2015 Alfa Romeo 4C brake fluid

It is recommended to check the
windscreen washer fluid regularly, in
particular in driving conditions needing
a heavier use of the windscreen washer.
If the level is not sufficient, namely if
there is no fluid inside the pipe, proceed
as follows:
❒to avoid any interference during the
procedure, lift the windscreen wiper
blade according to the "Windscreen
wiper" paragraph in the
"Maintenance and care" chapter;
❒loosen the 4 self-tapping screws A
fig. 121 using the supplied
screwdriver. Remove the engine
cover grille;❒take the white funnel D fig. 124 for
topping up the windscreen washer
fluid/fuel and its extension pipe from
the service kit in the luggage
compartment;
❒take out the plug B fig. 122 with the
fluid control pipe through the engine
cover opening on the grille;
❒introduce the funnel D fig. 124 and its
extension pipe in the reservoir neck
and top up;❒after topping up, remove the funnel D
with the extension pipe;
❒refit the plug B with the dipstick;
❒reposition the engine cover grille and
tighten the 4 self-tapping screws A.
BRAKE FLUID
125) 126)
25) 26)
To check the brake fluid level, proceed
as follows:
❒loosen the 2 self-tapping screws E
fig. 125 and remove the protection
panel;
❒check that the fluid is at the max.
level.
❒after checking, reposition the
protection panel and tighten the 2
self-tapping screws E.
122A0L0131
123A0L0147
124A0L0148
148
SERVICING AND MAINTENANCE

If the fluid level in the reservoir is not
sufficient, proceed as follows:
❒take the black funnel for topping up
the brake fluid and its extension
pipe from the service kit in the
luggage compartment;
❒loosen the reservoir plug and
introduce the funnel F fig. 126 with
the extension pipe in the reservoir
inlet;
❒after topping up, remove the funnel F
with the extension pipe;
❒tighten the reservoir plug;
❒reposition the protection panel and
tighten the 2 self-tapping screws E.
WARNING Be very careful while
removing the plug from the opening to
prevent the plug from falling inside
the vehicle body.
IMPORTANT
21) Be careful not to confuse the
various types of fluids while
topping up: they are not
compatible with each other!
Topping up with an unsuitable
fluid could severely damage your
vehicle.
22) The oil level should never exceed
the MAX mark.
23) Do not add oil with specifications
other than those of the oil already
in the engine.24) PARAFLU
UPanti-freeze fluid is
used in the engine cooling
system; use the same fluid type as
that already in the cooling system
when topping up. PARAFLU
UP
may not be mixed with other types
of anti-freeze fluids. If topping up
with an unsuitable product, under
no circumstances start the engine
and contact a dedicated Alfa
Romeo Dealership.
25) Avoid allowing brake fluid, which
is extremely corrosive, to come
into contact with painted areas.
Should it happen, immediately
wash with water.
26) Be very careful while topping up
the brake fluid, as it could drip
from the extension pipe inside the
vehicle under the engine cover
and on parts of the body and
windscreen, corroding and
damaging them. Adopt suitable
protection (e.g absorbing paper)
to reduce this risk as much as
possible.
125A0L0149126A0L0160
149

