2014 KIA OPTIMA HYBRID catalytic converter

17
(a) “EPA” means the U.S. Environmental ProtectionAgency.
(b) “Owner” means the original and each subsequent owner of a Kia Vehicle.
(c) “Kia Part” means a part sold by an Authorized Kia Dealer, whether new or remanufactured,
and supplied by Kia.
(d) “Emission Warranty Part” means a catalytic converter, thermal reactor, or other component
installed on or in a Kia Vehicle by or at the
direction of Kia for the sole or primary purpose
of reducing the Kia Vehicle’s emissions (not
including those vehicle components which
were in general use prior to model year 1968
and the primary function of which is not related
to emission control). A list of typical Emission
Warranty Parts is set forth at the end of this
warranty. (e) “Certified Part” means a replacement part for a
Kia Vehicle certified in accordance with after
market part certification regulations issued by
the EPA.
(f) “Written Maintenance Instructions” means those maintenance and operation instructions,
together with the time and/or mileage interval
at which such maintenances are to be
performed, specified in the Owner’s Manual for
the Kia Vehicle or this Warranty and Consumer
Information Manual as being necessary to
assure compliance of the Kia Vehicle with
applicable emission standards during the term
of this warranty, as specified by law.
Emission Warranty Definitions
Federal
Emission Control Warranty

24Federal
Emission Control Warranty
Federal Emission Control Warranty
Air Induction SystemAir Cleaner Assembly
Intake Manifold
Fuel Metering System Engine Coolant Temperature Sensor
Manifold Absolute Pressure Sensor
Wheel Speed Sensor
Fuel Injector
Fuel Delivery Line
Throttle Body
Oxygen Sensor
Pulsation Damper
Engine Control Module
* 8/80Ignition SystemSpark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor
Crankshaft Position Sensor
Generator
Valve Timing System CVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor Evaporative Control System
Vapor Storage Canister
Canister Close Valve
Purge Control Solenoid Valve
Fuel Pump
Fuel Tank
Fuel Filler Cap
Fuel Tank Pressure Sensor
ORVR(Vent) Valve
Rollover(Cut) Valve
Positive Crankcase Ventilation System PCV Valve and Hose
Catalyst and Exhaust System Exhaust Manifold
Exhaust Manifold Catalytic Assembly * 8/80Exhaust Pipe
Catalytic Converter Assembly * 8/80Hybrid SystemHybrid Battery Pack Assy #10/100Battery Management System #10/100Hybrid Power Control Unit #10/100Miscellaneous Items Used In Above SystemsHose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches,Solenoid Valves, Battery) associated with the ECM
Onboard Emission Diagnostic Device Malfunction Indicator Light and Bulb
* 8/80Data Link Connector * 8/80
Spark Plugs shall be warranted for the emissions warranty period, or the\
first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever\
occurs first, or up to the fist required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maint\
enance).
NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, wh\
ichever occurs first.
NOTE 3 : Specific Hybrid System Parts designated by "10/100" are warranted for 10\
years or 100,000 miles, whichever occurs first.

25
California
Emission Control Warranty
Y our Warranty Rights And Obligations
The California Air Resources Board and Kia Motors
America, Inc., are pleased to explain the emission
control system warranty on your 2014 Kia vehicle. In
California, new motor vehicles must be designed, built
and equipped to meet the State’s stringent anti-smog
standards. Kia must warrant the emission control
system on your Kia vehicle for the periods of time
listed below provided there has been no abuse, neglect
or improper maintenance of your Kia vehicle.
Y our emission control system may include parts such
as the carburetor or fuel-injection system, the ignition
system, catalytic converter, and engine computer. Also
included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable
condition exists, Kia will repair your Kia vehicle at no
cost to you including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage
For 3 years or 50,000 miles, whichever first occurs:
1. If your Kia vehicle fails a Smog Check inspection, all
necessary repairs and adjustments will be made by Kia to
ensure that your vehicle passes the inspection. This is your
emission control system PERFORMANCE WARRANTY.
2. If any emission-related part on your Kia vehicle is
defective, the part will be repaired or replaced by Kia. This
is your short-term emission control system DEFECTS
WARRANTY.
For 7 years or 70,000 miles for emission related parts,
whichever first occurs (8 years or 80,000 miles for Federal
Emission Control Warranty) : If an emission-related part listed in this warranty booklet
specially noted with coverage for 7 years or 70,000 miles is
defective, the part will be repaired or replaced by Kia. This
is your long-term emission control system DEFECTS
WARRANTY.
For 2014 SULEV (Super Ultra Low Emission Vehicle) vehicle
certified as Partial Zero-Emission Vehicle(PZEV) only, all
parts covered under the PERFORMANCE WARRANTY and
the DEFECT WARRANTY, which are listed in this warranty
booklet on the Emission Warranty Parts List, are warranted for
15 years or 150,000 miles, whichever occurs first.
California Emission Control Warranty Statement

