2015 AUDI A7 S tronic

156 Airbag system
-Never remove the front passenger or
driver seat from the vehicle.
- Never remove the upholstery from the
front passenger seat.
- Never disassemble or remove parts from
the seat or disconnect wires from it.
- Never carry sharp objects in your pockets
or put them on the seat. The capacitive
passenger detection mat in the front
passenger seat will not function properly
if it is punctured .
- Never carry things on your lap or carry objects on the front passenger seat.
Such objects can influence the capaci­
tance registered by the capacitive pas ­
senger detection system, so that incor­
rect information is provided to the airbag
control unit.
- Never store items under the front pas­
senger seat. Parts of the Advanced Air­
bag System under the passenger seat
could be damaged, preventing them and
the airbag system from working proper­
ly.
- Never place seat covers or replacement upholstery that have not been specifical­
ly approved by Audi on the front seats.
- Seat covers can prevent the Advanced Airbag System from recognizing child re­
straints or occupants on the front pas­
senger seat and prevent the side airbag
in the seat backrest from deploying prop­
erly.
- If a seat heater has been retrofitted or
otherwise added to the front passenger
seat, never install any child restraint sys­
tem on this seat .
- Never use cushions, pillows, blankets, or similar items on the front passenger
seat. The additional layers prevent the
capacitive passenger detection system
from accurately measuring the capaci­
tance of the child safety seat and/or the
person on the seat and thus keep the Ad­
vanced Airbag System from working properly.
- Never place or use any electrical device
(such as a laptop, CD player, electronic games device
, power inverter or seat
heater for child seats) on the front pas­
senger seat if the device is connected to
the 12-volt socket or the cigarette light­
er socket . Such devices can influence the
capacitance registered by the capacitive passenger detection system, so that in­
correct information is provided to the air­
bag control unit.
- If you must use a child restraint on the
front passenger seat and the child re­
straint manufacturer's instructions re­
quire the use of a towel, foam cushion or
something else to properly position the
child restraint, make certain that the
PASSENGER AIR BAG OFF light comes
on and stays on whenever the child re­
straint is installed on the front passen­
ger seat.
- If the
PASSENGER AIR BAG OFF light
does not come on and stay on, immedi­
ately install child restraint in a rear seat­
ing position and have the airbag system inspected by your Audi dealer.
,8. WARNING
If the front passenger seat gets wet, dry it
immediately.
- If liquid soaks into the front passenger
seat, this can keep the airbag system
from working properly and may, for in­
stance, deactivate the passenger frontal
airbag. If this happens, the
PASSENGER
AIR BAG OFF
light will come on and stay
on together with the airbag indicator light
fl in the instrument cluster .
- If liquid is pooled on the seat, but has
not soaked in, this may also keep the air­
bag system from working properly and
cause the passenger frontal airbag to be
enabled (turned on), even though there is a properly installed child restraint sys­
tem on the seat . Wet towels or other wet
things on the seat cushion can have the
same effect. If the front passenger fron­
tal airbag is turned on, the
PASSENGER
AIR BAG OFF
light light will go out.

M N <( I.J "". rl I.O
"' rl
"' rl
How the Advanced Airbag System
components work together
The front Advanced Airbag System and the
side airbags supplement the protection of­
fered by the front three -point safety be lts
with pretensioners and load limiters and the
adjustable head restra ints* to help reduce the
risk of injury in a wide range of acc ident and
crash situat ions . Be sure to read the impor­
tant information about safety and heed the
WARNINGS i n this chap ter .
Dep loyment of the Advanced Airbag System
and the activat ion of the safety be lt pre ten­
sioners depend on the dece lerat ion meas ured
by the c rash senso rs and registered by the
e lectronic control u nit. Cr ash severity depends
on speed and dece leration as well as the mass
and stiffness of the vehicle or object involved
in the crash .
On the passenge r side, reg ard less of safety
be lt use, the fron t passenger fronta l airbag
will be t urned off i f the electrical capacitance
measured by the capac itive passenger detec­
tion system on the front passenger seat is less
than the amount programmed in the e lectron­
ic control unit. The front passenger frontal air­
bag will also be turned off if the capac itance
measured by the system for the front passen­
ge r seat equa ls that of an infant of about one
year of age in one of the child seats that was
used to cert ify the Advanced Airbag Sys tem
u nder Fede ral Motor Vehicle Safety Standard
208 . The
PASSENGER AIR BAG OFF light
comes on and stays on to tell you when t he
front Advanced Airbag System on the passen­
ger s ide has been turned off¢
page 160.
