2015.5 VAUXHALL VIVARO spare wheel

Vehicle care165
5. Unscrew wheel bolts completelyby turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 165.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench locates securely. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).
11. Stow the replaced wheel 3 165
and the vehicle tools 3 155.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 190.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 161.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a flat rear tyre.
Wheel changing 3 164.

166Vehicle care
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied. Vehicle tools 3 155.
9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,loosen bolt 1, ensuring it is not fully
removed. Fully remove bolt 2, then
pull the carrier to the left, until it clears bolt 1, and lower the carrier assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Do not drive faster than 50 mph.
■ Drive particularly carefully on wet and snow-covered road surfaces.

Technical data181Vehicle weight
Kerb weight, basic model
Optional equipment and accessories increase the kerb weight.
Loading information 3 71.ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 2)3)VanR9ML1H1100027001661120029001661H2120029001760-1771L2H1120029001691-1695H21200290017752)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.

182Technical data
ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight2)3)Combi, BusR9ML1H1100027001901120029001901L2H11200290019012)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 2)3)Platform cabR9ML2H11200290015502)
Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.
3) Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludes the weight of the driver and deletable
options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may vary according to the specification of the vehicle, e.g. options, deleted
options and accessories.

190Technical dataTyre pressuresTyreTyre pressure with full load8)Front
[kPa/bar] (psi)Rear
[kPa/bar] (psi)205/65 R16 C380/3.8 (55)420/4.2 (61)215/65 R16 C310/3.1 (45)340/3.4 (49)195/75 R16 C380/3.8 (55)420/4.2 (61)215/60 R17 C350/3.5 (51) 9)390/3.9 (57)10)8)
The spare wheel should be set to the highest applicable pressure shown in the table.
9) Combi/Bus: 320/3.2 (46) for non-motorway driving below 100 mph.
10) Combi/Bus: 350/3.5 (51) for non-motorway driving below 100 mph.

197
Manual transmission .................. 119
Messages ..................................... 89
Mirror adjustment ........................... 8
Mirrors .................................... 36, 37
Misted light covers .......................96
N
New vehicle running-in ..............111
Number plate light .....................149
O Object detection systems ...........128
Octane rating .............................. 180
Odometer ..................................... 79
Oil ............................................... 138
Oil, engine .......................... 174, 179
Oil pressure .................................. 86
Outside temperature ....................76
Overcab storage ..........................68
Overrun cut-off ........................... 115
P Parking ................................ 18, 117
Parking assist ............................ 128
Parking brake ............................ 121
Particulate filter ........................... 118
Performing work ........................137
Pollen filter ................................. 109
Power button ........................ 17, 112
Power outlets ............................... 77Power steering fluid....................141
Power windows ............................ 38
Preheating ........................... 86, 114
Puncture ..................................... 164
R Radio Frequency Identification (RFID) ..................................... 192
Radio remote control ...................19
Rear air conditioning system .....103
Rear doors ................................... 29
Rear fog light ............................... 87
Rear fog lights ........................ 93, 96
Rear heating system .................. 103
Rear seats .................................... 45
Rear view camera ...................... 130
Rear windows .............................. 39
Rear window wiper/washer .......... 75 Recommended fluids and lubricants ........................ 174, 179
Refuelling ................................... 132
Remote control ............................. 19
Reversing light ........................... 148
Reversing lights ........................... 96
Ride control systems ..................122
Roof load ...................................... 71
Roof rack ..................................... 71S
Safety belts ................................... 48
Safety net .................................... 69
Seat adjustment ....................... 7, 43
Seat belt ........................................ 8
Seat belt reminder .......................83
Seat belts ..................................... 48
Seat folding .................................. 44
Seat heating ................................. 45
Seat position ................................ 42
Seats ............................................ 67
Service ............................... 109, 173
Service display ............................ 80
Service information ....................173
Service vehicle soon .................... 84
Side airbag system ......................55
Sidelights ...................................... 93
Side turn signal lights ................148
Sliding door .................................. 29
Spare wheel ............................... 165
Spare wheel security tool ...........155
Speed limiter......................... 78, 128
Speedometer ............................... 78
Starting and operating ................111
Starting off ................................... 17
Starting the engine ...............17, 114
Steering ...................................... 111
Steering column controls ..............74
Steering wheel adjustment ......9, 73