2013 Abarth 500 check engine

133
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
IMPORTANT If the charge level remains
for a long time under 50%, the battery is
damaged by sulphation, reducing its ca-
pacity and starting attitude.
The battery will also be more at risk of
freezing (e.g. already at -10°C). Refer to
the paragraph “Car inactivity” in “Starting
and driving” if the car is left parked for a
long time.
If after buying the car, you want to install
electric accessories which require per-
manent electric supply (alarm, etc.) con-
tact Abarth Dealership whose qualified
personnel, in addition to suggesting the
most suitable devices, will evaluate the
overall electric absorption, checking
whether the car’s electric system is capa-
ble of withstanding the load required, or
whether it should be integrated with a
more powerful battery.
Since these devices continue absorbing en-
ergy even when the ignition key is off, they
gradually run down the battery. USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and length-
en its life, observe the following indica-
tions:
❒when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
❒switch off all lights inside the car: the
car is however equipped with a system
which switches all internal lights off au-
tomatically;
❒do not keep accessories (e.g. sound sys-
tem, hazard lights, etc.) switched on for
a long time when the engine is not run-
ning;
❒before performing any operation on the
electrical system, disconnect the bat-
tery negative cable;
❒battery terminals shall always be per-
fectly tightened. Incorrect assembly of electric
and electronic devices may
cause severe damage to your
car. Go to a Abarth Dealer-
ship if you want to install accessories
(alarms, mobile phone, etc.): they will
suggest the most suitable devices and
advise you if a higher capacity battery
needs to be installed.
Batteries contain substances
that can be very dangerous
for the environment. t is ad-
visable to have the battery
changed by a Abarth Dealership where
it will be disposed of according to the
law.
If the vehicle must remain
unused for a long time at
very low temperature, remove the
battery and carry it to a warm place,
to avoid freezing.
WARNING
When you must perform any
operation on the battery or
near it, always protect your eyes with
the special goggles.
WARNING
123-140 ABARTH 500 1ed GB:123-140 ABARTH 500 GBdx 24-05-2012 10:01 Pagina 133

137
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
BODYWORK
PROTECTION FROM
ATMOSPHERIC AGENTS
The main causes of corrosion are the fol-
lowing:
❒atmospheric pollution;
❒salty air and humidity (coastal areas, or
hot humid climates);
❒seasonal environment conditions.
Not to be underestimated is also the abra-
sive action of wind-borne atmospheric
dust and sand and mud and gravel raised
by other cars.
On your car, Abarth implemented the
best manufacturing technologies to effec-
tively protect the bodywork against cor-
rosion.
These are the most important:
❒painting products and systems which
give the car particular resistance to cor-
rosion and abrasion;
❒use of galvanised (or pre-treated) steel
sheets, with high resistance to corro-
sion;
❒spraying the underbody, engine com-
partment, wheelhouse internal parts
and other parts with highly protective
wax products; SPRAY NOZZLES
Windscreen washer fig. 7
If the jet of fluid is inadequate, firstly check
that there is fluid in the reservoir: see
“Checking fluid levels” in this section).
Then check that the nozzle holes are not
clogged, if necessary use a needle.
The windscreen jets are directed by ad-
justing the angle of the nozzles.
Fluid jets shall be directed at about
1/3height from the window upper edge.
IMPORTANT For the versions with sun-
roof, before operating the front sprays,
ensure that the sunroof is closed.Rear window wiper fig. 8
Rear window washer jets are fixed.
The nozzle holder is on the rear window.
fig. 7F0S122Abfig. 8F0S123Ab
123-140 ABARTH 500 1ed GB:123-140 ABARTH 500 GBdx 24-05-2012 10:01 Pagina 137

139
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
INTERIORS
Periodically check that water is not trapped
under the mats (due to water dripping off
shoes, umbrellas, etc.) which could cause
oxidisation of the sheet metal.
Replace the worn carpet mats, if present,
with genuine products or however that
remain securely fastented to the passen-
ger compartment carpet. It is not advis-
able to use non genuine mats that could
move whilst driving. Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketenes (e.g.: ace-
tone) for cleaning front headlight plastic
lens. Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the rear win-
dow should be wiped gently with a cloth
in the direction of the filaments to avoid
damaging the heating device.
Engine compartment
At the end of each winter, thoroughly
wash the engine compartment, taking care
to avoid directly hitting with the water jet
the electronic control units and the re-
lay/fuse control unit on the left side of the
engine compartment (running direction).
Have this operation performed at a spe-
cialised workshop.
IMPORTANT Perform this operation on
a cold engine and with the key at STOP.
After the washing operation, make sure
that the various protections (e.g. rubber
caps and guards) have not been removed
or damaged.
Never use flammable prod-
ucts, such as petrol ether or
rectified petrol to clean inside the car.
The electrostatic charges which are
generated by rubbing during the
cleaning operation may cause a fire.
WARNING
123-140 ABARTH 500 1ed GB:123-140 ABARTH 500 GBdx 24-05-2012 10:01 Pagina 139

