2014 TOYOTA HIGHLANDER HYBRID fuel
[x] Cancel search: fuelPage 9 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:7SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
THE NEW WORLD OF
ANTI-THEFT TECHNOLOGY
ThisToyota vehicle maybeequipped with
an electronic “immobilizer” anti-theft
system. Whenthekey isinserted intothe
ignition switchittransmits anelectronic
code toan immobilizer computer.The
engine willonly start ifthe code inthe key
matches thecode inthe immobilizer. Ifthe
code doesnotmatch, theimmobilizer
disables theignition andfuelsystems.
While anexact physical copyofthe key
will open thedoor andallow retrieval of
items locked inthe vehicle, itwon’t start
the vehicle unlessthekey has thesame
code asthe immobilizer.
SECURITY
For security purposes, accesstokey
codes andservice procedures for
electronically registeringreplacement keys
is restricted. OnlyaToyota dealeror
certain bonded/registered independent
locksmiths cangenerate replacement keys.
TheImmobilizer Key
INTRODUCTION
Introduction7
Page 15 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:13SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
WHAT ISCOVERED AND
HOW LONG
Basic Warranty
Thiswarranty coversrepairs and
adjustments neededtocorrect defects in
materials orworkmanship ofany part
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 36months or
36,000 miles,whichever occursfirst,with
the exception ofwheel alignment and
wheel balancing, whicharecovered for
12 months or12,000 miles,whichever
occurs first.
Hybrid System Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofthe components listed
here andsupplied byToyota, subjectto
the exceptions indicatedunder“What Is
Not Covered” onpages 14-15.
•Battery controlmodule (battery
voltage sensor)
• Hybrid battery
• Hybrid control module (power
management controlmodule)
• Inverter withconverter
Coverage isfor 96months or
100,000 miles,whichever occursfirst.
Powertrain Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofany component listed
below andinthe next column and
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 60months or
60,000 miles,whichever occursfirst.
Engine
Cylinder blockandhead andallinternal
parts, timing gearsandgaskets, timing
chain/belt andcover, valvecovers, oilpan,
oil pump, engine mounts, enginecontrol
computer, waterpump, fuelpump, seals
and gaskets.
Transaxle/Motor/Generator
Case andallinternal parts,transaxle
mounts, sealsandgaskets.
Front-Wheel-Drive System
Final drive housing andallinternal parts,
axle shafts, driveshafts, constant velocity
joints, fronthubandbearings, sealsand
gaskets.
New Vehicle Limited Warranty
WARRANTY
YourWarranties inDetail13
Page 20 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:18SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
WHAT ISNOT COVERED
These warranty obligations donot apply to
failures ornoncompliance causedby:
•The useofreplacement partsnot
certified inaccordance with
aftermarket partscertification
regulations.
• The useofreplacement partsnot
equivalent inquality ordesign to
original equipment parts.
Provisionsunderthe“What IsNot
Covered” sectionofthe New Vehicle
Limited Warranty alsoapply tothis
warranty.
WARRANTY PARTSLIST
Air/Fuel Metering System
•Air/fuel ratiofeedback controlsystem
• Electronic fuelinjection system
components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
AirInduction System
•Intake manifold andintake airsurge
tank
Catalyst System
•Catalytic converter andprotector
(8/80)
• Constricted fuelfiller neck
• Exhaust manifold
• Exhaust pipe(manifold tocatalyst
and/or catalyst tocatalyst)
Evaporative ControlSystem
•Charcoal canister
• Diaphragm valve
• Fuel filler cap
• Fuel tank
8/80 =Covered foreight years or80,000 miles,whichever occursfirst.
Federal Emission ControlWarranty
WARRANTY
18YourWarranties inDetail
Page 25 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:23SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Vehicles equipped withaCalifornia
Certified Emission ControlSystem that
are sold, registered andoperated in
California orany state thatadopts
California emissionwarrantyprovisions
are covered bythis warranty. Currently,
Connecticut, Delaware,Maine,
Maryland, Massachusetts, NewJersey,
Oregon, Pennsylvania, RhodeIsland,
Vermont andWashington arethe other
states towhich thiswarranty applies.
Vehicles coveredbythis warranty are
also covered bythe Federal Emission
Control Warranty (seepage 17).
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
TheCalifornia AirResources Board(CARB)
and Toyota arepleased toexplain the
emission controlsystem warranty foryour
2014 vehicle. InCalifornia, newmotor
vehicles mustbedesigned, builtand
equipped tomeet thestate’s stringent
anti-smog standards. CARBregulations
require thatToyota mustwarrant the
emission controlsystem onyour vehicle
for the time periods indicated onthe next
page, provided therehasbeen noabuse,
neglect orimproper maintenance ofyour
vehicle.
Your emission controlsystem mayinclude
parts suchasthe fuel injection system,
ignition system, catalytic converter and
engine computer. Alsoincluded maybe
hoses, belts,connectors andother
emissions-related assemblies.
Where awarrantable conditionexists,
Toyota willrepair yourvehicle atno cost
to you, including diagnosis, partsand
labor.
California EmissionControlWarranty
WARRANTY
YourWarranties inDetail23
Page 27 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:25SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
WHAT ISNOT COVERED
These warranty obligations donot apply to
failures ornoncompliance causedby:
•The useofreplacement partsnot
certified inaccordance with
aftermarket partscertification
regulations.
• The useofreplacement partsnot
equivalent inquality ordesign to
original equipment parts.
Provisionsunderthe“What IsNot
Covered” sectionofthe New Vehicle
Limited Warranty alsoapply tothis
warranty.
PARTS LIST:LONG-TERM
EMISSION DEFECT
WARRANTY
The parts listed herearecovered forseven
years or70,000 milesfromthevehicle’s
in-service date,whichever occursfirst.
Air/Fuel Metering System
•Air fuel ratio sensor
• Engine control computer (engine
control module)
• Fuel delivery pipe
• Fuel pressure regulator
• Fuel pump
• Injector
• Throttle body
AirInduction System
•Intake manifold andintake airsurge
tank
Catalyst System
•Exhaust centerpipe(including
catalytic converter)
• Exhaust manifold (including manifold
converter)
EGR System
•EGR cooler
Evaporative ControlSystem
•Charcoal canister
• Fuel tank
• Fuel tank solenoid mainvalve
California EmissionControlWarranty
WARRANTY
YourWarranties inDetail25
Page 43 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:41SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
30,000 milesor36 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive shaftboots
__ Engine/Inverter coolant4
__Exhaust pipesandmountings
__ Front differential oil __
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading5: Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
5Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog41
Page 47 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:45SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
60,000 milesor72 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts4
__Drive shaftboots
__ Engine/Inverter coolant5
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6: Replace automatic transmission fluid Replacefrontdifferential oil Replacereardifferential oil Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Initial inspection at60,000 miles/72 months.Inspectevery15,000 miles/18 monthsthereafter.5Referto“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
6Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog45
Page 51 of 66
JOBNAME:1491132-2014-hhvWG-E PAGE:49SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
90,000 milesor108 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
4
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading5: Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
5Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog49