2013 VOLVO V60 maintenance

09 Maintenance and service
Car care 09
362* Option/accessory, for more information, see Introduction.
Testing the brakes
WARNING
Always test the brakes after washing the
car, including the parking brake, to ensure
that moisture and corrosion do not attack
the brake linings and reduce braking per-
formance.
Lightly depress the brake pedal now and then
when driving long distances in rain or slush.
The heat from the friction causes the brake lin-
ings to warm up and dry. Do the same thing
after starting in very damp or cold weather.
Exterior plastic, rubber and trim
components
A special cleaning agent available from Volvo
dealers is recommended for the cleaning and
care of coloured plastic parts, rubber and trim
components, such as glossy trim mouldings.
When using such a cleaning agent the instruc-
tions must be followed carefully.
IMPORTANT
Avoid waxing and polishing on plastic and
rubber.
When using degreasant on plastic and rub-
ber, only rub with light pressure if it is nec-
essary. Use a soft washing sponge.
Polishing glossy trim mouldings could wear
away or damage the glossy surface layer.
Polishing agent that contains abrasive must
not be used.
RimsOnly use rim cleaning agent recommended by
Volvo.
Strong rim cleaning agents can damage the
surface and cause stains on chrome-plated
aluminium rims.
Polishing and waxing
Polish and wax the car if the paintwork is dull
or to give the paintwork extra protection.
The car does not need to be polished until it is
at least one year old. However, the car can be
waxed during this time. Do not polish or wax
the car in direct sunlight.
Wash and dry the car thoroughly before you
begin polishing or waxing. Clean off asphalt
and tar stains using tar remover or white spirit.More stubborn stains can be removed using
fine rubbing paste designed for car paintwork.
Polish first with a polish and then wax with liq-
uid or solid wax. Follow the instructions on the
packaging carefully. Many preparations con-
tain both polish and wax.
IMPORTANT
Only paint treatment recommended by
Volvo should be used. Other treatment such
as preserving, sealing, protection, lustre
sealing or similar could damage the paint-
work. Paintwork damage caused by such
treatments is not covered by Volvo war-
ranty.
Water-repellent coating*
Never use products such as car wax,
degreaser or similar on glass surfa-
ces as this could ruin their water-repellent
properties.
Take care when cleaning so as not to damage
the glass surface.
To avoid damaging glass surfaces when
removing ice – only use plastic ice scrapers.
There is natural wear of the water-repellent
coating.
Treatment with a special finishing agent avail-
able from Volvo dealers is recommended in
ProCarManuals.com

09 Maintenance and service
Car care09
363
order to maintain the water-repellent proper-
ties. This should be used first after three years
and then each year.
Rustproofing – inspection and
maintenance
The car received a thorough and complete
rustproofing at the factory. Parts of the body
are made of galvanised sheet metal. The
underbody is protected by a wear-resistant
anti-corrosion compound. A thin, penetrating
rustproofing fluid was sprayed into the
exposed members, cavities, closed sections
and side doors.
Under normal conditions the rustproofing does
not require treatment for approximately 12
years. After this period, it should be treated at
three-year intervals. Volvo recommends that
you engage an authorised Volvo workshop for
assistance if the car needs further treatment.
Dirt and road salt can lead to corrosion so it is
important to keep the car clean. The car's rust-
proofing needs to be checked regularly and
touched-up if necessary in order for it to be
maintained.
Cleaning the interior
Only use cleaning agents and car care prod-
ucts recommended by Volvo. Clean regularly
and follow the instructions included with the
car care product.
Vacuuming is important prior to using cleaning
agents.
Carpets and cargo areaRemove inlaid carpets for separate cleaning of
the floor carpet and the inlaid carpets. Use a
vacuum cleaner to remove dust and dirt.
Each inlay mat is secured with pins.
–Take hold of the inlay mat at each pin and
lift the mat straight up.
Fit the inlay mat in place by pressing it in at
each pin.
WARNING
Before setting off check that the inlaid mat
in the driver area is firmly affixed and
secured in the pins in order to avoid getting
caught adjacent to and under the pedals.
A special textile cleaner is recommended for
stains on the floor mat after vacuuming. Floor
mats should be cleaned with agents recom-
mended by your Volvo dealer!
Stains on fabric upholstery and roof
upholstery
A special fabric cleaning agent, available from
authorised Volvo dealers, is recommended to
avoid impairing the fire retardant qualities of
the upholstery.
IMPORTANT
Sharp objects and Velcro may damage the
fabric upholstery.
Treating stains on leather upholsteryVolvo's leather upholstery is chromium-free
and is treated to preserve its original appear-
ance.
Leather upholstery ages and acquires a beau-
tiful patina over time. The leather is refined and
processed so that it retains its natural charac-
teristics. It is given a protective coating, but
regular cleaning is required in order to maintain
both characteristics and appearance. Volvo
offers a comprehensive product for the clean-
ing and treatment of leather upholstery which,
when used in accordance with the instructions,
preserves the leather's protective coating.
After a period of use the natural appearance of
the leather will nevertheless emerge, depend-
ing more or less on the surface texture of the
leather. This is a natural maturing of the leather
and shows that it is a natural product.
ProCarManuals.com

