fuel filler flap by hand if the
power locking system should fail.
Fig. 192 V ehicl es with sele cti ve catalytic re d uc tion :
Right s ide tri m pan el
Fig. 19 3 Right s ide trim pan el in th e luggage compart·
m ent: em erg enc y re le ase m echani sm
The emergency release mechanism is located
behind the right side trim panel in the lug­
gage compartment. In vehicles with selective
catalyt ic re duction* , re move th e vent gr ill e
first :
... Press both tabs@q
fig. 192 and tilt the
vent gr ille downward. You can then remove
the grille upward . ..,_