2015.5 VAUXHALL MOVANO_B fuel filter

Instruments and controls85
■ Vehicle messages 3 85
■ Trip computer 3 86
Some of the displayed functions differ
when the vehicle is being driven or at a standstill. Some functions are only
available when the vehicle is being
driven.
Triple-Info-Display
Displays time, outside temperature
and date when the ignition is on.
Vehicle messages
Messages appear in the Driver
Information Centre, in combination
with control indicator A or C.
Information messagesInformation messagesBATTERY MODE: ECONOMYESP OFFAUTO LIGHTS DEACTIVATEDOIL LEVEL CORRECT
Fault messages Displayed in combination with control
indicator A. Drive with caution and
seek the assistance of a workshop.
To remove fault message, press
button on end of wiper lever. After a
few seconds the message may
disappear automatically and A
remains illuminated. The fault will
then be stored in the on board
system.Fault messagesCHECK ESPCHECK FUEL FILTERCHECK GEARBOXCHECK AUTO LIGHTS
Warning messages
These may appear with control
indicator C or in combination with
other warning messages, control
indicators or an audible warning. Stop
engine immediately and seek the
assistance of a workshop.

Driving and operating109
systems function during an Autostop,
but there will be a controlled reduction
in power steering assist and vehicle
speed is reduced.
Stop-start system 3 111.
Pedals
To ensure the pedal travel is
uninhibited, there must be no mats in the area of the pedals.
Steering If power steering assist is lost
because the engine stops or due to a system malfunction, the vehicle can
be steered but may require increased
effort.Caution
Vehicles equipped with hydraulic
power steering:
If the steering wheel is turned until it reaches the end of its travel, and
is held in that position for more
than 15 seconds, damage may
occur to the power steering
system and there may be loss of
power steering assist.Starting and operating
New vehicle running-in Do not brake unnecessarily hard for
the first few journeys and after new
disc brake pads have been fitted.
During the first drive, smoke may
occur because of wax and oil
evaporating off the exhaust system.
Park the vehicle in the open for a
while after the first drive and avoid
inhaling the fumes.
During the running-in period fuel and
engine oil consumption may be
higher and the cleaning process of the diesel particle filter may take
place more often. Autostop may be inhibited to allow for charging the
vehicle battery.
Stop-start system 3 111.
Diesel particle filter 3 116.

116Driving and operatingEngine exhaust9Danger
Engine exhaust gases contain
poisonous carbon monoxide,
which is colourless and odourless and could be fatal if inhaled.
If exhaust gases enter the interior
of the vehicle, open the windows.
Have the cause of the fault
rectified by a workshop.
Avoid driving with an open load
compartment, otherwise exhaust
gases could enter the vehicle.
Diesel particle filter
The diesel particle filter system filters
harmful soot particles out of the
exhaust gases. The system includes
a self-cleaning function that runs
automatically during driving without
any notification.
The filter is cleaned by periodically
burning off the soot particles at high
temperature. This process takes
place automatically under set driving
conditions. Autostop is not available
and fuel consumption may be higher
during this period. The emission of
smells and smoke during this process is normal.
Under certain driving conditions, e.g.
short distances, the system cannot
clean itself automatically.
If cleaning of the filter is required and
if previous driving conditions did not
enable automatic cleaning, it will be
indicated by illumination of control
indicator A 3 80. Seek the
assistance of a workshop
immediately.Caution
If the cleaning process is
interrupted, there is a risk of
provoking severe engine damage.
Cleaning takes place quickest at high engine speeds and loads.
Catalytic converter
The catalytic converter reduces the
amount of harmful substances in the
exhaust gases.Caution
Fuel grades other than those listed on page 3 132, 3 185 could
damage the catalytic converter or
electronic components.
Unburnt petrol will overheat and
damage the catalytic converter.
Therefore avoid excessive use of the starter, running the fuel tank
dry and starting the engine by
pushing or towing.
In the event of misfiring, uneven
engine running, a reduction in engine performance or other unusual
problems, have the cause of the fault
rectified by a workshop as soon as
possible. In an emergency, driving
can be continued for a short period,
keeping vehicle speed and engine
speed low.

Driving and operating133
diesel, Aquazole and similar diesel-
water emulsions. Diesel fuels must not be diluted with fuels for petrol
engines.
The flow and filterability of diesel fuels are temperature-dependent. When
temperatures are low, refuel with
diesel fuel with guaranteed winter
properties.
Diesel fuel filter 3 146, diesel fuel
system bleeding 3 146.
Refuelling9 Danger
Before refuelling, switch off engine
and any external heaters with
combustion chambers. Switch off
any mobile phones.
Follow the operating and safety
instructions of the filling station
when refuelling.
9 Danger
Fuel is flammable and explosive.
No smoking. No naked flames or
sparks.
If you can smell fuel in your
vehicle, have the cause of this
remedied immediately by a
workshop.
Caution
In case of misfuelling, do not
switch on ignition.
The fuel tank filler neck with bayonet
cap is located on the left front side of
the vehicle.
The fuel filler flap can only be opened
if the vehicle is unlocked and the door is opened. Open the fuel filler flap by
hand.
Remove the fuel filler cap by turning
it anti-clockwise.
The fuel filler cap can be hung on the lower hook of the fuel filler flap.
For refuelling, fully insert the pump
nozzle and switch it on.
After automatic cut-off, it can be
topped-up with max. two doses of fuel.
Caution
Wipe off any overflowing fuel
immediately.