A WARNING
To reduce the risk of injury when an airbag
inf lates, a lways wear safety belts properly .
-If you are unrestrained, lean ing forward,
sitting sideways or out of position in any
way, yo ur r isk of inj ury is much hig he r.
- You w ill also receive serious injuries and
cou ld eve n be killed if you are up against
the a irbag or too close to it when it in-
A irba g sy stem 15 7
flates -even w it h an Advanced A irbag
¢page 147.
More important things to know about
front airbags
Fi g. 16 3 In flated front airbags
Safety be lts are important to he lp keep front
seat occupants in the proper seated position
so that airbags can unfold properly and pro­
vide supplementa l protect ion in a frontal col­
li s ion.
The front airbags are des igned to provide ad­
ditional protection for the chest and face of
the driver and the front seat passenger when :
- safety belts are worn proper ly,
- t he seats have been positioned so that the
occupant is properly seated as far as poss i­
ble from the airbag,
- and for ad justab le head restra ints: the head
restraints have been properly adj usted .
Bec ause airbags infl ate in the bli nk of an eye
wi th great force, th ings you have on your lap
o r have p laced on the seat co uld become dan ­
gerous projectiles, and be p ushed into you if
the a irbag inf lates.
When an airbag deploys, fine dust is re le ased.
This is norma l and is not caused by a fi re in
the ve hicle . This dust is made up mostly of a
powder used to lubricate the airbags as they
deploy. It could irr itate skin .
It is important to remembe r that wh ile the
supplementa l airbag system is designed to re­
duce the like lihood of serious injur ies, other
i njur ies, for example swelling, bruis ing and
minor abrasions, can also happen when air-
bags inflate . A irbags do not protect the arms .,_

158 Airb ag sys te m
or the lower parts of the body. Front airbags
supp lement the three-point safety belts only
in some frontal collisions in which the vehicle
dece leration is high enough to deploy the air­
bags.
F ront airbag s will not d eplo y:
-if the ignition is switched off when a crash
occurs,
- in side collisions,
- in rear-end collisions,
- in ro llovers,
- when the crash deceleration measured by
the a irbag system is less than the minimum
t h reshold needed for airbag deployment as
registered by the electron ic control unit.
The f ront pa ssenger airbag also will n ot
deploy:
- when the front passenger seat is not occu­
pied,
- when the electrical capac itance measured by
the capacitive passenger detect io n system
for the front passenger seat indicates that
the passenger side fronta l airbag must be
switched off by the e lectronic control unit
(the
PA SSENGE R AIR B AG OFF light
c> page 160 and how they work comes on
and stays on).
A WARNING
Sitting in the wrong position can increase
the risk of serious injury in crashes.
- To reduce the r isk of injury when the air­
bags inflate, the driver and passengers
must always sit in an upright position,
must not lean against or place any part
of the ir body too close to the area where
the a irbags are located.
- Occupants who a re unbelted, out of posi­
t ion or too close to the airbag can be se­
riously injured by an airbag as it un folds
with great force in the blin k of an eye
i=>page
149.
A WARNING
A child in a rearward-facing child seat in­
stalled on the front passenger seat will be
-
seriously injured and can be killed if the
front airbag inflates -even w ith an Ad­
vanced Airbag System.
- The inflating airbag will hit the ch ild seat
or infant carrier with great force and will
smash the child seat and child against
the backrest, center armrest, door or
roof.
- Always install rear-fac ing ch ild seats on
the rear seat .
- If you must install a rearward fac ing
child seat on the front passenger seat because of exceptional circumstances
and the
PASSENGER AIR BAG OFF light
does not come on and stay on, immed i­
ately insta ll the rear-facing child seat in a
rea r seating pos ition and have the airbag
system inspected by yo ur Audi dealer.
