2014 VAUXHALL ZAFIRA TOURER fuel filter

Instruments and controls123
No.Vehicle message54Water in diesel fuel filter55Diesel particle filter is full
3 16356Tyre pressure imbalance on
front axle57Tyre pressure imbalance on
rear axle58Tyres without TPMS sensors
detected59Open and then close driver
window60Open and then close front
passenger window61Open and then close rear left
window62Open and then close rear right
window65Theft attempted66Service theft alarm system67Service steering wheel lockNo.Vehicle message68Service power steering69Service suspension system70Service level control system71Service rear axle74Service AFL75Service air conditioning76Service side blind zone alert
system77Service lane departure warning79Top up engine oil81Service transmission82Change engine oil soon83Service adaptive cruise control84Engine power is reduced89Service vehicle soon94Shift to park before exiting95Service airbagNo.Vehicle message128Bonnet open134Park assist fault, clean bumper136Service parking assist145Check washer fluid level174Low vehicle battery258Park assist off
Vehicle messages on the
Uplevel-Display or Uplevel- Combi-Display

Instruments and controls125
■ If an unintended lane changeoccurs.
■ If reverse gear is engaged and the rear end carrier is extended.
■ If the diesel particle filter has reached the maximum filling level.
■ If AdBlue needs to be refilled.
When the vehicle is parked and/ or the driver's door is opened ■ When the key is in the ignition switch.
■ With exterior lights on.
During an Autostop ■ If the driver's door is opened.
Battery voltage
When the vehicle battery voltage is
running low, a warning message or
warning code 174 will appear in the
Driver Information Centre.1. Switch off immediately any electrical consumers which are
not required for a safe ride, e.g.
seat heating, heated rear window
or other main consumers.
2. Charge the vehicle battery by driving continuously for a while or
by using a charging device.
The warning message or warning
code will disappear after the engine
has been started two times
consecutively without a voltage drop.
If the vehicle battery cannot be
recharged, have the cause of the fault
remedied by a workshop.Trip computer
The menus and functions can be
selected via the buttons on the turn
signal lever.
Press the MENU button to select the
Trip/Fuel Information Menu , or select
W on the Uplevel-Combi-Display.

158Driving and operatingStarting and operating
New vehicle running-in Do not brake unnecessarily hard for
the first few journeys.
During the first drive, smoke may
occur because of wax and oil
evaporating off the exhaust system.
Park the vehicle in the open for a
while after the first drive and avoid
inhaling the fumes.
During the running-in period, fuel and
engine oil consumption may be
higher and the cleaning process of
the diesel particle filter may take
place more often. Autostop may be
inhibited to allow for charging of the vehicle battery.
Diesel particle filter 3 163.Ignition switch positions0=Ignition off1=Steering wheel lock released,
ignition off2=Ignition on, for diesel engine:
preheating3=Starting
Retained power off
The following electronic systems can
work until the driver's door is opened
or at the latest for 10 minutes after the
ignition is switched off:
■ Power windows
■ Power outlets
Power to the Infotainment system will continue to operate for 30 minutes oruntil the key is removed from the
ignition switch, regardless of whether
any door will be opened.
Starting the engine
Manual transmission: operate clutch.
Automatic transmission: operate
brake and move the selector lever to
P or N.
Do not operate the accelerator pedal.

Driving and operating163Engine exhaust9Danger
Engine exhaust gases contain
poisonous carbon monoxide,
which is colourless and odourless and could be fatal if inhaled.
If exhaust gases enter the interior
of the vehicle, open the windows.
Have the cause of the fault
rectified by a workshop.
Avoid driving with an open load
compartment, otherwise exhaust
gases could enter the vehicle.
Diesel particle filter
The diesel particle filter system filters
harmful soot particles out of the
exhaust gases. The system includes
a self-cleaning function that runs
automatically during driving without
any notification. The filter is cleaned
by periodically burning off the soot
particles at high temperature. This
process takes place automatically
under set driving conditions and may
take up to 25 minutes. Typically it
needs between 7 and 12 minutes. Autostop is not available and fuel
consumption may be higher during
this period. The emission of smells
and smoke during this process is
normal.
Under certain driving conditions, e.g.
short distances, the system cannot
clean itself automatically.
If the cleaning of the filter is required
and if previous driving conditions did
not enable automatic cleaning, it will
be indicated by control indicator %.
Simultaneously Diesel partic. filter is
full continue driving or warning
code 55 appears in the Driver
Information Centre.
% illuminates when diesel particle
filter is full. Start cleaning process as
soon as possible.
% flashes when diesel particle filter
has reached the maximum filling
level. Start cleaning process
immediately to avoid damage to the
engine.
Cleaning process
To activate cleaning process,
continue driving, keep engine speed
above 2000 revolutions per minute.
Shift down if necessary. Diesel
particle filter cleaning is then started.
If g illuminates additionally,
cleaning is not possible, seek the
assistance of a workshop.Caution
If the cleaning process is
interrupted, there is a risk of
provoking severe engine damage.

282Technical dataCapacitiesEngine oilEngineA14NELA14NET,
A14NET LPGA16XNT CNGA16XHTA18XEL,
A18XERincluding Filter [l]4.04.04.55.54.5between MIN and MAX [l]1.01.01.01.01.0EngineB16DTHA20DTLA20DTA20DTHA20DTRincluding Filter [l]5.04.54.54.54.5between MIN and MAX [l]1.01.01.01.01.0
Fuel tank
Petrol/diesel, refilling quantity [l]58Natural gas CNG, refilling quantity [kg] or [l]
Petrol, refilling quantity25 kg 4)
or 144 l
14Liquid gas LPG, refilling quantity [l]664) At 20 MPa/200 bar/2900 psi and 15°C.

