2014 MINI Clubman run flat

3Holder for the sealant bottle4Compressor5Connector and cable for the lighter socket/
socket in passenger compartment   91.6Connection hose for connecting the com‐
pressor and sealant bottle or the compres‐
sor and wheel7On/off switch8Pressure gauge for displaying the tire infla‐
tion pressure9Release button for reducing the tire infla‐
tion pressure
The connector, cable, and connecting hose are
stowed in the compressor housing.
Using the Mobility System
To repair a flat tire with the Mobility System,
proceed as follows:
▷Filling the tire with sealant▷Distributing the sealant▷Correcting the tire inflation pressure
Filling the tire with sealant
Adhere to the specified sequence
Adhere to the specified sequence of the
steps; otherwise, sealant may escape under
high pressure. ◀
1.Shake the sealant bottle.2.Pull the connection hose 6 fully out of the
compressor housing and screw it onto the
sealant bottle connection. Ensure that the
connection hose is not kinked.3.Insert the sealant bottle into the compres‐
sor housing in a vertical position.4.Unscrew the dust cap off of the valve of the
defective wheel and screw the filling hose 2
of the sealant bottle onto the valve.5.Ensure that the compressor is switched off.6.Insert connector 5 into the lighter socket/
socket in the passenger compartment, refer
to page 91.7.When the engine is running:
Switch on the compressor and let it run for
approx. 3 to 8 minutes to fill sealant into
the tire and achieve a tire inflation pressure
of approx. 1.8 bar/26 psi.
While sealant is being filled, the inflation
pressure may intermittently rise to approx.
5 bar/73 psi. Do not switch off the com‐
pressor in this phase.8.Switch off the compressor.
Do not allow the compressor to run too
long
Do not allow the compressor to run longer than
10 minutes; otherwise, the device will overheat
and may be damaged. ◀
If an air pressure of 1.8 bar/26 psi is not
reached:
1.Unscrew the filling hose 2 from the wheel
and drive forward and back approx.
33 ft/10 m to evenly distribute the sealant
in the tire.2.Inflate the tire again using the compressor.Seite 152MobilityWheels and tires152
Online Edition for Part no. 01 40 2 911 429 - VI/13

If the inflation pressure of 1.8 bar/26 psi is still
not reached, the tire is too heavily damaged.
Contact the nearest service center.
Stowing the Mobility System1.Unscrew the filling hose 2 of the sealant
bottle from the wheel.2.Unscrew the compressor connection hose 6
from the sealant bottle.3.Connect the filling hose 2 of the sealant
bottle with the free connector on the seal‐
ant bottle.
This prevents left-over sealant from escap‐
ing from the bottle.4.Wrap the empty sealant bottle in suitable
material to avoid dirtying the cargo area.5.Stow the Mobility System back in the vehi‐
cle.
Distributing the sealant
Drive approx. 3.1 miles/5 km to evenly distrib‐
ute the sealant.
Do not exceed a speed of 50 mph/80 km/h. If
possible, do not drop below a speed of
10 mph/20 km/h.
Correcting the tire inflation pressure
1.After driving approx. 3.1 miles/5 km, or
about 10 minutes, stop in a suitable loca‐
tion.2.Screw the connection hose 6 of the com‐
pressor directly onto the tire valve.3.Insert the connector 5 into the power
socket in the passenger compartment.4.Correct the tire inflation pressure to
1.8 bar/26 psi. When the engine is running:▷To increase the inflation pressure:
switch on the compressor. To check the
currently set inflation pressure, switch
off the compressor.▷To reduce the inflation pressure: press
the release button 9.Do not allow the compressor to run too
long
Do not allow the compressor to run longer than
10 minutes; otherwise, the device will overheat
and may be damaged. ◀
If the inflation pressure is not maintained, take
the vehicle on another drive, distributing the
sealant, refer to page 153. Then repeat steps
1 to 4 once.
If the inflation pressure of 1.8 bar/26 psi is still
not reached, the tire is too heavily damaged.
Contact the nearest service center.
Continuing the trip Note the maximum speed
Do not exceed the maximum speed of
50 mph/80 km/h; otherwise, accidents can oc‐
cur. ◀
Replace the defective tire as soon as possible
and have the wheel balanced.
Have the Mobility System refilled.
Snow chains
Only certain fine-link snow chains have been
tested by MINI, classified as safe for use, and
recommended. Consult your service center for more information.
Use only in pairs on the front wheels, equipped
with tires of the following size:▷175/65 R 15 M+S▷175/60 R 16 M+S
John Cooper Works:
▷185/50 R 17 86 H M+S XL RSC
Observe the manufacturer's instructions when
mounting snow chains. Do not exceed a speed
of 30 mph or 50 km/h when using snow chains.
Do not initialize the Flat Tire Monitor if snow
chains are mounted; otherwise, the instrument
might issue an incorrect reading. When driving
with snow chains, it may be useful to tempora‐
Seite 153Wheels and tiresMobility153
Online Edition for Part no. 01 40 2 911 429 - VI/13