A WARNING
c'-----
Objects between you and the airbag will
increase the r isk of injury in a crash by in­
terfering with the way the airbag unfolds
or by be ing p ushed into you as the airbag
inflates.
- Never hold things in yo ur hands or on
your lap when the veh icle is in use.
-
- Never transport items on or in the area
of the front passenger seat. Objects
could move into the area of the front air­ bags during braking or other sudden ma­
neuvers and become dangerous projec­
tiles that can cause ser ious perso nal in­
jury if the a irbags inflate.
- Never p lace or attach accesso ries o r oth­
er objects (such as cup holders, te le­
phone brac kets, large, heavy or bulky ob­
jects) on the doors, over o r near the area
marked "AIRBAG" on the steering whee l,
instr ument panel, seat bac krests or be­
tween those areas and yourself. These
objects could cause in jury in a crash, es­
pecially when the airbags inflate.
- Never recline the front passenger's seat to transport objects. Items can also move into the area of the s ide airbag or
the front airbag during braking or in a

M N <( (.J
'SI: ,...., \!) 1.1'1 ,...., 1.1'1 ,....,
sudden maneuver . Objects near the
airbags can become projectiles and cause
injury, particularly when the s eat is re­
cl ined .
- Never place or transport objects on the
front passenger seat. Objects on the
front passenger seat could cause the ca­
pacitive senso r in the seat to s ignal to
airbag system that the seat is occupied
by a person whe n it in fact is not, o r that
the person on the sea t is heavier than he
o r she actually is. The change in electric
capacitance beca use of such objects can
cause the passenger front airbag to be
turned on when it sho uld be off, or can
cause the airbag to work in a way that is
different from the way it wou ld have
worked w ithout objects on the seat .
- Always make sure that there is nothing
on the front passenger seat that will
cause the capacitive passenge r detection
system in the seat to s ignal to the A irbag
System that t he seat is occupied by a
pers on when it is not, or to sign al tha t it
is occupied by someone who is heavier
than the pe rson actually sitting on the
seat . The presence of an o bject co uld
cause the passenger front a irbag to be
turned on when it sho uld be off, or co uld
cause the airbag to work in a way that is
different from the way it wou ld have
wor ked w ithout the object on the sea t.
A WARNING
The fine dust created when a irbags dep loy
c an cause b reathing problems for peop le
w ith a his to ry o f asthma o r other brea th­
ing condi tion s.
- T o reduce the r is k of brea thing prob lems,
those w it h a sthma or o ther resp iratory
condit ions should ge t fresh a ir right
away by getting out of the vehicle o r
opening windows or doo rs .
- If you are in a coll is ion in which a irbags
deploy, wash yo ur hands and face with
mild soap and water befo re eating.
A irbag system 159
-Be ca reful not to get the d ust into your
eyes, or into any c uts o r scratches .
- If the resi due should get into your eyes,
f lush them w ith water.
Monitoring the
Advanced Airbag
System
tli Airbag monitoring indicator light
Two seporate indicators monitor the function
of the Advanced Airbag System: the airbag
monitoring indicator light and the
PASSEN ­
GER AIR BAG OFF light.
The Advanced Ai rbag System (incl uding the
electronic control unit, sensor circu its and sys­
tem wir ing) is mo nitored continuously to
make sure that it is funct io ni ng properly
whenever the ignition is on . Each time you
switch on the ignition, the ai rbag mon itor ing
i ndica to r li ght
fl will come on for a few sec­
onds (self diagnos tic s).
The system must be inspected when the
indicator light
ffl:
- does not come on when the ignition is
sw itched on,
- does not go out a few seconds after you
have sw itched on the ignit io n, or
- comes on whil e dr iv ing .
If an airbag system malfunction is detected,
the indicator lig ht w ill first sta rt flash ing to
catch the driver's attent io n and then stay on
continuously to serve as a co nstant rem inder
to have the system inspected immediately.
If a malfu nction occurs that turns the front
airbag on the passenger s ide off, the
PASSEN­
GER AIR BAG OFF light will come on and stay
o n wheneve r th e ignit io n is on.
A WARNING
An ai rbag system t hat is not functioning
p roperly cannot p rovi de sup plemental pro-
-
tec tion in a frontal c rash . .,..
