2015.5 VAUXHALL CASCADA parking brake

202Vehicle care
No.Circuit17Transmission control module18Heated rear window19Front power windows20Rear power windows21Rear eletrical centre22Left high beam (Halogen)23Headlamp washer system24Right low beam (Xenon)25Left low beam (Xenon)26Front fog lights27Diesel fuel heating28Start stop system29Electric parking brake30ABS pump31–32AirbagNo.Circuit33Adaptive forward lighting, auto‐
matic light control34Exhaust gas recirculation35Power windows, rain sensor,
exterior mirror36Climate control37–38Vacuum pump39Fuel system control module40Windscreen washer system41Right high beam (Halogen)42Radiator fan43Windscreen wiper44–45Radiator fan46–47HornNo.Circuit48Radiator fan49Fuel pump50Headlamp levelling, adaptive
forward lighting51–52Auxiliary heater, diesel engine53Transmission control module,
Engine control module54Vacuum pump, instrument
panel cluster, heating ventila‐
tion, air conditioning system
After having changed defective fuses,
close the fuse box cover and press
until it engages.
If the fuse box cover is not closed
correctly, malfunctions may occur.

204Vehicle care
No.Circuit16Boot lid relay17Air conditioning system18Service diagnose19Body control module, brake
lights, tail lights, interior lights20-21Instrument panel22Ignition system23Body control module24Body control module25–26Trunk power outlet accessory
Load compartment fuse
box
The fuse box is on the left side of the
load compartment behind a cover.
Remove the cover.
Fuse assignments
No.Circuit1Soft top control module, power
rail right2–3Parking assist4Selective catalytic reduction
system5–6–7Power seat8Soft top control module9Selective catalytic reduction
system10Selective catalytic reduction
system11Trailer module, tyre pressure
monitor and rear view camera12Soft top control module, tail
lights13–

210Vehicle care
Each time the tyres are replaced, tyrepressure monitoring system sensors
must be dismounted and serviced. For the screwed sensor: replace
valve core and sealing ring. For
clipped sensor: replace complete
valve stem.
Vehicle loading status Adjust tyre pressure to load condition according to tyre information label or
tyre pressure chart 3 242, and select
the relevant setting in the menu Tire
Load in the DIC, Vehicle Information
Menu 3 95.Select:
■ Light for comfort pressure up to
3 people
■ Eco for Eco pressure up to
3 people
■ Max for full loading
TPMS sensor matching process
Each TPMS sensor has a unique
identification code. The identification
code must be matched to a new tyre/
wheel position after rotating the tyres
or exchanging the complete wheel set and if one or more TPMS sensors
were replaced. The TPMS sensor
matching process should also be
performed after replacing a spare tyre
with a road tyre containing the TPMS
sensor.
The malfunction light and the warning
message or code should go off at the next ignition cycle. The sensors are
matched to the tyre/wheel positions,
using a TPMS relearn tool, in the
following order: left side front tyre,
right side front tyre, right side rear tyreand left side rear tyre. The turn signal
light at the current active position is
illuminated until sensor is matched.
Consult your workshop for service or
to purchase a relearn tool. There are
2 minutes to match the first tyre/wheel position, and 5 minutes overall to
match all four tyre/wheel positions. If
it takes longer, the matching process
stops and must be restarted.
The TPMS sensor matching process
is:
1. Apply the parking brake; on vehicles with automatic
transmission set the selector lever to P.
2. Turn the ignition on.
3. Use the MENU button on the turn
signal lever to select the Vehicle
Information Menu in the DIC.
4. Turn the adjuster wheel to scroll to
the tyre pressure menu.
5. Press the SET/CLR button to
begin the sensor matching process. A message requesting
acceptance of the process should
display.

