2014 FIAT 500X manual transmission

WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting
or riding on the brake pedal can result in abnor-
mally high brake temperatures, excessive lining
wear, and possible brake damage. Riding the
brakes may also reduce braking capacity in an
emergency.
Brake Master Cylinder
The fluid level in the master cylinder should be checked
when performing under hood services, or immediately
if the “Brake Warning Light” is on.
Be sure to clean the top of the master cylinder area
before removing the cap. If necessary, add fluid to bring
the fluid level up to the requirements described on the
brake fluid reservoir. Fluid level can be expected to fall
as the brake pads wear. The brake fluid level should be
checked when the pads are replaced. However, low
fluid level may be caused by a leak and a checkup may
be needed.NOTE:
If your vehicle is equipped with a manual
transmission, the brake fluid reservoir supplies fluid to
both the brake system and the clutch release system.
The two systems are separated in the reservoir, and a
leak in one system will not affect the other system. The
manual transmission clutch release system should not
require fluid replacement during the life of the vehicle.
If the brake fluid reservoir is low and the brake system
does not indicate any leaks or other problems, it may be
a result of a leak in the hydraulic clutch release system.
See your local authorized dealer for service.
Use only manufacturer’s recommended brake fluid.
Refer to “Fluids, Lubricants, And Genuine Parts” in the
“Technical Data” section for further information.
WARNING!
• Use only manufacturer ’s recommended brake
fluid. Refer to “Fluids, Lubricants, And Genuine
Parts” in the “Technical Data” section for further
information. Using the wrong type of brake fluid
can severely damage your brake system and/or
impair its performance. The proper type of brake
fluid for your vehicle is also identified on the
(Continued)
9
MAINTAINING AND CARING FOR YOUR VEHICLE 369

WARNING!(Continued)
original factory installed hydraulic master cylin-
der reservoir.
• To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep the
master cylinder reservoir cap secured at all times.
Brake fluid in a open container absorbs moisture
from the air resulting in a lower boiling point.
This may cause it to boil unexpectedly during
hard or prolonged braking, resulting in sudden
brake failure. This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should
be taken to avoid its contact with these surfaces.
• Do not allow petroleum-based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in a collision.
CAUTION!
Use of improper brake fluids will affect overall
clutch system performance. Improper brake fluids
may damage the clutch system resulting in loss of
clutch function and the ability to shift the transmis-
sion.
Manual Transmission — If Equipped
Lubricant Selection
Use only the manufacturers recommended transmis-
sion fluid. Refer to “Fluids, Lubricants, And Genuine
Parts” in “Technical Data” for further information.
Please see your authorized dealer for service.
Fluid Level Check
Check the fluid level by removing the fill plug. The
fluid level should be between the bottom of the fill hole
and a point not more than 3/16 inch (4.7 mm) below the
bottom of the hole.
Add fluid, if necessary, to maintain the proper level.
Please see your authorized dealer for service.
370 MAINTAINING AND CARING FOR YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Manual Transmission – If Equipped We recommend you use Mopar C Series Manual & Dual
Dry Clutch Transmission Fluid.
Automatic Transmission – If Equipped Use only Mopar ZF 8&9 Speed ATF Automatic Trans-
mission Fluid, or equivalent. Failure to use the correct
fluid may affect the function or performance of your
transmission.
Power Transfer Unit (PTU) – If Equipped We recommended you use Mopar Front Axle/PTU
Synthetic Axle Lubricant SAE 75W-90 (API GL-5).
Rear Differential (RDM) – If Equipped We recommended you use Mopar Rear Axle/RDM
Synthetic Axle Lubricant SAE 75W-90 (API GL-5).
Brake Master Cylinder We recommend you use Mopar DOT 4. If DOT 4 brake
fluid is not available, then DOT 3 is acceptable.
DOT 4 brake fluid must be changed every 2 years
regardless of mileage.
10
TECHNICAL DATA 409