•
•

160 Airbag system
-If the air bag indicator light ¢ page 19
comes when the vehicle is being used,
have the system inspected immediately
by your autho rized Aud i dea ler . It is pos­
s ible that the airbag will inflate when it
is not s upposed to, or w ill not inflate
when it should.
PASSENGER AIR BAG OFF light
F ig. 164 Sect ion from t he in strument pa nel : PASS EN­
GER AIR BAG O FF ligh t
The PASSENGER AIR BAG OFF light is located
in the cen ter o f the instr ument panel
¢ fig . 164.
The PASSENGER AIR BAG OFF light will come
on an d stay on to te ll you when the fron t Ad ­
v a nce d Airbag on t he passenger side h as been
turned off by the e lectronic control unit . If the
bu lb for the
PASSENGER A IR BAG O FF light
burns out, the airbag ind icator light
II wi ll
come on to signal a malfunction in the Ad­
vanced A irbag System . Although the burned­
out bulb will not change the way the front
passenger's frontal airbag works, it w ill no
longer be possib le to use the
PASSENGER AIR
BAG OFF
light to make sure that the ai rbag
on/off s tat us is correct for the occupant on
the front passenger seat. Have the airba g sys­
tem inspected immediate ly by your autho r­
ized A udi dealer.
Th e PASSENGER AIR BAG OFF light will blink
for about 5 se cond s when :
- the ignit ion is switched on and
- the capac itive passenger detect ion system,
wh ich sw itches the front seat passenger 's
fron tal Advanced Airbag on and off, detects a change in the status of the front passen
­
ger seat.
As soon as the
PA SSENGER AIR BAG OFF
ligh t stops b linking, a lways make sure tha t
the airbag status (on or off) as shown by the
PASSENGER AIR BAG OFF light is proper for
the age, size and e lectrica l capacitance of the
person occupy ing the front passenger seat.
Always make sure that the safety belt for the
front passenger seat is properly fastened .
The PASSENGER AIR BAG OFF light will
show the status of the front seat passenger 's
frontal Advanced Airbag a fe w seconds after
the ignition i s switched on and the airbag in ­
dicator light go es off . The PASSENG ER AIR
BAG OFF light :
-will stay on if the front passenger seat is not
occupied;
- will stay on if the electrical capacitance
measured by the capacitive passenger de­
tect ion system for the front passenger seat
equals the combined capacitance of an in­
hnt up to abou t one year of age and one of
the rearwa rd- facing or forward-fac ing ch ild
restrai nts listed in Fede ral Motor Vehicle
Safety Standard 208 with which the Ad­
vanced Airbag System in your vehicle was certified; For a listing of the child restraints
that we re used to certify your vehicle's com ­
pliance w ith the U.S . Safety Standard
¢ page 175.
-will go out if the front passenger seat is oc­
cupied by an adult as registered by the ca­
pacitive passenger detection system .
- The
PASSENGER AIR BAG OFF light must
come on and stay on if the ignition is on
and ...
- a car bed has been installed on the front
passenger seat, or
- a rearward-facing child restraint has been
installed on the front passenger seat, or
- a forward-facing ch ild restra int has been in ­
stalled on the front passenger sea t,
- and if the electrical capacitance registered
on t he front passenger seat is equal to or
less than the combined capaci tance of a typ-
ical 1 year-o ld i nfant and one of the
1111>

M N <( I.J "". rl I.O
"' rl
"' rl
Remember too, airbags will deploy only once
and only in certain kinds of accidents -your
safety belts are a lways there to offer protec ­
tion in those acc idents in which airbags are
not supposed to deploy or when they have al­
ready deployed, for example when your vehi ­
cle str ikes or is struck by another afte r the
fi rst coll is ion.
This is just one of the reasons why an a irbag is
not a substitute for the safety belt . The airbag
system works most effectively when used with
the safety belts . Therefore, always wear your
safety bel ts correctly .
It is important to remember that while the
supplemental knee a irbag system is des igned
to reduce the like lihood of serious injur ies,
o ther in juries, fo r example, swel ling , bruising
and minor abras io ns and frict ion bu rns ca n al ­
so occur when an airbag inflates.