Replacing componentsVehicle equipmentThis chapter describes all series equipment as
well as country-specific and special equipment
offered for this model series.Therefore, it also
describes equipment that may not be found in
your vehicle, for instance due to the selected
special equipment or the country version. This
also applies to safety-related functions and sys‐
tems.
Tool kit Depending on the vehicle equipment, your ve‐
hicle contains a special onboard vehicle tool kit
that is stowed under the flat loading floor in the
cargo area.
With Mobility System
MINI1Sealant bottle2Pulling hook3Vehicle jack4Lug bolts wrench5Screwdriver/cross-head, tow fitting6CompressorMINI Clubman1Compressor2Lug bolts wrench3Vehicle jack4Torx insert for screwdriver5Screwdriver/cross-head, tow fitting6Pulling hook7Sealant bottle
With run-flat tires or compact wheel
The onboard vehicle tool kit contains a pouch
holding a plastic bag in which you can stow the
defective wheel.
MINI
1Folding wheel chock and cover for the de‐
fective wheel2Pulling hook3Lug bolts wrench4Vehicle jackSeite 162MobilityReplacing components162
Online Edition for Part no. 01 40 2 911 429 - VI/13

Changing wheelsNotes
Wheel change for run-flat tires:▷Prepare for the wheel change, refer to
page 171.▷Jack up the vehicle, refer to page 171.▷Tighten the lug bolts, refer to page 172.
Compact wheel
Wheel change with a compact wheel:
▷Remove the compact wheel, refer to
page 170.▷Prepare for the wheel change, refer to
page 171.▷Jack up the vehicle, refer to page 171.▷Mount the compact wheel, refer to
page 172.▷Tighten the lug bolts, refer to page 172.▷Drive with the compact wheel, refer to
page 171.
MINI: removing the compact wheel
The screw fitting of the compact wheel is lo‐
cated in the cargo area under the floor mat, on
the floor of the storage compartment holding
the wheel change set.
1.Release the screw fitting with the special
wrench.2.Take out the cover.3.Screw the lifting handle from the onboard
vehicle tool kit onto the thread.4.Raise the lifting handle slightly.5.Squeeze the locking spring.6.Lower the compact wheel with the lifting
handle.7.Lower the compact wheel with the lifting
handle.8.Unscrew the lifting handle again.9.Pull the compact wheel out from under the
vehicle toward the back.10.Lay the compact wheel down with the
valve facing up.Seite 170MobilityReplacing components170
Online Edition for Part no. 01 40 2 911 429 - VI/13

MINI Clubman
The first aid kit is located in the left side trim on
the cargo area floor or under the flat loading
floor.
Roadside Assistance
Service availability Roadside Assistance can be reached around the
clock in many countries. You can obtain assis‐
tance there in the event of a vehicle break‐
down.
Roadside Assistance A phone number for Roadside Assistance can
be displayed, refer to page 132, via the radio.
Jump-starting NotesIf the battery is discharged, the engine can be
started using the battery of another vehicle and
two jumper cables. In the same way, you can
help jump-start another vehicle. Only use
jumper cables with fully insulated clamp han‐
dles.
To prevent personal injury or damage to both
vehicles, adhere strictly to the following proce‐
dure.
Do not touch live parts
To avoid the risk of potentially fatal injury,
always avoid all contact with electrical compo‐
nents while the engine is running. ◀
Preparation1.Check whether the battery of the other ve‐
hicle has a voltage of 12 volts and approxi‐
mately the same capacitance in Ah. This in‐
formation can be found on the battery.2.Switch off the engine of the assisting vehi‐
cle.3.Switch off any electronic systems/power
consumers in both vehicles.
Bodywork contact between vehicles
There must not be any contact between
the bodies of the two vehicles, otherwise there
is a danger of shorting. ◀
Seite 175Breakdown assistanceMobility175
Online Edition for Part no. 01 40 2 911 429 - VI/13