Light Bulbs........................... .209
Lights ............................... .209
AirBag ..........................132, 207
Automatic Headlights ....................67
Brake Warning ....................... .133
Cruise .......................... .151, 152
Daytime Running .......................68
Dimmer Switch, Headlight ................69
Exterior ............................ .209
Fog .................................68
Hazard Warning Flasher .................289
Headlights ............................66
Headlights On Reminder ..................68
Headlight Switch .......................66
High Beam ...........................69
High Beam/Low Beam Select ..............69
Instrument Cluster ......................66
Intensity Control .......................74
Interior ..............................70
Lights On Reminder .....................68
Low Fuel ........................... .140
Malfunction Indicator (Check Engine) ........140
Park .............................. .151
Seat Belt Reminder .....................133
Security Alarm ....................... .139Tire Pressure Monitoring (TPMS)
...........144
Turn Signal .....................70, 150, 209
Vanity Mirror ..........................72
Warning (Instrument Cluster Description) .....150
Loading Vehicle ........................ .268
Tires .............................. .384
Locks .................................36
Door ................................36
Lubrication, Body ....................... .360
Luggage Carrier .........................117
Lug Nuts ............................. .404
Maintenance Free Battery ...................358
Maintenance, General .....................354
Maintenance Procedures ...................354
Maintenance Schedule .....................344
Malfunction Indicator Light (Check Engine) . .140, 343
Manual, Service ..........................12
Manual Transmission ..................223,
370
Fluid Level Check ..................... .370
Frequency Of Fluid Change ...............371
Lubricant Selection .....................370
Shift Speeds ......................... .225
Master Cylinder (Brakes) ...................369
Methanol ............................. .262
466 INDEX

Seat Belt Maintenance.....................378
Seat Belt Reminder ...................... .164
Seat Belts .......................... .163, 207
Adjustable Shoulder Belt .................169
Adjustable Upper Shoulder Anchorage .......169
Child Restraint ....................... .188
Front Seat .....................163, 165, 167
Inspection .......................... .207
Operating Instructions ...................167
Pregnant Women ..................... .171
Pretensioners ........................ .172
Rear Seat ........................... .165
Reminder ........................... .133
Untwisting Procedure ...................169
Seats ..................................46
Adjustment ...........................46
Head Restraints ........................53
Seatback Release .......................46
Tilting ...............................46
Security Alarm ......................... .139
Arm The System .......................34
Selection Of Coolant (Antifreeze) .............408
Sentry Key (Immobilizer) ...................32
Sentry Key Replacement ....................26
Service Assistance .........................8 Service Contract
..........................10
Service Manuals ..........................12
Shifting Manual Transmission ...................223
Shift Lever Override ..................... .331
Shoulder Belts ......................... .165
Side View Mirror Adjustment ................58
Signals, Turn ..................... .70, 150, 209
Snow Chains (Tire Chains) ..................397
Snow Tires ............................ .393
Spark Plugs ........................... .408
Specifications Fuel (Gasoline) ....................... .408
Oil ............................... .408
Speed Control (Cruise Control) ...............235
Starting ............................ .29,

214
Cold Weather ........................ .216
Engine Fails To Start ....................215
Remote ..............................29
Starting And Operating ....................214
Starting Procedures ...................... .214
Steering Tilt Column ...........................55
Wheel, Heated .........................56
Wheel, Tilt ............................55
12
INDEX 469

Traction Control........................ .159
Trailer Towing ......................... .273
Cooling System Tips ....................283
Hitches ............................ .276
Minimum Requirements .................278
Trailer And Tongue Weight ...............277
Wiring ............................. .281
Trailer Towing Guide .....................277
Trailer Weight .......................... .277
Transfer Case Fluid .............................. .409
Transmission Automatic ....................... .226, 371
Fluid .............................. .409
Manual ............................ .223
Transporting Pets ....................... .205
Tread Wear Indicators .....................394
Turn Signals ........................ .70, 150
UCI Connector ......................... .445
Uconnect Customer Programmable Features ...........32
Uconnect Settings .......................32
Uconnect Settings Customer Programmable Features ..........439Passive Entry Programming
...............439
Uconnect Settings ..................... .439
Uconnect Voice Command ..................449
Uniform Tire Quality Grades ................398
Universal Consumer Interface (UCI) Connector . . .445
Unleaded Gasoline ...................... .261
Untwisting Procedure, Seat Belt ..............169
Vanity Mirrors ...........................72
Vehicle Loading ..................... .268, 386
Vehicle Modifications/Alterations ..............6
Vehicle Storage ...........................96
Viscosity, Engine Oil ..................... .356
Warning Flasher, Hazard ...................289
Warning, Roll Over ........................6
Warnings And Cautions .....................5
Warranty Information ....................4,11
Washer Adding
Fluid........................ .362
Washing Vehicle ........................ .373
Water Driving Through ...................... .271
Wheel And Wheel Trim ....................374
Wheel And Wheel Trim Care ................374
12
INDEX 471