The knee airbag system basically consists
of :
-The elec tronic control mod ule
- T wo inf latab le airbags (airbag and gas gen-
erato r), one for the driver and one for the
front passenger
- T he airbag ind icator light in the instrument
pane l
The knee airbag system will not deploy:
-when the ign ition is switc hed off
- in frontal collisions w hen the decelerat ion
measured by the control unit is too low
- in s ide collisions
- in rear-end collisions
- in ro llovers
- in the event of a system malfunct io n (wa rn -
i ng/indicator ligh t is on)
r::!>page 19.
& WARNING
- Safety belts and the airbag system can
only p rov ide protection when occ upants
are in the proper seating posit ion
c::>page 157.
-If the airbag indicator light c::> page 19
comes when the vehicle is be ing used,
have the system inspected immediately
A irba g sy stem 165
by your authorized A udi dealer. It is pos­
sib le that the airbag will inflate when it
is not supposed to , or will not inflate
when it should .
How knee airbags work
Applies to vehicles: with knee airbags
The risk of injury to the leg area can be re ­
duced by fully inflated knee airbags.
~ N 0 :..c---0
i::....---ali
Fi g. 166 In flated a irbags protect ing in a fronta l coll i·
s ion
The knee airbag system has been designed so
that the airbags for the driver and front pas­
senger deploy in certain but not all frontal
collisions.
If the front airbags dep loy, the knee airbags
also dep loy in fronta l collisions when the de­
ployment th resho ld stored in the control unit
is met.
When the system deploys, the ai rbags fill
with a propellant gas, and inflate between the l ower part of the instrument pane l and the
driver and t he lower part of the instrument
panel and the front passenger
c::> page 157,
fig . 163 .
Although they are not a soft pi llow, they can
"cushion" the impact and in th is way they can
help to reduce the risk of injury to the lower
extremit ies .
A ll of th is takes place in the blink o f an eye, so
fast that many people don't even realize that
the a irbags have deployed. The airbags a lso
i nfla te with a g reat dea l of fo rce and i t is im­
po rtant for occupant safety t hat nothing
sho uld be in their way whe n they deploy. ..,.

M N <( (.J
'SI: ,...., \!) 1.1'1 ,...., 1.1'1 ,....,
caused by airbags when they inflate, particu­
l arly when the occupant sitting next to it is
not seated properly. The s ide a irbag for the
front passenger seat can be used with proper ­
ly installed chi ld res traints. Please be sure to
read the important information and warnings
whenever us ing a child restraint in a veh icle :
Safety belts
c::;, page 138, A irbag system
c::;, page 147, Child safety ~ page 173.
The side airbag system basically con sists of:
- the e lectronic control module and external
s ide impact sensors
- the two airbags located in the sides of the
front backrests and the two airbags* located
in the rear backrest
- the airbag warning light in the instrument
cluster.
The airbag system is monito red elect ron ica lly
to make certain that it is functioning properly
at all times. Each time you switch on the igni­
tion, the airbag system indicator light will
come on for a few seconds (self diagnostics) .
T he side airbag system supplements the safe­
ty belts and can help to reduce the risk of in ­
jury to the driver's, front and rear passenger's upper torso on t he side of the vehicle that is
struck in a side collision . The airbag deploys
only in s ide impac ts and on ly when the veh icle
acceleration registered by the control u nit is
hi gh enough . If this rate is below the refer­
e nce va lue progr ammed i nto the con trol un it,
the side airbags will not be triggered, even
though the ca r may be badly damaged as a re­
sult of the collision . It is not possible to de­
f ine an a irbag trigger ing range that will cover
eve ry possible angle of impact, since the cir­
cumstances will vary considerably between
one co llision and another . Important facto rs
in clude, for examp le, the natu re (hard o r soft)
of the impacting objec t, the ang le of impact ,
ve hicl e speed, etc. ~
page 1 68, Impor tan t
safety instructions on the side airbag system.
Aside from the ir no rmal safety function, safe­
ty belts wor k to he lp keep the d river or front
passenger in posi tion in the event of a side
Airbag system 167
collision so that the side airbags can provide
protection.
