2013 DODGE CHALLENGER engine overheat

WARNING!(Continued)
•A hot exhaust system can start a fire if you park
over materials that can burn. Such materials might
be grass or leaves coming into contact with your
exhaust system. Do not park or operate your ve-
hicle in areas where your exhaust system can con-
tact anything that can burn.
CAUTION!
• The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions control
device and may seriously reduce engine perfor-
mance and cause serious damage to the engine.
(Continued)
CAUTION! (Continued)
•Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition.
In the event of engine malfunction, particularly
involving engine misfire or other apparent loss of
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
7
MAINTAINING YOUR VEHICLE 461

NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately. To minimize the possibility of catalytic converter dam-
age:
•
Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
462 MAINTAINING YOUR VEHICLE

WARNING!
•The warning words “DO NOT OPEN HOT” on the
cooling system pressure cap are a safety precaution.
Never add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or remove the
cap to cool an overheated engine. Heat causes
pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the engine coolant (antifreeze) level is
adequate. With the engine OFF and cold, the level of the
engine coolant (antifreeze) in the bottle should be be-
tween the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing en-
gine coolant (antifreeze). Advise your service attendant
7
MAINTAINING YOUR VEHICLE 467

Driving to Achieve Maximum Fuel Economy......229
Electrical Power Outlets .....................198
Electric Remote Mirrors .....................110
Electronic Brake Control System ...............332
Electronic Power Distribution Center (Fuses) ......483
Electronic Speed Control (Cruise Control) ........173
Electronic Stability Control (ESC) ..............337
Electronic Throttle Control Warning Light ........213
Electronic Vehicle Information Center (EVIC) ......224
Emergency Deck Lid Release ..................45
Emergency, In Case of Freeing Vehicle When Stuck ................432
Hazard Warning Flasher ..................406
Jacking .............................. .418
Jump Starting ......................... .427
Overheating .......................... .406
Towing ............................. .435
Emergency Trunk Release ....................45 Emission Control System Maintenance
..........445
Engine ................................ .443
Air Cleaner .......................... .453
Block Heater ......................... .303
Break-In Recommendations .................96
Checking Oil Level ..................... .448
Compartment ......................... .442
Compartment Identification ................442
Coolant (Antifreeze) .....................463
Cooling ............................. .463
Exhaust Gas Caution .....................97
Fails to Start .......................... .301
Flooded, Starting ...................... .301
Fuel Requirements ..................... .378
Jump Starting ......................... .427
Oil................................. .448
Oil Filler Cap ......................... .451
Oil Selection .......................... .450
Oil Synthetic ......................... .452
524 INDEX

Overheating.......................... .406
Starting ............................. .294
Temperature Gauge ..................... .214
Engine Oil Viscosity ...................... .451
Engine Oil Viscosity Chart ...................451
Enhanced Accident Response Feature ............69
Entry System, Illuminated ....................22
Ethanol ............................... .380
Event Data Recorder ........................72
Exhaust Gas Caution ........................97
Exhaust System ...........................97
Exterior Folding Mirrors ....................110
Exterior Lighting ......................... .162
Exterior Lights .......................... .101
Filler Location Fuel ....................... .383
Filters Air Cleaner .......................... .453
Air Conditioning ...................... .287Engine Oil
........................... .452
Engine Oil Disposal .....................452
Flashers Hazard Warning ....................... .406
Turn Signal .......................... .101
Flash-To-Pass ........................... .167
Flooded Engine Starting ....................301
Fluid, Brake ............................ .498
Fluid Capacities ......................... .495
Fluid Leaks ............................ .101
Fluid Level Checks Automatic Transmission ..................473
Brake ............................... .469
Cooling System ........................ .463
Engine Oil ........................... .448
Fluids, Lubricants and Genuine Parts ...........496
Fog Lights ............................. .165
Folding Rear Seat ........................ .158
Freeing A Stuck Vehicle .....................432
10
INDEX 525

Overdrive OFF Switch..................... .317
Overhead Console ........................ .184
Overheating, Engine ...................... .214
Owner’s Manual (Operator Manual) .............4
Paint Care ............................. .475
Panic Alarm ..............................27
Parking Brake ........................... .326
Park Sense System, Rear ....................176
Passing Light ........................... .167
Personal Settings ......................... .236
Pets ....................................95
Pets, Transporting ..........................95
Placard, Tire and Loading Information ..........350
Power Brakes .............................. .329
Deck Lid Release ........................43
Distribution Center (Fuses) ................483
Door Locks ............................34 Mirrors
..............................110
Outlet (Auxiliary Electrical Outlet) ...........198
Seats ............................... .151
Steering ............................. .324
Sunroof ............................. .194
Windows ..............................41
Power Steering Fluid ...................... .498
Pregnant Women and Seat Belts ................58
Preparation for Jacking .....................421
Pretensioners Seat Belts ..............................57
Programmable Electronic Features .............236
Programming
Transmitters (Remote Keyless Entry). . .23
Radial Ply Tires ......................... .358
Radiator Cap (Coolant Pressure Cap) ...........466
Radio Operation ......................... .280
Radio Remote Controls .....................277
Rear Cupholder ......................... .202
532 INDEX