2013 AUDI A8 radiator

24 2 Ch ecking and filling
scalding from hot coolant by following
these steps .
- Turn off the eng ine and a llow it to cool
down.
- Protect your face, hands and arms from escaping flu id and steam by cover ing
the cap with a large, thick rag .
- Turn the cap slowly and very carefully
i n a counter-clockwise direction while
apply ing l ight, downwa rd press ure on
the top of the cap .
- To avo id being burned, do not spi ll an­
tifreeze or coolant on the exhaust sys­
tem or hot engine parts . Under certain
conditions, the ethylene glyco l in en­
gine coolant can catch f ire .
- Antifreeze is poisonous . Always store an­
tifreeze in its or iginal container and we ll
out of the reach of children.
- If you drain the coolant, it must be
caught and safely stored in a proper con­
tainer clear ly marked "poison".
@ Note
- Coolant po llutes the env ironment and
could cause an engine fire . Excess coo l­
ant will be forced out through the pres­
sure re lief valve in the cap when the en­
gine becomes hot.
- If, in an emergency, only water can be
added, the correct ratio between water
and antifreeze
c::> page 240 must be re­
stored as soon as possible .
@ For the sake of the environment
Drained coolant should not be re used. Al­
ways dispose of used coolant while observ­
ing all environmental regulat ions .
Radiator fan
The radiator fan switches on automatically by
itself
T he radiator fan is driven by the engine via the
V-be lt . The viscous clutch regulates the speed
of the fan accord ing to the temperature of the
coolant. An a
uxiliary electric radiator fan* switches on
and off depend ing on coolant temperature
and other vehicle operat ing condit ions .
After yo u sw itch the engine off, the aux iliary
f an can continue running for up to 10 minutes
- eve n wit h the ignit ion off. It can even switc h
on again later by itself
c::> &. , if
- t he tempe rature of the engine coo lant rises
due to the heat build -up from the engine in
the engine compartment, or
- the engine compa rtment heats up because
the vehicle is parked in i ntense sunlight.
_& WARNING
- To reduce the risk of personal injury nev­
er touch the radiator fan.
- The auxiliary electric fan is temperat ure
controlled and can sw itch on suddenly
even when the engine is not running.
- The a uxiliary radiator fan sw itches on au­
tomatically when the engine coo lant
reaches a certai n temperature and will
continue to run until the coolant temper­
ature drops .
Brake fluid
Checking brake fluid level
The brake fluid level can be checked with a
quick glance.
F ig . 201 E ngin e compart men t: cover on the brake fluid
r eservo ir
Before you check a nyth ing in the engine com­
partment,
always read and hee d all WARN ­
INGS c::> .&. in Working in the engine compart-
ment on page 232. .,..

complexity of today's automobi les, have
steadi ly reduced the scope of maintenance
and repairs which can be carried out by vehicle
owners.
Also, safe ty and e nvir onm en tal con­
cerns place very strict limits on the na ture of
repairs and adjustments to engine and trans ­
miss io n pa rts which an owner can perform .
Maintenance, adjustments and repairs usua lly
require special tools, testing devices and oth­
er equipment avai lab le to specially trained
workshop personnel in order to assure prope r
performance, reliab ility and safety of the vehi­
cle and its many systems .
Improper ma intenance, adjustments and re ­
pa irs can impair the operation and reliability
of your vehicle and even void your vehicle war­ ranty. The refo re, p roof of servici ng in accord­
ance w ith the maintenance sched ule may be a
condition for upholding a poss ible war ranty
claim made within the warranty period.
Above all, operational safety can be adversely
affected, crea ting unnecessary risks for you
and your passengers.
If in doubt about any servicing, have it done
by your authorized Audi dealer or any other
properly equipped and q ualified workshop .
We strong ly urge you to give you r a uthorized
Audi dealer the opportunity to perform all
schedu led maintenance and necessary repairs .
Your dea ler has the facilities, or iginal parts
and trained spec ialists to keep your vehicle
running properly.
Performing limit ed m aintenance you rself
The following pages describe a limited num­
ber of procedures which can be performed on
your vehicle with ordinary too ls, should the
need arise and trained personnel be unavaila­
b le. Before performing any of these proce­
dures, always thoroughly read all of the app li­
cable text and carefully follow the instruc­
tions given . Always rigorously obse rve the
WARNINGS provided .
Before you check anything in th e engine
compartment, a lway s re ad and heed all
Con sumer In formation 297
WARNINGS ¢ & and ¢ & in Working in the
engine comportment on page 232 .
A WARNING
-Ser ious personal injury may occur as a re­
sult of improperly performed mainte­ nance, adjustments or repa irs.
-Always be extremely careful when work­
ing on the vehicle. Always follow com­
mon ly accepted safety practices and gen­
eral common sense . Never r isk personal
lnJU ry .
- Do not attempt any of the ma intenance ,
checks or repairs descr ibed on the fol­
lowing pages if you are not fully fam iliar
wit h these or othe r pro cedures with re­
spect to t he veh icle, or are uncerta in how
to p roceed .
- Do not do any work without the proper
too ls and equipment. Have the necessary
work done by your authorized A udi deal ­
er or another proper ly equipped and
qualified workshop .
- The engine compartment o f any motor
veh icle is a potentially hazardous area.
Never reach into the area around or
touch the radiator fan. It is temperature
contro lled and can switch on suddenly -
even when the engine is
off . The radiator
fan switches on automat ically when the
coo lant reaches a certai n temperature
and will cont inue to run until the coo lan t
temper ature drops.
- Always sw itch
off the ignition before any­
one gets under the vehicle.
- Always support your veh icle with safety
stands if it is necessary to work under­
neath the vehicle . The j ack s upplied with
the vehicle is not adequate for this pur­
pose and cou ld collapse causing serio us
personal i njury .
- I f you must work unde rneath the vehicle
with the wheels on the ground, a lways
make sure the vehicle is on leve l ground,
that the wheels are a lways securely
blocked and that the engine cannot be
started.
•
•

