2013 FIAT SCUDO brake fluid

165
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
Make sure that the highly
corrosive brake fluid does not
drip onto the paintwork; if it
does, wash it off immediate-
ly with water.
Brake fluid is poisonous and
highly corrosive. In the event
of accidental contact, wash the parts
involved immediately with neutral
soap and water, then rinse thor-
oughly. Call the doctor immediately
if the fluid is swallowed.
WARNING
The symbol πon the con-
tainer indicates synthetic
brake fluid, distinguishing it from the
mineral kind. Using mineral fluids ir-
reversibly damages the special brak-
ing system rubber seals.
WARNING
POWER STEERING FLUID
With the vehicle on level ground, engine not
running and cold, check whether the oil lev-
el in the tank is between the MINand
MAXmarks on the tank fig. 12 and
fig. 13.
If oil is hot the level can also exceed the
MAXmark.
If required, top up with oil having the same
characteristics of the oil present in the sys-
tem.
fig. 12 - 90 Multijet versionsF0P0150mfig. 13 - 120 - 130 -
165 Multijet versionsF0P0151m
Power steering oil consump-
tion is extremely low. If the
fluid level needs topping up
again after a short period of
time, have the system checked for leak-
age at a Fiat Dealership.
Do not allow the power
steering fluid to touch the
hot parts of the engine: it is inflam-
mable.
WARNING
For the van outfitting it is
recommended to replace the
brakes liquid every two years.
WARNING
155-174 SCUDO LUM GB_153-172 Nuovo ScudoG9 GB 17/10/12 14.44 Pagina 165

170
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
WINDSCREEN/
REAR WINDOW
WIPERS
BLADES
Periodically clean the rubber part using
special products; TUTELA PROFES-
SIONAL SC 35is recommended.
Change the blades if the rubber edge is
warped or worn out. You should in any case
change them approximately once a year.
A few simple notions can reduce the pos-
sibility of damage to the blades:
❒ if the temperature fall below zero,
make sure that ice has not frozen the
rubber against glass. If necessary, thaw
using an antifreeze product;
❒ remove any snow from the glass: in ad-
dition to protecting the blades, this pre-
vents effort on the motor and over-
heating;
❒do not operate the windscreen wipers
on dry glass.
Driving with worn wiper
blades is a serious hazard,
because visibility is reduced in bad
weather.
WARNING
RUBBER HOSES
As far as the brake system and fuel rubber
hoses are concerned, carefully follow the
“Service schedule” in this section.
Indeed ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the hoses,
with possible leaks. Careful control is
therefore necessary.If the pressure is too low the
tyre overheats and this can
cause it serious damage.
WARNING
Do not cross switch the
tyres, moving them from the
right of the vehicle to the left and vice
versa.
WARNING
Never submit alloy rims to
repainting treatments re-
quiring to use temperatures exceed-
ing 150°C since the mechanical prop-
erties of the wheels could be im-
paired.
WARNING
155-174 SCUDO LUM GB_153-172 Nuovo ScudoG9 GB 17/10/12 14.44 Pagina 170

IDENTIFICATION DATA ................................................. 176
ENGINE CODES - BODY WORK VERSIONS .............. 179
ENGINE .................................................................................. 182
FUEL FEED/IGNIT ION ....................................................... 183
TRANSMISSION .................................................................. 183
BRAKES .................................................................................. 184
SUSPENSIO NS ......................................................................184
STEERIN G ..............................................................................184
WHEELS ................................................................................. 185
DIMENSIO NS ....................................................................... 188
SIZE OF LOADING CO MPARTMENT ..........................192
PERFORMA NCE .................................................................. 192
WEIGHTS AND T OWABLE LOADS ............................. 193
CAPACIT IES .......................................................................... 204
FLUIDS AND LU BRICANTS .............................................205
FUEL CONSUMPT ION ...................................................... 207
CO2EMISSIO NS ..................................................................2
T T E E C C H H N N I I C C A A L L S S P P E E C C I I F F I I C C A A T T I I O O N N S S
VEHICLE MAINTENANCE
IN AN EMERGENCY
CORRECT USE OF THE
VEHICLE
SAFETY DEVICES
DASHBOARD AND CONTROLS
INDEX
WARNING LIGHTS ANDMESSAGES
175
TECHNICALSPECIFICATIONS
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.45 Pagina 175
10