Vehicle care213Tyre repair kit
Minor damage to the tyre tread can be
repaired with the tyre repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding 4 mm or that is at tyre's sidewall cannot be repairedwith the tyre repair kit.9 Warning
Do not drive faster than 50 mph.
Do not use for a lengthy period.
Steering and handling may be
affected.
If you have a flat tyre:
Apply the parking brake and engage
first gear, reverse gear or P.
The tyre repair kit is in a box under the
floor cover in the load compartment.
On another version, a bag with the
tyre repair kit is fixed at the left rear
lashing eye in the load compartment.
1. Take the tyre repair kit from the load compartment.
2. Remove the compressor.
3. Remove the electrical connection cable and air hose from the
stowage compartments on the
underside of the compressor.

216Vehicle care
Notice
The driving characteristics of the repaired tyre are severely affected,therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
The built-in safety valve opens at a
pressure of 102 psi.
Note the expiry date of the kit. After
this date its sealing capability is no
longer guaranteed. Pay attention to
storage information on sealant
bottle.
Replace the used sealant bottle. Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be used from approx. -30 °C.
The adapters supplied can be used
to pump up other items e.g.
footballs, air mattresses, inflatable
dinghies etc. They are located on the underside of the compressor. To
remove, screw on compressor air hose and withdraw adapter.Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel
3 213.
Make the following preparations and
observe the following information:
■ Park the vehicle on a level, firm and
non-slippery surface. The frontwheels must be in the straight-ahead position.
■ Apply the parking brake and engage first gear, reverse gear or
P .
■ Remove the spare wheel 3 218.
■ Never change more than one wheel
at once.
■ Use the jack only to change wheels
in case of puncture, not for
seasonal winter or summer tyre
change.
■ The jack is maintenance-free.
■ If the ground on which the vehicle is standing is soft, a solid board
(max. 1 cm thick) should be placed
under the jack.■ Take heavy objects out of the vehicle before jacking up.
■ No people or animals may be in the
vehicle when it is jacked-up.
■ Never crawl under a jacked-up vehicle.
■ Do not start the vehicle when it is raised on the jack.
■ Clean wheel nuts and thread with a
clean cloth before mounting the
wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Disengage wheel nut caps with a screwdriver and remove. Pull off
the wheel cover. Vehicle tools
3 205.
Alloy wheels: Disengage wheel
nut caps with a screwdriver and
remove. To protect the wheel,
place a soft cloth between the
screwdriver and the alloy wheel.

222Vehicle care
■ Never expose the battery to nakedflames or sparks.
■ A discharged vehicle battery can already freeze at a temperature of
0 °C. Defrost the frozen battery
before connecting jump leads.
■ Wear eye protection and protective
clothing when handling a battery.
■ Use a booster battery with the same voltage (12 Volts). Its
capacity (Ah) must not be much less than that of the discharged
battery.
■ Use jump leads with insulated terminals and a cross section of at
least 16 mm 2
(25 mm 2
for diesel
engines).
■ Do not disconnect the discharged battery from the vehicle.
■ Switch off all unnecessary electrical
consumers.
■ Do not lean over the battery during jump starting.
■ Do not allow the terminals of one lead to touch those of the other
lead.■ The vehicles must not come into contact with each other during the
jump starting process.
■ Apply the parking brake, transmission in neutral, automatictransmission in P.
■ Open the positive terminal protection caps of both batteries.
Lead connection order:
1. Connect the red lead to the positive terminal of the booster
battery.
2. Connect the other end of the red lead to the positive terminal of the
discharged battery.
3. Connect the black lead to the negative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as far away from the discharged
battery as possible, however at
least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.