T he airbag system is
not a substi tute fo r your
s af ety belt . Ra ther, it is part o f the over all oc­
cupant restra int system in you r vehicle . A l­
ways remember that the side airbag system
can on ly help to protect yo u if you are wearing
your safety be lt and wearing it proper ly. This
is another reason why you should always wear
your safety be lts, not just because the law re­
quires you to do so c::;,
page 138, General
notes.
It is important to remember that wh ile the
suppleme nta l side airbag system is desig ned
to r educe the likelihood of ser ious injuries,
othe r injur ies, for exampl e, swelling, bru is ing ,
friction bur ns and m ino r abrasions can a lso be
associ ated w ith dep loye d side airbags. Re­
member too, si de a irbags w ill dep loy o nly
once an d only in ce rtain kinds of accidents -
yo ur safety be lts a re a lways there to offer p ro ­
tection .
Vehicle damage, repair costs o r even the lack
of ve hicle damage are not necessarily a n indi ­
cation of over-sensitive or failed airbag activa­
tion. In some coll is ions, both front and side
a irbags may inflate. Remember too, that air­
bags will deploy only once a nd only in cer tain
ki nds of col lisions -you r safety belts a re a l­
ways t he re to offe r protection in those acc i­
dents i n which a irbags are not supposed to
deploy or when they have a lready deployed .
The side airbag system will not deploy:
-when the ignit io n is switched off
- in side co llisions whe n the acceleration
meas ured by t he sensor is too low
- in front-end collisions
- in rear -end co llisions
- in rollove rs .
In some types of accidents the front airbags,
s ide cu rtain airbags and s ide a irbags may be
t rigge red together. .,,. •
•

1 70 Airbag system
The side curtain airbags are located on both
sides of th e interior above the front and rear
side windows ~
fig. 169. They are ident ified
by the word "AIRBAG" on the windshield
frame and the center roof pillar.
The side curtain airbag system supplements
the safety belts and can help to reduce the risk of injury for occupants' heads and uppe r
torso on the side of the vehicle that is struck
in a side collision . The side curtain airbag in­
flates in side impacts and only when the vehi­
cle acceleration registered by the control unit is high enough. If this rate is below the refer­
ence value programmed into the control unit,
the side curtain airbag will not be triggered,
even though the car may be badly damaged as
a result of the collision. It is not possible to
define an airbag triggering range that will
cover every possible angle of impact, since the
circumstances will vary considerably between
one collision and another. Important factors
include, for example, the nature (hard or soft)
of the impacting object, the angle of impact,
vehicle speed, etc.~
page 171, How side cur­
tain airbags work.
Aside from their normal safety function, safe­
ty belts work to help keep the driver or front
passenger in position in the event of a colli­
sion so that the side curtain airbags can pro­
vide protection.
The airbag system is not a substitute for your
safety belt. Rather, it is part of the overall oc­
cupant restraint system in your vehicle. Al­
ways remember that the airbag system can
only help to protect you if you are wearing
your safety belt and wearing it properly. This
is another reason why you should always wear
your safety belts, not just because the law re­
quires you to do so
Q page 138, General
notes.
It is important to remember that while the
side curtain airbag system is designed to help
reduce the likelihood of serious injuries, other
injuries, for example, swelling, bruising, fric ­
tion burns and minor abrasions can also be as­
sociated with these airbags upon deployment. Remember too, these airbags will deploy only once and only in certain kinds of accidents
-
your safety belts are always there to offer pro­
tection.
The side curtain airbag system basically
consists of:
- The electronic control module and external
side impact sensors
- The side curtain airbags above the front and
rear side windows
- The airbag indicator light in the instrument
panel
The airbag system is monitored electronically
to make certain it is functioning properly at all
times. Each time you switch on the ignition,
the airbag system indicator light will come on
for a few seconds (self diagnostics).
The side curtain airbag is not activated:
- if the ignition is switched off,
- in side collisions when the acceleration
measured by the sensor is too low,
- in rear-end collisions.
_&. WARNING
- Safety belts and the airbag system will
only provide protection when occupants
are in the proper seating position
¢page 53, General recommendations.
- If the airbag indicator light Q page 19
comes when the vehicle is being used,
have the system inspected immediately
by your authorized Audi dealer. It is pos­
sible that the airbag will inflate when it
is not supposed to, or will not inflate
when it should.
.