2015.5 VAUXHALL INSIGNIA spare wheel

260Vehicle care
Jacking position for liftingplatform
Rear arm position of the lifting
platform at the underbody.
Front arm position of the lifting
platform at the underbody.
Spare wheel Some vehicles are equipped with a
tyre repair kit instead of a spare
wheel.
If mounting a spare wheel, which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.
The spare wheel has a steel rim.Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
The spare wheel is located in the load
compartment beneath the floor
covering.
To remove: 1. Open the floor cover.

Vehicle care261
2.The spare wheel is secured with a
wing nut. Turn wing nut
anticlockwise and remove the
spare wheel.
Under the spare wheel there is the box with vehicle tools.
3. When, after a wheel change, no wheel is placed in the spare wheel
well, secure the tool box by
turning right back the wing nut and close the floor cover.
Stowing the replaced full size wheel in the spare wheel well
The spare wheel well is not designed for all permitted tyre sizes. If a wheel
wider than the spare must be stowed
in the spare wheel well, the thread
bolt for mounting the wheel must be
replaced by an extension bolt, located
in the tool box 3 248. To replace the
bolt:
■ Remove tool box from the spare wheel well.
■Install the hexagon key of the wheel
wrench ensuring that it locates
securely on the bolt.
■ Turn the wheel wrench anticlockwise to loosen the bolt.
Remove the bolt.
■ Take the extension bolt from the tool box 3 248 and screw it in hand-
tight using the hexagon key of the
wheel wrench.■ Store the tool box and the damaged
wheel outside up in the spare wheel
well and secure it by turning the
wing nut clockwise on the bolt.
The floor cover can be placed on the
projecting wheel.
To fit the spare wheel in the well after
renewing the defective wheel use the
short thread bolt again. Exchange the
bolt in the same way.

262Vehicle care9Warning
Storing a jack, a wheel or other
equipment in the load
compartment could cause injury if they are not fixed properly. During a sudden stop or a collision, looseequipment could strike someone.
Store wheel, jack and tools always
in the original storage location and secure them by fixing.
Temporary spare wheel
Caution
The use of a spare wheel that issmaller than the other wheels or in
combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
Only mount one temporary spare
wheel. Do not drive faster than
50 mph. Take curves slowly. Do not
use for a long period of time.
If your vehicle gets a flat tyre on the
rear while towing another vehicle,
mount the temporary spare wheel in
the front and the full tyre in the rear.
Tyre chains 3 254.
Directional tyres Fit directional tyres such that they roll
in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Drive particularly carefully on wet and snow-covered road surfaces.Jump starting
Do not start with quick charger.
A vehicle with a discharged vehicle
battery can be started using jump
leads and the vehicle battery of
another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.

Technical data303
Comfort with up to
3 peopleECO with up to
3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])A20DTR with Sport
chassis and Brembo
brake 18''245/40 R19230/2.3
(33)220/2.2
(32)270/2.7
(39)290/2.9
(42)260/2.6
(38)300/3.0
(43)235/45 R18,250/2.5
(36)250/2.5
(36)270/2.7
(39)290/2.9
(42)260/2.6
(38)320/3.2
(46)245/35 R20AllTemporary spare wheel420/4.2
(61)420/4.2
(61)––420/4.2
(61)420/4.2
(61)11) Only permitted as winter tyres.

Technical data309
Comfort with up to
3 peopleECO with up to
3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])225/45 R18 M+S 11)260/2.6
(38)280/2.8
(41)270/2.7
(39)290/2.9
(42)260/2.6
(38)320/3.2
(46)A20DTR with Sport
chassis and Brembo
brake 18''245/40R19230/2.3
(33)220/2.2
(32)270/2.7
(39)290/2.9
(42)260/2.6
(38)300/3.0
(43)235/45R18,250/2.5
(36)250/2.5
(36)270/2.7
(39)290/2.9
(42)260/2.6
(38)320/3.2
(46)245/35R20AllTemporary spare wheel420/4.2
(61)420/4.2
(61)––420/4.2
(61)420/4.2
(61)11) Only permitted as winter tyres.

Technical data311
Comfort with up to
3 peopleECO with up to 3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])A20DTH,
B20DTH215/55 R17 M+S 11)
,230/2.3 (33)250/2.5 (36)270/2.7 (39)290/2.9 (42)230/2.3
(33)300/3.0
(43)225/55 R17,225/50 R17 M+S 11)
,235/45 R18,245/45 R18,245/40 R19,245/35 R20225/50 R17230/2.3 (33)250/2.5 (36)300/3.0 (43)300/3.0 (43)230/2.3
(33)300/3.0
(43)225/45 R18 M+S 11)250/2.5 (36)270/2.7 (39)270/2.7 (39)290/2.9 (42)250/2.5
(36)320/3.2
(46)AllTemporary spare wheel420/4.2 (61)420/4.2 (61)––420/4.2
(61)420/4.2
(61)11) Only permitted as winter tyres.

316Technical dataComfort with up to 3 peopleECO with up to
3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar] ([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])A20DTR with
Sport chassis
and Brembo
brake 18''245/40R19230/2.3 (33)220/2.2
(32)270/2.7
(39)290/2.9
(42)260/2.6
(38)300/3.0
(43)235/45R18,250/2.5 (36)250/2.5
(36)270/2.7
(39)290/2.9
(42)260/2.6
(38)320/3.2
(46)245/35R20A28 NER235/45 R18,270/2.7 (39)250/2.5
(36)310/3.1
(45)300/3.0
(43)280/2.8
(41)300/3.0
(43)245/40 R19255/35 R20AllTemporary spare wheel420/4.2 (61)420/4.2
(61)––420/4.2
(61)420/4.2
(61)11) Only permitted as winter tyres.

318Technical data
Comfort with up to
3 peopleECO with up to
3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])B20NHT,
A20DTH,
B20DTH,
A20DTR
with Sport chassis and
Brembo brake 18''245/40R19230/2.3
(33)220/2.2
(32)270/2.7
(39)290/2.9
(42)260/2.6
(38)300/3.0
(43)235/45R18,250/2.5
(36)250/2.5
(36)270/2.7
(39)290/2.9
(42)260/2.6
(38)320/3.2
(46)245/35R20A28 NER235/45 R18,260/2.6
(38)230/2.3
(33)300/3.0
(43)320/3.2
(46)270/2.7
(39)320/3.2
(46)245/40 R19,255/35 R20AllTemporary spare
wheel420/4.2
(61)420/4.2
(61)––420/4.2
(61)420/4.2
(61)11) Only permitted as winter tyres.