249
Climate control systems.............122
Clock............................................. 81
Code ........................................... 102
Control indicators.......................... 87
Control of the vehicle .................132
Controls ........................................ 77
Convex shape .............................. 29
Coolant and antifreeze ...............229
Cruise control ...................... 94, 153
Cupholders .................................. 70
Curve lighting.............................. 113
D
Danger, Warnings and Cautions ...3
Daytime running lights ...............113
Declaration of conformity ............244
DEF ............................................ 140
Diesel exhaust fluid ....................140
Diesel fuel system bleeding .......191
Diesel particle filter ...............92, 138
Door open .................................... 95
Doors ............................................ 25
Driver assistance systems ..........153
Driver Information Centre .............95
Driving characteristics and towing tips .............................. 179
Driving hints ................................ 132E
Electric adjustment ......................29
Electrical system......................... 200
Electric parking brake ...........91, 147
Electric parking brake fault ...........91
Electronic climate control system 125
Electronic driving programmes ..144
Electronic Stability Control.......... 150
Electronic Stability Control and Traction Control system ............92
Electronic Stability Control off....... 92 End-of-life vehicle recovery .......185
Engine compartment fuse box ...201
Engine coolant ........................... 188
Engine coolant temperature gauge ....................................... 86
Engine data ............................... 236
Engine exhaust .......................... 138
Engine identification ...................232
Engine oil ................... 186, 229, 233
Engine oil pressure ......................93
Entry lighting .............................. 119
Event data recorders ..................246
Exit lighting ................................ 120
Exterior care .............................. 225
Exterior light ................................. 94
Exterior lighting ....................13, 109
Exterior mirrors ............................. 29F
Fault ........................................... 145
First aid ......................................... 75
First aid kit ................................... 75
Fixed air vents ........................... 130
Fog light ....................................... 94
Fog lights ................................... 195
Folding mirrors ............................. 30
Following distance indication ......158
Forward collision alert................. 156
Front airbag system .....................60
Front fog lights ........................... 117
Front seats.................................... 47
Front storage ................................ 70
Front turn signal lights ...............195
Fuel............................................. 175
Fuel consumption - CO 2-
Emissions ............................... 177
Fuel for diesel engines ..............175
Fuel for petrol engines ...............175
Fuel gauge ................................... 86
Fuses ......................................... 200
G Gauges ......................................... 84
General information ...................178
Glovebox ..................................... 69

250
Graphic-Info-Display, Colour-Info-Display ............................ 100
Ground clearance .......................133
H Halogen headlights ....................192
Hand brake ......................... 146, 147
Hazard warning flashers ............116
Headlight flash ........................... 111
Headlight range adjustment ......112
Headlights................................... 109
Headlights when driving abroad 112
Head restraint adjustment .............8
Head restraints ............................ 45
Heated mirrors ............................. 30
Heated rear window ..................... 34
Heated steering wheel .................78
Heating ........................................ 53
Heating and ventilation system . 122
High beam ........................... 94, 110
High beam assist ..................94, 111
Hill start assist ........................... 149
Horn ....................................... 15, 78
I
Identification plate .....................231
Ignition switch positions .............133
Immobiliser ............................ 29, 94
Indicators ...................................... 84
Information displays...................... 95Instrument cluster ........................84
Instrument panel fuse box .........203
Instrument panel illumination .....199
Instrument panel illumination control .................................... 118
Instrument panel overview ........... 11
Interactive driving system ...........151
Interior care ............................... 227
Interior lighting ............................ 118
Interior lights ...................... 118, 199
Interior mirrors .............................. 31
Interruption of power supply ......145
Introduction .................................... 3
ISOFIX child restraint systems ....68
J
Jump starting ............................. 221
K
Key, memorised settings ..............22
Keys ............................................. 20
Keys, locks ................................... 20
L
Lane departure warning .......92, 173
Lashing eyes ............................... 75
Light switch ................................ 109
Load compartment ................25, 72
Load compartment fuse box ......204Loading information .....................76
Low fuel ....................................... 94
M
Malfunction indicator light ............90
Manual anti-dazzle ......................31
Manual mode ............................. 144
Manual transmission .................. 146
Memorised settings ......................22
Mirror adjustment ........................... 9
Misted light covers .....................118
N
New vehicle running-in ..............133
Number plate light .....................199
O Object detection systems ...........159
Odometer ..................................... 85
Oil, engine .......................... 229, 233
Operate pedal ............................... 90
Outside temperature ....................81
Overrun cut-off ........................... 135
P
Parking ................................ 19, 137
Parking assist ............................ 159
Parking brake ............................ 147
Parking lights ............................. 117
Particulate filter ........................... 138