VEHICLE
MAINTENANCE
IN AN
EMERGENCY
CORRECT USE
OF THE
VEHICLE
SAFETY
DEVICES
DASHBOARD
AND CONTROLS
INDEX
WARNING
LIGHTS AND
MESSAGES
204
TECHNICAL
SPECIFICATIONS
120
Multijet
80
8
9
5.25
1.9
0.519
7.5 90
Multijet ()
80
8
8
6.2
1.7
0.519
7.5
CAPACITIES
Fuel tank: litresincluding a reserve of: litres
Engine cooling
system: litres
Engine sump and filter: litres
Gearbox/
differential casing: kg
Hydraulic brake circuit:
ABS devices (with ESP) kg
Windscreen, rear window
and headlight washer
fluid reservoir: litres
() Euro 4 - Euro 5
(*) Brake fluid shall be changed at least every 2 years (Van versions)Recommended fuels and
genuine lubricants
Diesel fuel for motor vehicles
(EN590 Specification)
Mixture of 50% water and
PARAFLU
UP
SELENIA WR
TUTELA CAR MATRYX
TUTELA TOP 4 (*)
Mixture of water and
TUTELA PROFESSIONAL
SC 35 165
Multijet
80
8
9
5.25
1.9
0.519
7.5 130
Multijet
80
8
9
5,25
1,9
0,519
7,5
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.46 Pagina 204

VEHICLE
MAINTENANCE
IN AN
EMERGENCY
CORRECT USE
OF THE
VEHICLE
SAFETY
DEVICES
DASHBOARD
AND CONTROLS
INDEX
WARNING
LIGHTS AND
MESSAGES
206
TECHNICAL
SPECIFICATIONS
Fluid and lubricant quality specifications
for correct vehicle operation
Synthetic-based oil, grade SAE 75W-85
that passes API GL4 and MIL-L-2105 D LEV specifications
Molibdenum organic disulphide, lithium soap based grease,
NLGI 2 consistency
Lubricant for power
That passes ATF DEXRON III specifications
Synthetic fluid for hydraulic and electro-hydraulic systems
Synthetic fluid, F.M.V.S.S. n 116, DOT 4, ISO 4925,
SAE J-1704, CUNA NC 956-01
Red protective with antifreeze action
based on inhibited monoethylen glycol
with organic formula based on O.A.T.,
that passes CUNA NC 956-16, astm d 3306 specifications
Mixture of alcohol, water and surfactants CUNA NC 956-11Applications
Mechanical gearbox and
differential
CV joints
Hydraulic power steering
Hydraulic power steering
Brake and
clutch hydraulic
controls
Cooling circuits, an-
tifreeze proportion:
50% down to –35°C
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems Use
Lubricantsand greases
for transmission
Brake fluids
Protective agent
for radiators
Windscreen/
rear window/
headlight washer
fluid Recommended
fluids and lubricants
TUTELA
MATRYX
TUTELA
STAR 500
TUTELA GI/E
TUTELA GI/R
TUTELA TOP 4
PARAFLU
UP
TUTELA
PROFESSIONAL
SC 35
175-210 SCUDO LUM GB_173-199 Nuovo ScudoG9 GB 17/10/12 14.46 Pagina 206

209
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Brakes
– emergency.......................................118
– fluid level......................................... 164
Bulb (replacement).............................. 141
Capacities ............................................ 204
Carrying children safely...................... 99
– ISOFIX child restraint
system (fitting)................................ 105
Central and side air vents .................. 28
Central locking .................................... 72
Changing a wheel................................. 137
Checking levels..................................... 160
Child restraint system label ............... 109
Cigar lighter .......................................... 67
Clock ...................................................... 16
Clutch..................................................... 183
CO2 emissions at exhaust ................. 210
Cruise control ...................................... 54
Dashboard ........................................... 5
Demisting
– rear windows.......................30-34-38
– side front windows.............28-32-38– windscreen ...........................28-32-38
Diesel filter
(water in diesel filter) ....................... 134
Dimensions ...........................................187
Dipped beam headlights
– bulb (replacement)........................ 143
– control ............................................. 47
Direction indicators
– control ............................................. 48
– front bulb replacement................. 144
– rear bulb replacement .................. 145
– side bulb replacement................... 144
Door locking/unlocking
remote control .................................. 7
Doors ..................................................... 69
Engine
Electric windows.................................. 74
Engine compartment........................... 160
Engine coolant level............................. 163
Engine oil consumption ...................... 162
Engine oil level...................................... 162
ABS ...................................................... 82
Accessories purchased by
the owner ........................................... 90
Air cleaner.............................................166
Air recirculation .........................31-36-41
Airbags .................................................. 108
– front passenger airbag and
child restraint systems ........109-110
– child restraint system label .......... 109
Ashtray................................................... 67
Battery
– economy mode .............................. 153
– fluid level......................................... 166
– jump starting ...................................136
– recharging........................................153
– specifications................................... 182
Bodywork
– maintenance.................................... 172
– versions............................................ 175
Bonnet.................................................... 76
Brake fluid level.................................... 164
Brake lights............................................ 145
I I
N N
D D
E E
X X
211-218 SCUDO LUM GB.qxd:200-208 Nuovo ScudoG9 ING 18-10-2012 8:30 Pagina 209

