2014 DODGE CHARGER radiator cap

•You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads “H,”
pull over and stop the vehicle. Idle the vehicle with
the air conditioner turned off until the pointer drops
back into the normal range. If the pointer remains on
the “H,” turn the engine off immediately and call for
service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
WHEEL AND TIRE TORQUE SPECIFICATIONS
Proper lug nut/bolt torque is very important to ensure
that the wheel is properly mounted to the vehicle. Any
time a wheel has been removed and reinstalled on the
vehicle the lug nuts/bolts should be torqued using a
properly calibrated torque wrench.
506 WHAT TO DO IN EMERGENCIES

To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.Cooling System
WARNING!
• When working near the radiator cooling fan, dis-
connect the fan motor lead or cycle the ignition
switch to the LOCK position. The fan is tempera-
ture controlled and can start at any time the igni-
tion switch is in the ON position.
• You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had
time to cool. Never try to open a cooling system
pressure cap when the radiator is hot.
Coolant Checks
Check engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
552 MAINTAINING YOUR VEHICLE

applicable). If the engine coolant (antifreeze) is dirty, the
system should be drained, flushed, and refilled with
fresh OAT coolant (conforming to MS-12106) only ac-
cording to Chrysler Service Manual procedure or by an
authorized dealer. Check the front of the radiator for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts, and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
engine coolant (antifreeze) from the radiator drain cock.
If the cap is sealing properly, the engine coolant (anti-
freeze) will begin to drain from the coolant recoverybottle. DO NOT REMOVE THE COOLANT PRESSURE
CAP WHEN THE COOLING SYSTEM IS HOT.
Cooling System — Drain, Flush And Refill
If the engine coolant (antifreeze) is dirty or contains
visible sediment, have an authorized dealer clean and
flush with OAT coolant (antifreeze) (conforming to MS-
12106).
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
NOTE:
Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could lead
to severe internal engine damage. If any coolant is
needed to be added to the system please contact your
local authorized dealer.
7
MAINTAINING YOUR VEHICLE 553

(antifreeze) solution. The use of lower quality water
will reduce the amount of corrosion protection in the
engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:
• Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could
lead to severe internal engine damage. If any coolant is
needed to be added to the system please contact your
local authorized dealer.
• Mixing engine coolant (antifreeze) types is not recom-
mended and can result in cooling system damage. If
HOAT and OAT coolant are mixed in an emergency, have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS-12106) as soon as
possible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
556 MAINTAINING YOUR VEHICLE

WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator/coolant pressure cap
unless checking for engine coolant (antifreeze) freeze
point or replacing coolant. Advise your service attendant
of this. As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked once
a month.
7
MAINTAINING YOUR VEHICLE 557

Brake System........................... .559
Anti-Lock (ABS) ....................... .429
Fluid Check .......................... .559
Master Cylinder ....................... .559
Parking ............................. .426
Warning Light ........................ .320
Brake/Transmission Interlock .................399
Brightness, Interior Lights ...................225
Bulb Replacement ........................ .583
Bulbs, Light ............................ .100
Camera, Rear ........................... .277
Capacities, Fluid ......................... .588
Caps, Filler Oil (Engine) .......................... .541
Radiator (Coolant Pressure) ................556
Carbon Monoxide Warning ...................96
Cargo (Vehicle Loading) ....................488 Car Washes
............................ .565
Cellular Phone .......................... .373
Certification Label ........................ .488
Chains, Tire ............................ .463
Changing A Flat Tire ...................... .508
Chart, Tire Sizing ........................ .441
Check Engine Light (Malfunction Indicator Light) . .317
Checking Your Vehicle For Safety ...............96
Checks, Safety ............................96
Child Restraint ............................73
Child Restraints Child Seat Installation .....................91
Install A LATCH-compatible Child Restraint .....86
Installing Child Restraints Using The Vehicle Seat
Belt ..................................88
Lower Anchors And Tethers For Children .......81
Child Safety Locks .........................33
Clean Air Gasoline ....................... .478
612 INDEX

CleaningWheels .............................. .567
Climate Control ......................... .374
Coin Holder ............................ .303
Cold Weather Operation ....................395
Compact Disc (CD) Maintenance ..............373
Compact Spare Tire ....................... .458
Computer, Trip/Travel ..................... .337
Connector UCI................................ .369
Universal Consumer Interface (UCI) ..........369
Conserving Fuel ......................... .335
Console, Floor .......................... .303
Contract, Service ......................... .603
Coolant Pressure Cap (Radiator Cap) ...........556
Cooling System .......................... .552
Adding Coolant (Antifreeze) ...............555
Coolant Capacity ...................... .588
Coolant Level ......................... .552Disposal of Used Coolant
.................557
Drain, Flush, and Refill ...................553
Inspection ........................... .557
Points to Remember .....................558
Pressure Cap ......................... .556
Radiator Cap ......................... .556
Selection of Coolant (Antifreeze) .............554
Corrosion Protection ...................... .564
Cruise Control (Speed Control) ................241
Cupholders ............................ .300
Customer Assistance ...................... .601
Customer Programmable Features .............339
Data Recorder, Event .......................72
Daytime Brightness, Interior Lights .............227
Daytime Running Lights ....................220
Dealer Service ........................... .537
Deck Lid, Emergency Release .................44
Deck Lid, Power Release .....................
4210
INDEX 613

Outlet (Auxiliary Electrical Outlet)...........295
Seats ............................... .197
Steering ............................. .425
Sunroof ............................. .292
Tilt/Telescoping Steering Column ............232
Windows ..............................39
Power Steering Fluid ...................... .590
Pregnant Women and Seat Belts ................58
Preparation for Jacking .....................511
Pretensioners Seat Belts ..............................56
Programming Transmitters (Remote Keyless Entry) . .22
Radial Ply Tires ......................... .455
Radiator Cap (Coolant Pressure Cap) ...........556
Radio Operation ......................... .373
Radio Remote Controls .....................371
Rain Sensitive Wiper System .................230
Rear Axle (Differential) .....................564 Rear Camera
........................... .277
Rear Cupholder ......................... .301
Rear ParkSense System .....................269
Rear Seat, Folding ........................ .209
Rear Window Defroster .....................307
Rear Window Features .....................307
Recorder, Event Data .......................72
Recreational Towing ...................... .502
Reformulated Gasoline .....................478
Refrigerant ............................. .546
Reminder, Lights On ...................... .220
Reminder, Seat Belt .........................57
Remote Control Starting System .........................27
Remote Keyless Entry (RKE) ..................22
Arm The Alarm .........................19
FCC General Information ..................26
Lock The Doors .........................23
Panic Alarm ............................24
624 INDEX