2014 Ram 5500 Chassis Cab check engine

CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
Check the fluid level when the engine is fully warmed up
and the transmission fluid is at normal operating tem-
perature. Driving with an improper fluid level will
greatly reduce the life of the transmission and of the
fluid. Check the fluid level whenever the vehicle is
serviced.
Fluid Level Check — Procedure
It is best to check the fluid level when the transmission is
at normal operating temperature (170-180°F / 77-82°C for
66RFE transmission, or 158–176°F / 70–80°C for AS66RCtransmission). This normally occurs after at least 15 miles
(25 km) of driving. At normal operating temperature the
fluid cannot be held comfortably between the fingertips.
You can read the transmission sump temperature in the
EVIC display (see Electronic Vehicle Information Center
[EVIC] for further information).
Use the following procedure to check the transmission
fluid level properly:
1. Monitor the transmission temperature using the EVIC
display, and operate the vehicle as required to reach
the normal operating temperature.
2. Park the vehicle on level ground.
3. Run the engine at normal idle speed for at least 60 seconds, and leave the engine running for the rest of
this procedure.
4. Fully apply the parking brake and press the brake.
7
MAINTAINING YOUR VEHICLE 475

CAUTION!
If the fluid temperature is below 50°F (10°C) it may
not register on the dipstick. Do not add fluid until
the temperature is elevated enough to produce an
accurate reading. Run the engine at idle, in PARK, to
warm the fluid.
9. Check for leaks. Release the parking brake.
NOTE: To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
sure that the dipstick cap is properly reseated. It is
normal for the dipstick cap to spring back slightly from
its fully seated position, as long as its seal remains
engaged in the dipstick tube.
Fluid And Filter Changes — Six-Speed
Transmission
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter(s) if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Appearance Care And Protection From Corrosion
Protection Of Body And Paint From Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice, and chemicals that are sprayed
on trees and road surfaces during other seasons, are
highly corrosive to the metal in your vehicle. Outside
parking, which exposes your vehicle to airborne contami-
nants, road surfaces on which the vehicle is operated,
7
MAINTAINING YOUR VEHICLE 477

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that ser-
vice is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extremely hot or
cold ambient temperatures, and E85 fuel usage will
influence when the “Oil Change Required” message is
displayed. Severe Operating Conditions can cause the
change oil message to illuminate as early as 3,500 miles
(5,600 km) since last reset. Have your vehicle serviced as
soon as possible, within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone otherthan your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)” in “Understanding Your
Instrument Panel” for further information.
NOTE:
•
Gasoline Engines
• Under no circumstances should oil change intervals
exceed 8,000 miles (13,000 km) or twelve months,
whichever comes first.
• Severe Duty
• Change Engine Oil at 4000 miles (6,500 km) if the
vehicle is operated in a dusty and off road environ-
ment. This type of vehicle use is considered Severe
Duty
Once A Month Or Before A Long Trip:
• Check engine oil level
8
M
A I
N T
E
N
A
N
C E
S
C
H E
D
U L
E
S508 MAINTENANCE SCHEDULES

•Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission as needed
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting.
8
M
A I
N T
E
N
A
N
C E
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 509

Adding Engine Coolant (Antifreeze)............463
Adding Fuel ............................ .385
Additives, Fuel .......................... .383
Adjustable Pedals ........................ .166
Airbag ..................................64
Airbag Deployment ........................70
Airbag Light .............................68
Airbag Maintenance ........................71
Airbag, Side ..............................67
Airbag, Window (Side Curtain) ................67
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .454
Air Conditioner Maintenance .................456
Air Conditioning ......................... .269
Air Conditioning Controls ...................269
Air Conditioning, Operating Tips ..............288
Air Conditioning Refrigerant .................456
Air Conditioning System ....................269
Air Pressure, Tires ........................ .357
Alarm Light ............................ .205Alarm, Panic
.............................27
Alarm (Security Alarm) ......................21
Alarm System (Security Alarm) ................21
Alterations/Modifications, Vehicle ...............7
Antifreeze (Engine Coolant) ..................462
Capacities ........................... .503
Disposal ............................. .466
Anti-Lock Brake System (ABS) ................333
Anti-Lock Warning Light ....................200
Appearance Care ........................ .477
Ashtray ............................... .180
Auto Down Power Windows ..................45
Automatic Door Locks ......................37
Automatic Headlights ..................... .151
Automatic High Beams .....................153
Automatic Transmission ....................474
Adding Fluid ......................... .476
Fluid and Filter Changes ..................477
Fluid Level Check ...................... .475
526 INDEX