210
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Fuel consumption................................ 207
Fuel cut-off switch............................... 64
Fuel level gauge .................................... 14
Fuel
– fuel tank cap.................................... 91
– level gauge ....................................... 14
Fuses....................................................... 148
Gearbox
– using the manual gearbox ............ 119
Handbrake ........................................... 118
Hazard warning lights......................... 61
Head restraints..................................... 23
Headlight washer................................. 53
Headlights
– light beam direction ...................... 81
Heated rear window.................30-35-43
Heating and ventilation ...................... 27
Identification data................................ 176
In an emergency................................... 135
Instrument panel brightness
regulator .............................................15
Instrument panel.................................. 13
Interior fittings...................................... 65
Interiors .................................................174
Isofix (child restraint system) ............ 103Jack ......................................................... 138
Keys ....................................................... 7
Levels (checking)................................ 160
Load advice ...........................................79
Lubricants (specifications).................. 205
Main beam headlights
– bulb (replacement)........................ 143
– control ............................................. 47
Manual climate control....................... 31
Number plate lights........................... 146
On-board instruments...................... 14
Paintwork.............................................172
Performance .........................................192
Periodic checks.................................... 159
Pneumatic suspension ......................... 78
Power steering fluid level................... 165
Pretensioners........................................ 96
Radio system .......................................89
Rear view mirrors
– door mirrors .................................. 25 Engine oil
– consumption................................... 162
– level check....................................... 162
– technical specifications ................. 205
Engine start
– bump starting .................................137
– ignition device................................ 12
– jump starting ...................................136
– start procedure.............................. 116
– warming up the engine
once started....................................117
Engine
– identification code .........................179
– lubrication .......................................205
– supply............................................... 183
– technical data..................................175
EOBD (system) .................................... 87
Fiat CODE .......................................... 6
Fix&Go quick tyre repair kit ............. 140
Fix&Go................................................... 140
Fog lights/rear fog lights
– bulb replacement................142-143
– control ............................................. 47
Front passenger airbag and child
restraint systems .....................109-110
– child restraint system label .......... 109
211-218 SCUDO LUM GB.qxd:200-208 Nuovo ScudoG9 ING 18-10-2012 8:30 Pagina 210

211
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Speedometer........................................ 14
Starter.................................................... 183
Steering lock ......................................... 12
Steering wheel stalks........................... 47
Steering wheel ......................................24
Steering.................................................. 184
Storage compartment......................... 65
Sun visors .............................................. 68
– child restraint system label .......... 109
Suspension
(technical specifications) .................. 184
Symbols.................................................. 6
Technical data .....................................175
Third brake light.................................. 146
Top speeds ........................................... 192
Towable weights and loads ..............193
Towing the vehicle ............................. 154
Transmission ......................................... 183
Tyre inflation pressure (label)........... 187
Tyres....................................................... 187
– if a tyre is punctured..................... 137
“
Universal Isofix” child
restraint system................................. 103
– child restraint system label .......... 109“Universal” child restraint
system fitting...................................... 100
– child restraint system label .......... 109
“Universal” child restraint system.... 100
– child restraint system label .......... 109
Vehicle maintenance
– Heavy use of the vehicle ............. 159
– scheduled servicing....................... 156
– Scheduled servicing plan ............. 157
Ventilation ............................................. 27
Warning lights and messages.......... 125
When parked........................................ 118
Windows
– cleaning ............................................173
– sliding windows.............................. 69
Windscreen washer
– control ............................................. 50
– fluid level......................................... 164
Windscreen wiper jets....................... 172
Windscreen wiper
– blades .............................................. 170
– control ............................................ 50
– jets.................................................... 172
Windscreen/headlamp washer
fluid level ............................................. 164
Windscreen/rear window
wiper blades .......................................170 – interior rear view mirror............. 25
Rev counter .......................................... 14
Reversing lights..................................... 145
Roof lights ............................................. 60
– bulb (replacement)........................ 141
Roof rack/ski rack (setup).................. 77
Safety..................................................... 93
Seat belts
– general warnings............................ 97
– height adjustment ......................... 95
– maintenance.................................... 99
– use.................................................... 94
Seats
– cleaning ............................................174
– front................................................. 17
– rear................................................... 20
– seat arrangement........................... 22
Side bags ...............................................111
– child restraint system label .......... 109
– passenger side front airbag
and child restraint systems .......... 109
Side lights
– control ............................................. 47
– front bulb replacement................. 143
– rear bulb replacement .................. 145
Snow chains ..........................................123
Speed limiter .........................................57
211-218 SCUDO LUM GB.qxd:200-208 Nuovo ScudoG9 ING 18-10-2012 8:30 Pagina 211