2013 FIAT SCUDO tow

154
WARNING
LIGHTS AND
MESSAGES
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
fig. 26
A
F0P0243m
Do not start the engine
when towing the vehicle.
WARNING
Before screwing the drawbar
eye, carefully clean the rela-
tive threaded part. Before starting to
tow the vehicle, take care also to
have completely tightened the draw-
bar eye onto the threaded pin.
WARNING
Before starting to tow, disen-
gage the steering lock (see
paragraph “Ignition device” in section
“Dashboard and controls”).
When towing, remember that without
the help of the brake booster and
power steering, a greater effort is re-
quired on the pedal and steering
wheel. Do not use flexible cables for
towing and avoid jerks. During tow-
ing operations make sure that fasten-
ing the joint to the vehicle does not
damage the components in contact
with it. When towing the vehicle, you
must comply with the specific traffic
regulations regarding the tow ring and
how to tow on the road.
WARNING
fig. 27F0P0608m
TOWING THE VEHICLE
The tow ring provided with the vehicle is
housed in the engine compartment as
shown in fig. 26.
TOW RING HOOKING
Proceed as follows:
❒open the bonnet and release the tow
ring A-fig. 26from its seat;
❒take away the front or rear door B-
fig. 27using the supplied screwdriver;
❒completely undo the drawbar eye on
the relative threaded pin.
135-154 SCUDO LUM GB_133-152 Nuovo ScudoG9 GB 17/10/12 14.43 Pagina 154

IMPORTANT The Programmed Mainte-
nance coupons are specified by the Man-
ufacturer. The failure to have them car-
ried out may invalidate the warranty.
Scheduled Servicing is performed by all
Fiat Dealership, at pre-established times.
If during each operation, in addition to the
ones programmed, the need arises for fur-
ther replacements or repairs, these may
be carried out only with the explicit agree-
ment of the Customer.IMPORTANT You are advised to contact
Fiat Dealership in the event of any minor
operating faults, without waiting for the
next service coupon.
If your vehicle is used frequently for tow-
ing, the interval between one service
coupon and the other must be reduced.SCHEDULED SERVICING
Correct maintenance is essential for en-
suring long life to your vehicle at top con-
ditions.
This is why Fiat has programmed a series
of checks and maintenance operations
every 30,000 km.
It is however important to remember that
scheduled servicing does not completely
cover all the vehicle’s requirements: also
in the initial period before 30,000 km ser-
vice coupon and later, between one
coupon and another, ordinary care is still
required such as for example routine
check and topping up the level of fluids,
tyre pressure check, etc...
156
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
155-174 SCUDO LUM GB_153-172 Nuovo ScudoG9 GB 17/10/12 14.44 Pagina 156

159
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
HEAVY-DUTY
Should prevailing use of the vehicle be un-
der one of the following specially heavy
conditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external tempera-
tures below zero;
❒frequently idling engines or long dis-
tance low speed driving (e.g. door-to-
door deliveries) or in case of a long
term inactivity;
❒driving in the city;
carry out the following checks more fre-
quently than required in the Service
Schedule:
❒check front disk brake pad conditions
and wear;
❒check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
❒sight inspect the conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.);
❒check battery charge and fluid level
(electrolyte);
❒visual check on various drive belt con-
ditions;
❒check and replace pollen filter, if
required;
❒check and replace air cleaner, if
required.
ROUTINE
MAINTENANCE
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒light system operation (headlights, di-
rection indicators, hazard lights, etc.);
❒windscreen wiper/washer operation
and windscreen/rear window blade
position/wear;
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use PETRO-
NAS LUBRICANTS, products, designed
and produced specifically for Fiat vehicles
(see table “Capacities” in section “Tech-
nical specifications”).
155-174 SCUDO LUM GB_153-172 Nuovo ScudoG9 GB 17/10/12 14.44 Pagina 159

IDENTIFICATION PLATE
BODYWORK PAINT AND
TYRES fig. 4
The label attached to the upright, driver’s
side, indicates:
– The size of the wheel rims and the tyres;
– The brand of the tyres certified by the
manufacturer;
– The inflating pressure (the control of the
inflating pressure must be carried out
when stationary and at least once a
month):
– Paint colour code.
178
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
fig. 4
Bar Bar
PRESSIONS CONTROLLER PNEUS FROIDS (
0,05 bar)
A
B
C
D
E
F
G
H
I
F0P0304m
CHASSIS MARKING fig. 3
Use the flat tip of the towing hook so as
to open the car door.
fig. 3F0P0302m
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 178