WARNING
118) The Alfa Romeo 4C is designed
and produced for road use, in
compliance with the current
regulations. Vehicle use in the
track must be considered as
occasional and in any case under
the responsibility of the user.
The vehicle CANNOT be modified
or tampered with for any reason,
this would alter the Manufacturer
homologation and/or safety
requirements. Using a modified or
tampered product relieves the
Manufacturer from any
responsibility on it and may
expose people to serious risks.
119) Never smoke when performing
operations in the engine
compartment. Flammable gases
and fumes may be present, with
the risk of fire.
120) Be very careful when working in
the engine compartment if the
engine is hot: risk of burns.121) If the engine oil is being topped
up, wait for the engine to cool
down before loosening the filler
plug, particularly for cars with
aluminium plug (for versions/
markets, where provided).
WARNING: risk of burns!
122) The cooling system is
pressurised. If necessary, only
replace the plug with another
original one or the operation of
the system may be adversely
affected. Do not remove the
reservoir plug when the engine is
hot: risk of burns.
123) Do not travel with the
windscreen washer reservoir
empty: the windscreen washer is
essential for improving visibility.
Repeated operation of the system
without fluid could damage or
cause rapid deterioration of some
system components.
124) Certain commercial additives
for windscreen washer fluids are
inflammable. The engine
compartment contains hot
components which may set it on
fire.125) Brake fluid is poisonous and
highly corrosive. In the event of
accidental contact, immediately
wash the affected parts with
water and mild soap. Then rinse
thoroughly. Call a doctor
immediately if swallowed.
126) Thesymbol on the container
indicates a synthetic brake fluid,
which is different from a mineral
fluid. Using a mineral fluid will
damage the special rubber seals
of the braking system beyond
repair.
IMPORTANT
3) Used engine oil and oil filters
contain substances which are
harmful to the environment. You
are advised to go to a dedicated
Alfa Romeo Dealership to have
the oil and filters changed.
150
SERVICING AND MAINTENANCE

TECHNICAL SPECIFICATIONS
Everything you may find useful for
understanding how your car is made
and works is contained in this chapter
and illustrated with data, tables and
graphics. For the enthusiasts and the
technician, but also just for those who
want to know every detail of their
car.IDENTIFICATION DATA....................162
ENGINE CODES - BODY
VERSIONS ......................................164
ENGINE ..........................................165
FUEL SUPPLY .................................166
TRANSMISSION .............................167
BRAKES .........................................168
SUSPENSION .................................169
STEERING ......................................170
WHEELS .........................................171
DIMENSIONS ..................................175
PERFORMANCE .............................176
WEIGHTS .......................................177
REFUELLING ..................................178
FLUIDS AND LUBRICANTS ............179
FUEL CONSUMPTION ....................182
CO2 EMISSIONS ............................183
PRESCRIPTIONS FOR HANDLING
THE VEHICLE AT THE END OF ITS
LIFE ................................................184
161

WEIGHTS
Versions 1750 Turbo Petrol
Unladen weight (with all fluids, fuel tank
90% full and without optional equipment):920
Payload including the driver: (*) 255
Maximum permitted loads (**)
– front axle: 490
– rear axle: 755
– total:1175
Towable loads (kg)
- braked trailer: 0
- non-braked trailer: 0
Maximum load on roof: 0
Maximum load on ball joint (braked trailer): 0
(*) If special equipment is fitted, the unladen vehicle weight increases, thus reducing the specified payload.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment within the maximum permitted loads.
177

REFUELLING
1750 Turbo Petrol
Prescribed fuels / Original fluids
and lubricants
litres kg
Fuel tank 40 -
Unleaded petrol not less than 95
RON (EN 228 specification)
including a reserve of 4 - 5 -
Engine cooling system 10.6 9.4Mixture of 50% demineralised water
and 50% PARAFLU
UP(*)
Engine sump 5.4 4.6
SELENIA SPORT POWER
Engine sump and filter 5.8 5.0
Transmission/differential casing: 1.88 1.6TUTELA TRANSMISSION
GEARTECH
Transmission hydraulic activation system 1.45 1.2 TUTELA CS SPEED
Hydraulic brake circuit with ABS 0.52 0.56 TUTELA TOP 4
Windscreen washer fluid reservoir 1.9 1.7Mixture of water and TUTELA
PROFESSIONAL SC 35
(*) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand demineralised water.
178
TECHNICAL SPECIFICATIONS