FFailure messages, refer to Check Control 60
False alarm, refer to Avoiding unintentional alarms 30
Fastening safety belts, refer to Safety belts 36
Fault messages, refer to Check Control 60
Filling capacities 199
Filter– Refer to Activated-charcoal
filter 84– Refer to Microfilter 84– Refer to Microfilter/acti‐
vated-charcoal filter with
automatic climate control 86
First aid kit 174
First aid, refer to First aid kit 174
Flashing when locking/unlock‐ ing 23
Flat tire
– Flat Tire Monitor 70– Indicator/warning lamp 70– Run-flat tire 71– Tire Pressure Monitor
TPM 72
Flat Tire Monitor FTM 69
Flat Tire Monitor FTM
– Flat tire message 70– Initializing the system 70– Limits of the system 70– Snow chains 70
Flat tire, wheel change 170
Floor mats, care 182
Fog lamps 65
Foot brake 102
Footwell lamps, refer to Inte‐ rior lamps 65
Front airbags 67
Front fog lamp, bulb replace‐ ment 166
Front fog lamps 65
Front lamps, bulb replace‐ ment 165
Front passenger airbags, de‐
activating 68
FTM Flat Tire Monitor 69
Fuel 140
Fuel– Refer to Average fuel con‐
sumption 56
Fuel, additives 140
Fuel, average consump‐ tion 56
Fuel cap, closing 138
Fuel consumption display
– Average fuel consump‐
tion 56
Fuel filler flap, closing 138
Fuel filler flap, opening 138
Fuel filler flap, unlocking in case of an electrical malfunc‐
tion 138
Fuel gauge 55
Fuel, saving 108
Fuel tank capacity, refer to Filling capacities 199
Fuel tank contents, refer to Filling capacities 199
Fuel tank, refer to Filling ca‐ pacities 199
Fuse 173
G Garage door opener, refer to Universal garage door
opener 87
Gasoline 140
Gasoline gauge, refer to Fuel gauge 55
Gasoline quality 140
Gear change
– Automatic transmission with
Steptronic 52
Gear display, automatic trans‐
mission with Steptronic 51
Glass sunroof, electrical 31
Glass sunroof, electrical– Convenient operation 23– Opening, closing 31– Raising 31– Remote control 23
H
Halogen headlamps, bulb re‐ placement 165
Hand car wash, care 180
Hand-held transmitter, alter‐ nating code 88
Hands-free microphone 15
Hazard warning system 15
Head airbags 67
Headlamp control, auto‐ matic 62
Headlamp courtesy delay fea‐ ture 64
Headlamp flasher 47, 63
Headlamps 62
Headlamps, care 180
Headlamps, cleaning, washer fluid 50
Head restraints 37
Head restraints
– Adjusting the height 37– Removing 37
Heatable
– Windshield 86
Heating
– Rear window 83, 86– Seats 36– Windshield 86
Height adjustment
– Seats 34
High beams 63
High beams, bulb replace‐ ment 165
Hill drive-off assistant 78
Hills 102
Holder for remote control, re‐ fer to Ignition lock 44
Homepage 6
Hood 155
Hood, closing 156
Seite 203Everything from A to ZReference203
Online Edition for Part no. 01 40 2 911 429 - VI/13

Hood, opening 156
Hood, unlocking 156
Horn 12
Hydraulic brake assistant 76
I
Ice warning, refer to External temperature warning 54
Icy roads, refer to External temperature warning 54
Identification marks, run-flat tires 151
Identification marks, tires 147
Ignition 44
Ignition key position 1, refer to Radio ready state 44
Ignition key position 2, refer to Ignition on 44
Ignition key, refer to Remote control with integrated
key 20
Ignition lock 44
Ignition, switched off 45
Ignition, switched on 44
Indicator and warning lamps 15
Indicator and warning lamps– Tire Pressure Monitor
TPM 73
Indicator and warning lamps,
overview 183
Individual air distribution 83
Inflation pressure monitor, re‐ fer to Flat Tire Monitor 69
Inflation pressure monitor, re‐ fer to Tire Pressure Monitor
TPM 72
Inflation pressure, refer to Tire inflation pressure 142
Initializing
– Compass, refer to Calibrat‐
ing 90– Glass sunroof, electrical 31
Initializing, Flat Tire Monitor
FTM 70
Instrument cluster, refer to
Displays 14
Instrument lighting 65
Instruments, refer to Cock‐ pit 12
Integrated key 20
Interior equipment 87
Interior lamps 65
Interior lamps– Remote control 24
Interior mirror 38
Interior rearview mirror, com‐ pass 89
Interior temperature, setting
– Air conditioner 82– Automatic climate con‐
trol 84
Internet page 6
J Jump-starting 175
K
Keyless Go, refer to Comfort Access 28
Keyless opening and closing, refer to Comfort Access 28
Key Memory, refer to Personal Profile 20
Key, refer to Remote control with integrated key 20
Kickdown
– Automatic transmission with
Steptronic 52
Knocking control 140
L Lamp and bulb replacement, bulb replacement 164
Lamp, replacing, refer to Lamp and bulb replace‐
ment 164
Lamps 62
Lamps, automatic headlamp
control 62
Lamps, parking lamps/low beams 62
Lap-and-shoulder belt, refer to Safety belts 36
LATCH child restraint fixing system 41
Leather, care 181
Leather care 181
LEDs, light-emitting di‐ odes 164
License plate lamp, bulb re‐ placement 167
Light-alloy wheels, care 182
Light-emitting diodes, LEDs 164
Lighter– Socket 91
Lighting
– Instruments 65
Lighting, lamp and bulb re‐
placement 164
Lighting, vehicle, refer to Lamps 62
Light switch 62
Lock buttons on doors, refer to Locking 25
Locking
– From the inside 25– From the outside 23– Setting the confirmation sig‐
nal 23– Without remote control, re‐
fer to Comfort Access 28
Locking, vehicle
– From the inside 25– From the outside 22
Longlife oils, alternative oil
types 158
Longlife oils, refer to Ap‐ proved engine oils 158
Low beams 62
Low beams
– Automatic 62
Low beams, automatic 62
Seite 204ReferenceEverything from A to Z204
Online Edition for Part no. 01 40 2 911 429 - VI/13