09 Maintenance and service
Car care 09
364
To achieve best results Volvo recommends
cleaning and the application of protective
cream once to four times per year (or more if
necessary). The Volvo Leather Care kit is avail-
able from your Volvo dealer.
IMPORTANT
•Certain items of coloured clothing (for
example, jeans and suede garments)
may stain the upholstery.
•Never use strong solvents. Such prod-
ucts may damage fabric, vinyl and
leather upholstery.
Washing instructions for leather
upholstery
1. Pour the leather cleaner on the dampened
sponge and squeeze out a strong foam.
2. Work the dirt away with gentle circular
movements.
3. Dab accurately with the sponge on the
stains. Allow the sponge to absorb the
stain. Do not rub.
4. Wipe off with soft paper or a cloth and
allow the leather to dry completely.
Protective treatment of leather
upholstery
1. Pour a small amount of the protective
cream on the felted cloth and massage in
a thin layer of cream with gentle circular
movements on the leather.
2. Allow the leather to dry for 20 minutes
before use.
The leather has now been given improved pro-
tection against stains and improved UV pro-
tection.
Washing instructions for the leather
steering wheel
•Remove dirt and dust with a soft pre-mois-
tened sponge and neutral soap.
•Leather needs to breathe. Never cover the
leather steering wheel with protective plas-
tic.
•Use natural oils. Volvo's leather care
agents are recommended for best results.
If the steering wheel has stains:
Group 1 (ink, wine, coffee, milk, sweat and
blood)
–Use a soft cloth or sponge. Mix a 5%
ammonia solution. (For blood stains, use a
solution of 2 dl water and 25g salt.)Group 2 (fats, oils, sauces and chocolate)
1. Same procedure as group 1.
2. Polish with an absorbent paper or cloth.
Group 3 (dry dirt, dust)
1. Use a soft brush to remove the dirt.
2. Same procedure as group 1.
Treating stains on interior plastic, metal
and wood parts
A fibrillated fibre or microfibre cloth, lightly
moistened with water, available from Volvo
dealers, is recommended for cleaning interior
parts and surfaces.
Do not scrape or rub stains. Never use strong
stain removers. A special cleaning agent avail-
able from Volvo dealers can be used for more
difficult cleaning.
Cleaning seatbeltsUse water and a synthetic detergent. A special
textile cleaning agent is available from your
Volvo dealer. Make sure the seatbelt is dry
before allowing it to retract.
ProCarManuals.com

09 Maintenance and service
Car care09

365 Touching up minor paintwork damage
Paint is an important part of the car's rust-
proofing and should therefore be checked reg-
ularly. To avoid the onset of rust, damaged
paintwork should be rectified immediately. The
most common types of paintwork damage are
stone chips, scratches, and marks on the
edges of wings, doors and bumpers.
Materials
•primer1 - for e.g. plastic-clad bumpers
there are special adhesive primers availa-
ble in spray cans
•base coat and clear coat - are available in
spray cans or as touch-up pens/sticks2
•masking tape
•fine sand paper1.
Colour code (Paint code)
Code for car's colour
It is important that the correct colour is used.
For product decal location, see page 370.
Repairing minor paint damage such as
stone chips and scratches
G021832
Before work is started, the car must be clean
and dry as well as at a temperature above
15 °C.
1. Apply a piece of masking tape over the
damaged surface. Then remove the tape to
remove any loose paint.
If the damage has reached down to a metal
surface (sheet steel), it is preferable to use
a primer. In the event of damage to a plas-
tic surface, an adhesive primer should be
used for better results - spray into the
spray can's cap and brush thinly.
1If required.2Follow the instructions that are included with the package for the touch-up pen/stick.
ProCarManuals.com

