2013 CHRYSLER 200 CONVERTIBLE air condition

WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the EnvironmentalProtection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealer or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter – If Equipped
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
7
MAINTAINING YOUR VEHICLE 435

•Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine coolant (antifreeze)
performance, poor gas mileage, and increased emis-
sions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the brake system warning light indicates system fail-
ure.
Check the fluid level in the master cylinder when per-
forming underhood services.
7
MAINTAINING YOUR VEHICLE 447

passable in snow and ice and those that are sprayed on
trees and road surfaces during other seasons are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants,
road surfaces on which the vehicle is operated, extreme
hot or cold weather and other extreme conditions will
have an adverse effect on paint, metal trim, and under-
body protection.
The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion
resistance built into your vehicle.
What Causes Corrosion?
Corrosion is the result of deterioration or removal of
paint and protective coatings from your vehicle.
The most common causes are:
•Road salt, dirt and moisture accumulation.
•Stone and gravel impact.•Insects, tree sap and tar.
•Salt in the air near seacoast localities.
•Atmospheric fallout/industrial pollutants.
Washing
•Wash your vehicle regularly. Always wash your ve-
hicle in the shade using MOPARCar Wash or equiva-
lent, or a mild car wash soap, and rinse the panels
completely with clear water.
•If insects, tar, or other similar deposits have accumu-
lated on your vehicle, use MOPARSuper Kleen Bug
and Tar Remover or equivalent to remove.
•Use a high quality cleaner wax, such as MOPAR
Cleaner Wax or equivalent, to remove road film, stains
and to protect your paint finish. Take care never to
scratch the paint.
•
Avoid using abrasive compounds and power buffing that
may diminish the gloss or thin out the paint finish.
454 MAINTAINING YOUR VEHICLE

CAUTION!
•When installing the Integrated Power Module
cover, it is important to ensure the cover is properly
positioned and fully latched. Failure to do so may
allow water to get into the Integrated Power Mod-
ule, and possibly result in an electrical system
failure.
•When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days, you may want to take steps to preserve your
battery.
•Disengage the mini-fuse in the Power Distribution
Center labeled IOD (Ignition Off-Draw).
•Or disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
468 MAINTAINING YOUR VEHICLE

Required Maintenance Intervals.
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Change oil and filter.
•Rotate the tires.Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
•Inspect battery and clean and tighten terminals as
required.
•Inspect automatic transmission fluid if equipped
with dipstick.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
•Inspect engine cooling system protection and
hoses.
•Inspect exhaust system.
•Inspect engine air cleaner if using in dusty or
off-road conditions.
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 481

Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Replace cabin/air conditioning
filter.XXX X X X X
Replace spark plugs (2.4L En-
gine). **XX X X X
Replace spark plugs (2.4L PZEV
Engine Only). **X
Replace spark plugs (3.6L En-
gine). **X
Flush and replace the engine
coolant at 10 years or 150,000
miles (240,000 km) whichever
comes first.XX
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 483

About Your Brakes........................328
ABS (Anti-Lock Brake System)................331
Accessory Delay, Power......................12
Adding Engine Coolant (Antifreeze)............443
Adding Fuel.............................379
Adding Washer Fluid......................438
Additives, Fuel...........................373
Airbag..................................57
Airbag Deployment........................65
Airbag Light.............................62
Airbag Maintenance........................66
Airbag, Side..............................60
Airbag, Window (Side Curtain)................61
Air Cleaner, Engine (Engine Air Cleaner Filter). . . .432
Air Conditioner Maintenance.................434
Air Conditioning..........................285
Air Conditioning Controls...................285
Air Conditioning Filter.....................297
Air Conditioning, Operating Tips..............298Air Conditioning Refrigerant.................434
Air Conditioning System....................285
Air Pressure, Tires.........................351
Alarm System (Security Alarm)................18
Alterations/Modifications, Vehicle...............7
Antenna, Satellite Radio.....................273
Antifreeze (Engine Coolant)..................442
Disposal.............................445
Anti-Lock Brake System (ABS)................331
Anti-Lock Warning Light....................331
Anti-Theft Security Alarm (Theft Alarm)..........18
Appearance Care.........................453
Ashtray................................205
Assistance Towing.........................143
Auto Down Power Windows..................36
Automatic Dimming Mirror..................126
Automatic Door Locks......................33
Automatic Oil Change Indicator...............227
Automatic Temperature Control (ATC)..........290
498 INDEX

Fabric Care..............................457
Filler Location Fuel........................220
Filters
Air Cleaner...........................432
Air Conditioning.......................297
Automatic Transmission..................453
Engine Oil............................432
Engine Oil Disposal.....................432
Flashers................................398
Hazard Warning.......................398
Turn Signal............................95
Flash-To-Pass............................181
Flexible Fuel Vehicles
Cruising Range........................378
Engine Oil............................377
Fuel Requirements......................375
Maintenance..........................378
Replacement Parts......................378
Starting..............................378Fluid Capacities..........................475
Fluid Leaks..............................95
Fluid Level Checks
Automatic Transmission..................451
Brake...............................447
Cooling System........................442
Engine Oil............................429
Power Steering........................327
Fluids, Lubricants and Genuine Parts...........476
Fog Lights..............................181
Fog Light Service.........................472
Freeing A Stuck Vehicle.....................415
Fuel...................................370
Adding..............................379
Additives............................373
Clean Air............................371
Ethanol..............................371
Filler Cap (Gas Cap)
....................220
Filler Door (Gas Cap)....................220
10
INDEX 503