Prescribed engine oils, refer toApproved engine oils 158
Pressure monitoring of tires, refer to Tire Pressure Monitor
TPM 72
Pressure, tires 142
Pressure warning, tires 69
Profile depth, refer to Mini‐ mum tread depth 148
Profile, tires 148
Protective function, refer to
Pinch protection– Windows 32
R
Radio MINI Boost CD 112
Radio-operated key, refer to Remote control with
integrated key 20
Radio ready state 44
Radio ready state, switched off 45
Radio ready state, switched
on 44
Radio setting, refer to Radio ready state 44
Rain sensor 48
Range 56
Rear door, refer to Club‐ door 26
Rear doors, refer to Split door 27
Rear fog lamp 65
Rear fog lamp, bulb replace‐ ment 167
Rear lamps, refer to Tail lamps 167
Rear swing doors, refer to Split door 27
Rearview mirror, refer to Mir‐ rors 38
Rear window defroster 83, 86
Rear window, washing 50
Rear window wiper 50
Recirculated air mode 83, 85
Recommended tire
brands 150
Releasing, refer to Unlock‐ ing 28
Remaining range for service, refer to Service require‐
ments 59
Remaining range, refer to Range 56
Remote control– Battery replacement 30– Comfort Access 28– Malfunctions 24, 29– Split door 24
Remote control, removing
from the ignition lock 44
Remote control, service data 160
Remote control, universal 87
Replacement remote con‐ trol 20
Replacing wheels/tires 149
Reporting safety defects 9
Reserve warning, refer to Fuel gauge 55
Reservoir for washer fluid, re‐ fer to Washer fluid reser‐
voir 50
Restraining systems
– Refer to Safety belts 36
Restraint systems for chil‐
dren 40
Retreaded tires 150
Reverse gear, manual trans‐ mission 51
Roadside Assistance 175
Roadside parking lamp, bulb replacement 166
Roadside parking lamps 63
RON gasoline quality 140
RON, refer to Fuel quality 140
RPM, refer to Engine data 196
Rubber seals, care 181
Run-flat tires 151
Run-flat tires
– Flat tire 70Run-flat tires, tire inflation
pressure 142
Running lights, refer to Park‐ ing lamps/low beams 62
S Safe braking 102
Safety 6
Safety belts 36
Safety belts– Damage 37
Safety belts, care 182
Safety belts, indicator/warning lamp 37
Safety belts, reminder 37
Safety systems
– Safety belts 36
Safety systems, airbags 67
Saving fuel 108
Seat adjustment
– Manual 34
Seat belts
– Refer to Safety belts 36
Seat heating 36
Seats
– Adjusting 34– Heating 36– Sitting safely 34
Selector lever, automatic
transmission with Step‐
tronic 52
Selector lever lock, overrid‐ ing 53
Selector lever lock, refer to Changing selector lever posi‐
tions, Shiftlock 52
Selector lever positions, auto‐ matic transmission with
Steptronic 52
Service and warranty 7
Service data in the remote control 160
Service interval display, refer to Condition Based Service
CBS 160
Seite 206ReferenceEverything from A to Z206
Online Edition for Part no. 01 40 2 911 429 - VI/13