291
Child restraint installationlocations ................................... 59
Child restraints.............................. 57
Child restraint systems ................57
Cigarette lighter .........................101
Climate control ............................. 15
Climate control systems .............148
Clock............................................. 99
Code ........................................... 121
Control indicators........................ 105
Control of the vehicle .................157
Controls ........................................ 94
Convex shape .............................. 28
Coolant and antifreeze ...............267
Cruise control ....................114, 177
Cupholders .................................. 64
Curtain airbag system .................. 55
Curve lighting.............................. 139
D Danger, Warnings and Cautions ...4
Daytime running lights ...............139
Declaration of conformity ............287
DEF ............................................ 164
Diesel exhaust fluid ....................164
Diesel fuel system bleeding .......228
Diesel particle filter .............112, 163
Door open .................................. 115
Door panel storage .......................65
Doors ............................................ 24Driver assistance systems..........177
Driver Information Centre ...........115
Driving characteristics and towing tips .............................. 216
Driving hints ................................ 157
E Electric adjustment ......................28
Electrical system......................... 238
Electric parking brake .................110
Electric parking brake fault .........110
Electronic climate control system 150
Electronic driving programmes ..169
Electronic Stability Control.......... 175
Electronic Stability Control and Traction Control system ..........112
Electronic Stability Control off..... 112
End-of-life vehicle recovery .......222
Engine compartment fuse box ...239
Engine coolant ........................... 225
Engine coolant temperature gauge ..................................... 104
Engine data ............................... 274
Engine exhaust .......................... 163
Engine identification ...................270
Engine oil ................... 223, 267, 271
Engine oil pressure ....................113
Entry lighting .............................. 146
Event data recorders ..................287
Exit lighting ................................ 146Exterior care .............................. 262
Exterior light ............................... 114
Exterior lighting ....................12, 136
Exterior mirrors ............................. 28
F
Fault ........................................... 169
First aid kit ................................... 90
Fixed air vents ........................... 155
Flex-Fix system ............................ 68
Fog light ..................................... 114
Fog lights ................................... 233
Folding mirrors ............................. 28
Folding tray .................................. 90
Following distance indication ......190
Forward collision alert................. 187
Front airbag system .....................53
Front fog lights ........................... 143
Front seats.................................... 37
Front storage ................................ 65
Fuel............................................. 207
Fuel consumption - CO 2-
Emissions ............................... 215
Fuel for diesel engines ..............207
Fuel for liquid gas operation .......208
Fuel for natural gas operation ...207
Fuel for petrol engines ...............207
Fuel gauge ................................. 103
Fuel selector .............................. 103
Fuses ......................................... 238

293
Oil, engine.................. 223, 267, 271
Outside temperature ....................98
Overhead console .......................65
Overrun cut-off ........................... 159
P Parking ................................ 18, 162
Parking assist ............................ 192
Parking brake ............................ 172
Parking lights ............................. 144
Particulate filter ........................... 163
Performance .............................. 277
Performing work ........................222
Pollen filter ................................. 155
Power outlets ............................. 100
Power seat adjustment ................40
Power steering............................ 111
Power windows ............................ 30
Preheating ................................. 112
Puncture ..................................... 253
Q
Quickheat ................................... 154
R Radio Frequency Identification (RFID) ..................................... 288
Radio remote control ...................20
Reading lights ............................ 146
Rear carrier system ......................68Rear floor storage cover ..............81
Rear fog light ............................. 114
Rear fog lights ........................... 144
Rear seats .................................... 43
Rear storage ................................. 79
Rear view camera ...................... 200
Rear window wiper/washer .......... 98
Recommended fluids and lubricants ........................ 267, 271
Reduced engine power ..............114
Refuelling ................................... 210 Retained power off .....................158
Reversing lights .........................144
Ride control system ....................174
Roller blinds ................................. 32
Roof .............................................. 33
Roof load ...................................... 92
Roof rack ..................................... 91
S Safety net .................................... 88
Seat adjustment ....................... 6, 37 Seat belt ........................................ 8
Seat belt reminder .....................108
Seat belts ..................................... 49
Seat position ................................ 37
Second row seats ........................43
Selective catalytic reduction .......164
Selector lever ............................. 167
Service ............................... 156, 266Service display .......................... 105
Service information ....................266
Service vehicle soon .................. 110
Side airbag system ......................54
Side blind spot alert ....................199
Sidelights .................................... 136
Side turn signal lights ................236
Spare wheel ............................... 255
Speed limiter............................... 179
Speedometer ............................. 102
Starting and operating ................158
Starting off ................................... 17
Starting the engine ....................158
Steering ...................................... 157
Steering wheel adjustment ......9, 94
Steering wheel controls ...............94
Stop-start system........................ 160
Storage compartment ...................63
Storage compartments .................63
Sunvisor lights ........................... 146
Sun visors .................................... 32
Symbols ......................................... 4
T Tachometer ............................... 103
Tail lights ................................... 234
Third row seats ............................ 47
Three-point seat belt .................... 50
Tools .......................................... 244
Top-tether fastening eyes ............62