146Vehicle careDiesel fuel filter
Drain diesel fuel filter of residual
water at every engine oil change.
Place a container underneath the
filter housing. Loosen the knurled
screws on the filter cover and on the
lower part of the filter by approx. one
turn, to drain off the water.
The filter is drained as soon as diesel fuel emerges from the knurled screw
at the bottom. Retighten the two
screws.
Check diesel fuel filter at shorter
intervals if the vehicle is subjected to
extreme operating conditions.
Diesel fuel system
bleeding
If the fuel tank has been run dry, it will be necessary to air vent or bleed the
diesel fuel system.
Fill the tank with fuel and proceed as
follows:
1. Place a suitable container underneath the fuel filter vent
screw to collect fuel.
2. Loosen the vent screw (arrowed) by one turn.
3. Manually operate the in-line supply pump slowly and steadily
until fuel discharging from the
loosened vent screw is free of air
bubbles.
4. Retighten the vent screw.
If the engine cannot be started after
several attempts to bleed the diesel
fuel system, seek the assistance of a
workshop.
Wiper blade replacement Wiper blades on the windscreen

Vehicle care157Instrument panel fuse box
Located behind the trim panel on the
left-hand side of the instrument panel. Pull upper part of trim panel to
remove.
Do not store any objects behind this
panel.
Some circuits may be protected by
several fuses.
SymbolCircuitZInfotainment system, seat
heating, vehicle display
screen, audio connections,
alarm?Power outletÌCigarette lightereInstrument panelUCentral lockingOTurn signals, rear fog lights,
body control moduleDIAGDiagnostic connectoruABS, Electronic stability
programdInterior lights, brake lightsZBody control moduleSTOPBrake lightIBody control module, power windows, heating and venti‐
lation system, air condi‐
tioningSymbolCircuitmLeft heated rear windownRight heated rear windowRWindscreen washerMElectronic immobiliserUHeated seatsFBLCornering lightlHands-free connection&TachographPTOPower take-offjHornÍPreheating, diesel fuel filterxClimate control fanADPAdditional adaptations,Power windows, body
control module

200Technical data
VanRear-wheel driveLengthL3L4Roof heightH2H3H2H3Gross vehicle weight350045003500450045004500Maximum rear door aperture height [mm]172417241724172417241724Rear door aperture width (at floor) [mm]158015801580158015801580Maximum load area height [mm]179817982048204817982048Maximum load area width [mm]176517651765176517651765Width between wheel arches [mm]138010801380108010801080Maximum load floor length [mm]373337333733373343834383CapacitiesEngineM9TEngine oil including filter [l]Front-wheel drive 8.0
Rear-wheel drive 8.9between MIN and MAX [l]1.5 - 2.0Fuel tank, nominal capacity [l]80 or 105

207
Cleaning the vehicle...................175
Climate control ............................. 14
Climate control systems ...............96
Clock ............................................ 72
Control indicators.......................... 77
Control of the vehicle .................108
Controls ........................................ 69
Convex shape .............................. 30
Coolant ....................................... 142
Coolant and antifreeze ...............179
Coolant heater ............................ 102
Cornering light ......................91, 150
Coupling ball bar ........................135
Cruise control ...................... 84, 126
Cupholders .................................. 62
D Danger, Warnings and Cautions ...3
Dashboard .................................... 10
Daytime running lights .................90
Declaration of conformity ............203
Demisting and defrosting ..............14
Diesel fuel ................................... 132
Diesel fuel filter .......................... 146
Diesel fuel system bleeding .......146
Diesel particle filter ....................116
Door locks..................................... 19
Door open .................................... 84
Doors ............................................ 24
DPF (diesel particle filter) ...........116Driver assistance systems ..........126
Driver Information Centre .............84
Driving characteristics and towing tips .............................. 134
Driving economically................... 108
Driving hints ................................ 108
E ECO mode .................................. 108
Electric adjustment ......................31
Electrical system......................... 155
Electronic climate control system 98
Electronic driving programmes ..120
Electronic Stability Program .....
.................................. 81, 125, 136
Electronic Stability Program off ...82
Emergency exit ............................. 35
End-of-life vehicle recovery .......139
Engine compartment fuse box ...156
Engine coolant ........................... 142
Engine coolant temperature ........82
Engine coolant temperature gauge ....................................... 75
Engine data ............................... 185
Engine exhaust .......................... 116
Engine identification ...........182, 183
Engine oil ................... 140, 179, 184
Engine oil additives ....................179
Engine oil level monitor ................76
Engine oil pressure ......................82Engine oil viscosity grades .........179
Enhanced Traction function 124, 125
Event data recorders ..................203
Exhaust gases ............................ 116
Exit lighting .................................. 95
Exterior care .............................. 175
Exterior light ................................. 83
Exterior lighting ......................12, 89
Exterior mirrors ............................. 30
F
Fault ........................................... 121
Fire extinguisher ..........................66
First aid ......................................... 66
First aid kit ................................... 66
Fixed air vents ........................... 107
Fog light ....................................... 84
Fog lights .............................. 92, 150
Folding mirrors ............................. 31
Front airbag system .....................50
Front fog lights ........................ 89, 92
Front seats.................................... 37
Front storage ............................... 62
Front turn signal lights ...............150
Fuel consumption - CO 2-
Emissions ............................... 134
Fuel for diesel engines ..............132
Fuel gauge ................................... 75 Fuse box ............................. 156, 157
Fuses ......................................... 155