09 Maintenance and service
Car care 09
366
2. A light sanding with very fine abrasive
material can be performed locally before
painting if necessary (e.g. if there are rough
edges). Clean the surface thoroughly and
allow to dry.
3. Stir the primer well and apply using a fine
brush, matchstick or similar. Finish with
base coat and clear coat once the primer
has dried.
4. For scratches, proceed as above, but
mask around the damaged area to protect
the undamaged paintwork.
NOTE
If the stone chip has not penetrated down
to the meal and an undamaged layer of paint
remains in place, fill in with base coat and
clear coat as soon as the surface has been
cleaned.
ProCarManuals.com

09 Maintenance and service
09
367ProCarManuals.com

11 Alphabetical Index
11
409
Battery.............................................344, 391
maintenance....................................... 344
remote control ................................... 280
remote control key/PCC....................... 51
start assistance................................... 120
symbols on the battery....................... 345
warning symbols................................. 345
Bioethanol E85........................................ 289
Blind spot (BLIS)...................................... 194
BLIS......................................................... 194
Bluetooth
Ÿ
handsfree ........................................... 262
media ................................................. 259
microphone off ..................................265
streaming audio ................................. 259
transfer call to mobile ........................ 265
Bonnet, opening...................................... 328
Brake and clutch fluid..............................333
Brake light.................................................. 91
Brakes...................................................... 135
anti-lock braking system, ABS........... 135
brake light............................................. 91
brake system...................................... 135
electric parking brake......................... 137
Emergency Brake Assistance, EBA ... 135
emergency brake lights........................ 91filling brake fluid.................................. 334
handbrake........................................... 137
symbols in the combined instrument
panel...................................................136
Bulbs, see Lighting.................................. 335
C
Calls
incoming............................................. 264
operation............................................. 264
Camera sensor................................169, 178
Car care................................................... 361
Car care, leather upholstery.................... 363
Cargo area
cargo cover......................................... 296
lighting.................................................. 93
loading................................................292
mounting points.................................. 293
safety grille.......................................... 296
safety net............................................ 295
Cargo cover............................................. 296
Car upholstery......................................... 363
Car wash.................................................. 361Catalytic converter................................... 288
recovery..............................................305
CD ........................................................... 252
Centre console........................................ 202
Chassis settings......................................226
Checking and topping up the coolant..... 332
Checking the engine oil level................... 329
Children..................................................... 31
child safety locks.................................. 38
child seats and side airbags................. 24
location in the car.................................31
safety.................................................... 31
Child safety locks...................................... 62
Child seat................................................... 31
Child seats................................................. 31
integrated two-stage booster cushion. 36
ISOFIX fixture system for child seats. . . 38
recommended...................................... 32
size classes for child seats with the ISO-
FIX fixture system................................. 38
upper mounting points for child seats. . 41
Cigarette lighter socket............................ 228
City Safety™............................................ 168
ProCarManuals.com

11 Alphabetical Index
11
413
Intermittent wiping..................................... 98
iPodŸ, connection................................... 256
K
Kerb weight.............................................. 373
Key............................................................. 44
Key blade................................................... 48
Keyless drive...................................... 53, 113
Keyless start (keyless drive)............... 53, 113
Keypad in the steering
wheel.................................85, 152, 203, 236
Key positions............................................. 78
L
Labels...................................................... 370
Laminated glass....................................... 101
Lamps, see Lighting................................335
Lane Departure Control........................... 185
Laser sensor................................................ 9
Leather upholstery, washing instructions 363Lighting.................................................... 335
Active Xenon headlamps...................... 90
approach light, duration.................46, 94
automatic lighting, passenger compart-
ment...................................................... 93
bulbs, specifications........................... 339
controls................................................. 92
display lighting...................................... 86
headlamp levelling................................ 86
home safe lighting................................ 94
in passenger compartment................... 92
instrument lighting................................ 86
main/dipped beam............................... 87
position/parking lamps......................... 91
rear fog lamp........................................ 91
tunnel detection.................................... 90
Lighting, bulb replacement...................... 335
bulb holder, rear, direction indicators. 338
cargo area........................................... 339
dipped beam halogen......................... 336
direction indicators............................. 337
main beam, Xenon lamp.....................337
main beam halogen............................ 337
number plate lighting.......................... 338
vanity mirror........................................ 339
Light switches............................................ 86Loading
cargo area........................................... 292
general................................................ 292
mounting points.................................. 293
roof load............................................. 292
Lock confirmation ..................................... 44
Locking/unlocking
inside.................................................... 57
tailgate.................................................. 59
Locks
automatic locking................................. 57
locking.................................................. 57
unlocking.............................................. 57
Lubricants................................................ 381
Lubricants, capacities.............................. 381
M
Main/dipped beam, see Lightning............. 87
Main beam, automatic activation.............. 88
Maintenance
rustproofing........................................ 363
Making calls............................................. 264
ProCarManuals.com