starting .... ................ ... .... 83
Starting with jumper cables . ... .. .. . 284
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Engine compartment ....... .. .. .. .. . 234
C losing the hood ......... .. .. .. .. . 233
Opening the hood .............. .. . 232
Safety instructions ................. 232
Working in the engine compartment .. 232
Engine coolant . ........... .. .. .. ... 240
Adding coolant ........... .. .. .. .. . 241
Checking the engine coolant level .. .. . 240
Expansion tank .............. ... ... 240
Malfunction symbol .......... ... .. .. 16
Radiator fan ............. .... .. .. . 242
Temperature gauge ....... .. .. .. .. .. 10
Engine oil ... ................ ... ... 235
Adding .... ................ ... ... 238
Additives ... ................ ... ... 238
Changing .. ............. .... .. ... 239
Checking oil level ......... .. .. .. .. . 238
Checking the engine oil level .. .. .. .. . 237
Consumption ............... .... .. 238
Indications and conditions requiring ex-
tra checking ............. .... .. ... 23 7
I ndicator light . . . . . . . . . . . . . . . . . . . . . 17
O il consumption .......... .. .. .. .. . 236
Oil grades .. ................ ... ... 235
Oil level symbol ................ .... 20
Pressure malfunction ......... ..... .. 17
Recommended oil check intervals .. .. . 237
Sensor defective . . . . . . . . . . . . . . . . . . . . 21
Specification and viscosity .. .. .. .. .. . 235
Engine sound ................ ... ... 109
Engine speed limitation ....... .. .. .. .. 20
Engine start-stop mode
refer to Start-Stop-System . .. .. .. .. .. 89
Engine start system (indicator lights) . ... 17
Entry assistance . . . . . . . . . . . . . . . . . . . . . 63
Environment Break-in period ........... .. .. .. ... 206
Catalytic converter . ....... .. .. .. .. . 207
Disposing of your vehicle battery .... . 247
Driving at high speeds ...... ... ... .. 209
Driving to minimize pollution and noise 208
Fuel ... .. .. .. ............. .. .. ... 230
Fuel economy ............ .... .. .. . 208
Leaks under your vehicle ............ 232
Letting the vehicle stand and warm up. 209
Index 305
Proper disposal of drained brake fluid . 243
Proper disposal of drained engine cool-
ant ....... ... .. .. ............... 241
Proper disposal of drained engine
oil . . . . . . . . . . . . . . . . . . . . . . . . . 238, 239
Recycling used engine oil ............ 238
Unleaded fuel .. .. .. . .. .... ........ 228
What should I do with an old battery? . 247
EPC
refer to E lectronic power control (EPC) . 20
ESC
refer to Electronic Stabilization Control
(ESC) ............................ 198
ESC (Electronic Stab ilization Control)
Warning/ind icator lights ............ . 18
Event Data Recorder (EDR) ............ 198
Exhaust tail pipes .. .. .............. . 222
Expansion tank .. .. ................. 240
Exterior lighting . .. ................. . 45
Exterior mirrors Adjusting . . . . . . . . . . . . . . . . . . . . . . . . . 54
Dimming ... ... .... ................ 54
Heating ... .. .. .. .... ............. . 54
Exterior temperature display ........ .. . 23
F
Fastening
Booster seats .. .. .... ......... .... 184
Convertib le child safety seats .... .. .. 183
Infant seats . . . . . . . . . . . . . . . . . . . . . . 182
Floor mats . . . . . . . . . . . . . . . . . . . . . . . . . 140
Fo lding table .. .. .. .. ............... . 68
Foot pedals ... .. .... ... .......... .. 139
For the sake of the environment Gasoline fumes and the environment .. 230
Reducing engine noise by ear ly upshift-
ing ....... .. .. .. .. .. ........... .. . 10
Refueling . .. .. .. .. ............... 230
Saving fuel by early upshifting ....... . 10
Four zone automatic climate control ..... 79
Front airbags Description .. .. .. ................. 156
How they work . .. ................. 161
Frontal collisions and the laws of physics 145
Front passenger seat adjustment . . . . . . . 63
•
•