193
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
WEIGHTS AND TOWABLE LOADS
VAN VERSIONS
For further details see the registration certificate of your vehicle.
In every Country it is compulsory to observe the current regulations in force concerning the admitted towable loads. Contact Fiat
Dealership for further details on towing and admitted towable loads.
Carrying loads
If max admitted load values are not exceed it will be possible to tow trailers. In any case, never exceed the max admitted trailer
and towable load values specified in the registration certificate.
Observe vehicle towing capacity values.
Number
of seats
2
3
2
3
2
3
2
3
90 Multijet
(Euro 4)
Payload
without the
driver
(kg)
925
913
925
913
1125
1073
1125
1113Towable load
with trailer
with brakes
(kg)
1672
1672
1472
1472
1453
1453
1433
1433EngineVersion
Short
wheelbase
(10 quintals)
Long
wheelbase
(12 quintals)
Unladen
vehicle
weight
(kg)
1661
1673
1661
1673
1680
1712
1700
1712Max
admitted
load
(kg)
2661
2661
2661
2661
2880
2860
2900
2900Max
payload
(kg)
1000
988
1000
988
1200
1148
1200
1188
Short
wheelbase
(12 quintals)
(*) The towable load with trailer with brakes can be increased provided the equivalent load is unloaded from the vehicle in order to avoid ex-
ceeding the total towable load. High external temperatures could cause low engine performance. In this event (external temperature exceeding
37°C) the towable load shall be limited to 700 kg without carrying other loads. If towing trailers never exceed 100 km/h speed (observe the reg-
ulations in force in your Country).High roof
(12 quintals)
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 193

194
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Number
of seats
2
3
2
3
2
3 Version
90 Multijet
(Euro 5)
Max
payload
(kg)
1000
988
1200
1188
1200
1188
Short
wheelbase
(10 quintals)
Short
wheelbase
(12 quintals)
Long
wheelbase
(12 quintals)
Unladen
vehicle
weight
(kg)
1661
1673
1661
1673
1680
1692Max
admitted
load
(kg)
2661
2661
2861
2861
2880
2880Payload
without the
driver
(kg)
925
913
1125
1113
1125
1113Towable load
with trailer
with brakes
(kg)
1672
1672
1472
1472
1453
1453
Number
of seats
2
3
2
3
2
3
2
3 Version
120 Multijet
Engine
Long
wheelbase
(12 quintals)
Unladen
vehicle
weight
(kg)
1702
1714
1702
1714
1732
1744
1763
1775Max
admitted
load
(kg)
2702
2702
2902
2932
2932
2963
2963
2963Max
payload
(kg)
1000
988
1200
1218
1200
1188
1200
1188Payload
without
the driver
(kg)
925
913
1125
1143
1125
1113
1125
1113Towable load
with trailer
with brakes
(kg)
2000
2000
1998
1998
1968
1968
1937
1937
Short
wheelbase
(12 quintals)Short
wheelbase
(10 quintals)
High roof
(12 quintals)
Engine
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 194

195
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Long
wheelbase
(12 quintals)
EngineVersion
130 Multijet
Short
wheelbase
(10 quintals)
Long
wheelbase
(12 quintals)
High roof
(12 quintals)
Short
wheelbase
(12 quintals)
Towable load
with trailer
with brakes
(kg)
2000
2000
2000
2000
2000
2000
2000
2000
2000
2000
2000
2000 Unleaden
vehicle
weight
(kg)
1686
1698
1686
1698
1772
1784
1720
1732
1801
1813
1752
1764Max
admitted
load
(kg)
2698
2698
2898
2898
2780
2780
2932
2932
2880
2880
2954
2954Max
payload
(kg)
1012
1000
1212
1200
1008
996
1212
1200
1079
1067
1202
1200Payload
without
the driver
(kg)
937
925
1137
1125
933
921
1137
1125
1004
992
1127
1125 Number
of
seats
2
3
2
3
5
6
2
3
5
6
2
3
Short
wheelbase
(10 quintals)
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 195

Short
wheelbase
(12 quintals)
Engine
165 Multijet VersionTowable load
with trailer
with brakes
(kg)
2000
2000
2000
2000
2000
2000
1803
1803 Number
of seats
2
3
2
3
2
3
2
3
Short
wheelbase
(10 quintals)
Long
wheelbase
(12 quintals)
High roof
(12 quintals)
Unladen
vehicle
weight
(kg)
1731
1743
1731
1743
1761
1748
1772
1784Max
admitted
load
(kg)
2743
2743
2943
2943
2973
2973
2992
2932Max
payload
(kg)
1012
1000
1212
1200
1212
1125
1220
1148Payload
without the
driver
(kg)
937
925
1137
1125
1137
1050
1145
1073
VEHICLE
MAINTENANCE
IN AN
EMERGENCY
CORRECT USE
OF THE
VEHICLE
SAFETY
DEVICES
DASHBOARD
AND CONTROLS
INDEX
WARNING
LIGHTS AND
MESSAGES
196
TECHNICAL
SPECIFICATIONS
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 196