California
Emission Control Warranty28
What The Owner Must Do
It is your responsibility to perform the required
maintenance and use the vehicle in accordance with
Kia’s written instructions. Warranty coverage will not be
denied solely because there is no record of maintenance.
However, failures caused by lack of required
maintenance are not covered by the warranty. To avoid
questions as to whether the vehicle maintenance has
been performed, Kia urges that you retain all receipts
and/or maintenance records indicating that service has
been performed on the vehicle and these documents
should be transferred to any subsequent owner of the
vehicle.
Service
MAINTENANCE SERVICE CAN BE PERFORMED
BY ANY QUALIFIED SERVICE OUTLET OR BY
THE OWNER. HOWEVER, EXCEPT IN AN
EMERGENCY SITUATION (SEE EMERGENCY
SERVICE), WARRANTY SERVICE MUST BE
PERFORMED BY AN AUTHORIZED KIA DEALER.
Parts
IT IS RECOMMENDED THAT ANY REPLACEMENT
PA RTS USED FOR MAINTENANCE OR FOR THE
REPAIR OF EMISSIONS CONTROL SYSTEMS BE
NEW, KIA GENUINE PARTS. However, the warranty
obligations are not dependent upon the use of any
particular brand of replacement parts. The owner may
elect to use non-Kia parts for maintenance purposes. Use
of replacement parts which are not of equivalent quality
may impair the effectiveness of emissions control
systems.
What Is Not Covered By Emission Warranty
Malfunctions in any part caused by misuse, alteration,
tampering, disconnection or improper or inadequate
maintenance.
Damage to catalytic converter due to use of leaded
gasoline.
Damage resulting from fire, accident, negligence, act of
God or other events beyond the control of Kia.
Maintenance replacement parts (such as spark plugs)
beyond the first scheduled replacement point.

California
Emission Control Warranty30
California Emission Control Warranty
Air Induction SystemAir Cleaner Assembly
Intake Manifold (
* 7/70)Fuel Metering SystemEngine Coolant Temperature Sensor
Manifold Absolute Pressure Sensor
Wheel Speed Sensor
Fuel Injector
Fuel Delivery Line
Throttle Body
Oxygen Sensor
Pulsation Damper
Engine Control Module (
* 8/80)Ignition SystemSpark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor
Crankshaft Position Sensor
Generator (
* 7/70)Valve Timing SystemCVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor Evaporative Control System
Vapor Storage Canister
Canister Close Valve
Purge Control Solenoid Valve
Fuel Pump
Fuel Tank (
*7/70)Fuel Filler Cap
Fuel Tank Pressure Sensor
ORVR(Vent) Valve
Rollover(Cut) Valve
Positive Crankcase Ventilation System PCV Valve and Hose
Catalyst and Exhaust System Exhaust Manifold
Exhaust Manifold Catalytic Assembly (
* 8/80)Exhaust Pipe
Catalytic Converter Assembly (* 8/80)Hybrid SystemHybrid Battery Pack Assy #10/150 (#10/100) Battery Management System #10/150 (#10/100) Hybrid Power Control Unit #10/150 (#10/100) Miscellaneous Items Used In Above SystemsHose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches, Solenoid Valves, Battery) associated with the ECM\
Onboard Emission Diagnostic Device Malfunction Indicator Light and Bulb (
* 8/80)Data Link Connector (* 8/80)
Spark Plugs shall be warranted for the emissions warranty period, or the\
first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : The above parts for a Optima Hybrid SULEV vehicle, certified as a Parial\
Zero-Emission Vehicle(PZEV) only, are warrant ed for 15 years
or 150,000 miles, whichever occurs first, with the exception of Pennsylv\
ania and Washington.
NOTE 2 : Specific Hybrid System parts designated by "10/150" are warranted for 10\
years or 150,000 miles, whichever occurs firs t, with the
exception of Pennsylvania and Washington.
NOTE 3 : Specific emission parts covered up to 5 years or 60,000 miles, \
whichever occurs first, in Pennsylvania and Washington.
NOTE 4 : Parts designated by "8/80" are warranted for 8 years or 80,000 \
miles, whichever occurs first, in Pennsylvania and Washington.
NOTE 5 : Parts designated by "7/70" are warranted for 7 years or 70,000 \
miles, whichever occurs first, in Pennsylvania and Washington.
NOTE 6 : Specific Hybrid System parts designated by "10/100" are warranted for 10\
years or 100,000 miles, whichever occurs firs t, in Pennsylvania
and Washington.
* (Pennsylvania and Washington only)