UseFluid and lubricant specifications for a correct
use of the carGenuine fluids and
lubricantsApplications
Lubricants and
greases for drive
transmissionSAE 75W 85 grade synthetic lubricant
FIAT 9.55550-MZ3 classification.TUTELA
TRANSMISSION
GEARTECH
Contractual Technical
Reference No. F704.C08TCT automatic
transmission
Specific fluid for electro-hydraulic ratio selector
actuators
FIAT 9.55550-SA1 classificationTUTELA CS SPEED
Contractual Technical
Reference No. F005.F98Lubricant for electro-
hydraulic actuator
Molybdenum disulphide grease, for use at high
temperatures. NL.G.I. 1-2 consistency
FIAT 9.55580 classificationTUTELA ALL STAR
Contractual Technical
Reference No. F702.G07Wheel side constant
velocity joints
Grease for constant velocity joints with low friction
coefficient. NL.G.I. 0-1 consistency
FIAT 9.55580 classificationTUTELA STAR 700
Contractual Technical
Reference No. F701.C07Differential side
constant velocity joints
Brake fluidSynthetic fluid for brake and clutch systems.
Exceeds specifications: FMVSS no. 116 DOT 4,
ISO 4925, SAE J1704
FIAT 9.55597 classificationTUTELA TOP 4
Contractual Technical
Reference No. F001.A93Hydraulic brakes and
hydraulic clutch
controls
180
TECHNICAL SPECIFICATIONS

INDEX
A
BS .............................................. 43
– System intervention ................... 43
Air cleaner ...................................... 151
Alarm ............................................. 13
Alfa DNA system ........................ 46
– "All Weather" mode ................... 48
– Driving modes ........................... 47
– “Dynamic” mode ....................... 47
– "Natural" mode.......................... 47
– “Race” mode............................. 47
lfa Romeo Code system ............. 10
Ashtray .......................................... 36
ASR system (AntiSlip Regulation) ... 43
Backrest pocket ........................... 36
Battery ........................................... 151
– advice for extending lifetime ...... 151
– replacement .............................. 151
Battery (recharging) ........................ 136
Body versions ................................ 164
Bodywork
– body codes ............................... 164
– maintenance ............................. 156
– protection against
atmospheric agents................... 156
– warranty .................................... 156
Brakes ........................................... 168
– brake fluid level.......................... 148bulb replacement.................... 130-131
Bulb replacement
– exterior lights ............................. 129
– interior lights .............................. 132
Bulbs
– types of bulbs ........................... 127
Car inactivity ................................. 114
Carrying children safely .................. 95
CBC (Cornering Brake Control)
system ......................................... 43
Central locking ............................... 33
Changing a bulb............................. 126
– General instructions................... 126
Changing a wheel .......................... 122
Cigar lighter.................................... 35
Cleaning and maintenance
– bodywork .................................. 156
– car interior ................................. 157
– engine compartment ................. 157
– front headlights ......................... 156
– leather parts .............................. 158
– leather seats.............................. 158
– plastic and coated parts ............ 158
– seats and fabric parts ................ 158
– windows.................................... 156
Climate control ............................... 19
– Passenger compartment air
diffusers .................................... 20
Climatic comfort ............................. 20
Clutch ............................................ 167CO2 emissions............................... 183
Conditions of use ........................... 112
Control buttons .............................. 64
Control panel and instruments ....... 62
Controls ......................................... 33
Cruise Control ................................ 30
Cup holder ..................................... 36
Daytime running lights (DRL) ......... 28
Dimensions .................................... 175
Dipped beam headlights
– bulb replacement ...................... 129
Direction indicators ........................ 29
– bulb replacement ...................... 129
– “Lane change” function ............. 29
Door mirrors
– Door mirrors .............................. 18
Doors ............................................. 37
– Central door
locking/unlocking ...................... 37
Driver's side front airbag ................ 99
Driving style.................................... 112
DTC (Drag Torque Control)
system ......................................... 43
EBD system .................................. 43
Electric windows ............................ 38
– Controls .................................... 38
Electronic Q2 system ("E-Q2") .... 45
ngine codes ................................ 164
Engine compartment
INDEX
A
E