Fluid Type........................... .474
Shifting ............................. .300
Special Additives ...................... .474
Axle Fluid ............................. .471
Axle Lubrication (Axle Fluid) .................471
Battery ................................ .455
Keyless Transmitter Replacement (RKE) ........28
Belts, Seat ...............................50
Body Builders Guide ........................6
Body Mechanism Lubrication .................457
B-Pillar Location ......................... .351
Brake Control System, Electronic ..............333
Brake Fluid ............................ .469
Brake System ........................... .330
Anti-Lock (ABS) ....................... .331
Fluid Check .......................... .469
Master Cylinder ....................... .469
Parking ............................. .328Warning Light
........................ .202
Brake/Transmission Interlock .................300
Bulb Replacement ........................ .496
Bulbs, Light .............................114
Cab Top Clearance Lights ...................501
Capacities, Antifreeze (Engine Coolant) ..........503
Capacities, Fluid ......................... .503
Caps, Filler Oil (Engine) .......................... .453
Power Steering ........................ .327
Radiator (Coolant Pressure) ................465
Carbon Monoxide Warning ..................110
Cargo Light ............................ .159
Car Washes ............................ .478
Cellular Phone .......................... .268
Center High Mounted Stop Light ..............499
Center Lap Belts ...........................59
Center Seat Storage Compartment .............187
10
INDEX 527

Certification Label........................ .387
Chart, Tire Sizing ........................ .345
Check Engine Light (Malfunction Indicator Light) . .200
Checking Your Vehicle For Safety ..............110
Checks, Safety ............................110
Child Restraint ............................74
Child Restraints Child Seat Installation .....................98
Lower Anchors And Tethers For Children .......82
Cigar Lighter ........................... .180
Clean Air Gasoline ....................... .381
Cleaning Wheels .............................. .480
Climate Control ......................... .268
Cold Weather Operation ....................295
Compact Disc (CD) Maintenance ..............267
Compact Spare Tire ....................... .362
Console, Overhead ....................... .174
Contract, Service ......................... .519Coolant Pressure Cap (Radiator Cap)
...........465
Cooling System .......................... .461
Adding Coolant (Antifreeze) ...............463
Coolant Capacity ...................... .503
Coolant Level ......................... .461
Disposal of Used Coolant .................466
Drain, Flush, and Refill ...................462
Inspection ........................... .466
Points to Remember .....................468
Pressure Cap ......................... .465
Radiator Cap ......................... .465
Selection of Coolant (Antifreeze) .............462
Corrosion Protection ...................... .477
Cupholders ............................ .182
Customer Assistance ...................... .517
Data Recorder, Event .......................73
Daytime Running Lights ....................152
Dealer Service ........................... .449
528 INDEX

Alarm.............................. .205
Anti-Lock ............................ .200
Anti-Lock Warning ..................... .332
Automatic Headlights ....................151
Brake Assist Warning ....................341
Brake Warning ........................ .202
Bulb Replacement ...................... .495
Cap Top Clearance ..................... .501
Cargo .............................. .159
Center Mounted Stop ....................499
Check Engine (Malfunction Indicator) .........200
Courtesy/Reading ..................... .157
Daytime Running ...................... .152
Electronic Stability Program (ESP) Indicator .....341
Exterior ..............................114
Fog ................................ .155
Four-Wheel Drive Indicator ................315
Hazard Warning Flasher ..................420
Headlights ........................... .151High Beam
........................... .161
High Beam Indicator .....................204
High Beam/Low Beam Select ...............161
Illuminated Entry ........................23
Instrument Cluster ..................... .200
Interior ............................. .156
Oil Pressure .......................... .205
Passing ............................. .161
Seat Belt Reminder ..................... .204
Security Alarm ........................ .205
Service .............................. .495
Tire Pressure Monitoring (TPMS) ............206
Traction Control ....................... .341
Transfer Case ......................... .315
Turn Signal ............................114
Warning (Instrument Cluster Description) ......200
Limited-Slip Differential ....................322
Loading

Vehicle ......................... .387
Tires ............................... .351
534 INDEX