162
WARNING
LIGHTS AND
MESSAGES
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Rear fog lights ...................................... 38
– activation ........................................ 38
– bulb replacement .......................... 113
Rear head restraints............................ 24
Rear screen washer ........................... 36
– activation ........................................ 36
– fluid level ........................................ 130
Rear screen wiper .............................. 36
– activation ........................................ 36
– brushes ...........................................136
– sprayers .......................................... 137
Rear seats ............................................. 24
Rear view mirrors .............................. 26
– exterior .......................................... 26
– interior ........................................... 26
Refuelling the car ................................ 62
Rev counter ......................................... 10
Reversing light ..................................... 113
Roof rack/ski rack .............................. 50
Rubber hoses ....................................... 135
Safety ................................................... 63
Saving on fuel ....................................... 82
SBR (system) ........................................ 64
Seat adjustment ................................... 23
Seat belts ............................................... 64
– warnings .........................................65
– use of .............................................. 64
– load limiters ................................... 65
– maintenance .................................. 67
– seatbelt tensioners ....................... 65Seatbelt tensioners ............................. 65
Seats ...................................................... 23
Sidelights ............................................... 34
– rear bulb replacement ................. 113
Snow chains ......................................... 85
Spark plugs ............................................ 145
Speedometer (tachometer) ............... 10
Sport functions activation ................. 37
Starting the engine ........................80-96
– jump starting with battery .......... 96
– bump starting ............................... 97
– ignition switch .............................. 7
– how to warm up the engine
that has just started ..................... 81
– engine turn off ............................... 81
Starting the engine and driving ........ 79
Steering ................................................. 147
Steering column lock ......................... 7
Steering wheel adjustment ............... 25
Storing the car .................................... 85
Sun roof ................................................ 41
– emergency action ......................... 43
Sun visors ............................................. 39
Suspension ........................................... 147
Symbols ................................................. 4
Tachometer (speedometer) ........... 10
TTC System ....................................... 54
Technical data ..................................... 141
Main beam headlights ....................... 34
– activation ........................................ 34
– flashing the headlights .................. 34
– bulb replacement .......................... 112
Manual climate control system ........ 29
Motor oil
– technical specifications ................ 155
– consumption .................................. 129
– checking fluid levels ...................... 129
MSR (system) .......................................54
Multifunctional and reconfigurable
multifunctional display...................... 11
Number plate light ............................ 114
Oddment compartment .................. 39
Paint ..................................................... 138
Parking .................................................. 81
Parking sensors .................................... 57
Particulate Filter (DPF) ...................... 132
Performance ........................................ 152
Plates...................................................... 142
Power supply ....................................... 146
Power windows .................................. 44
Protecting the environment ............. 62
Radio .................................................... 60
Radio and cell phone transmitters .. 61
Radio frequency remote control .... 159
160-168 ABARTH 500 1ed GB:160-170 ABARTH 500 GB 24-05-2012 14:39 Pagina 162

FUEL CAPACITIES (litres)
1.4 TB BZ ABARTH
Tank capacity 35
Reserve5
The car should only be refuelled with unleaded petrol with an octane rating (RON) of at least 95 (Specification EN228)
Fiat Group Automobiles S.p.A. - Parts & Services - Technical Services - Service Engineering
Largo Senatore G. Agnelli, 3 - 10040 Volvera - Torino (Italia) Print N. 603.99.228 - /2012 - Edition
ENGINE OIL CHANGE
1.4 TB BZ ABARTH
Engine sump 2.75
Engine sump and filter 2.90
COLD INFLATION PRESSURE (bar)
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm.
Recheck pressure value with cold tyres.
Tyres Medium load * Full load
Front rear Front Rear
195/45 R16 84 V XL 2.3 2.1 2.6 2.4
205/40 R17 84 W XL 2.3 2.1 2.6 2.4
* At speeds above 160 km/h, use the inflation pressures for the maximum load conditions.
160-168 ABARTH 500 1ed GB:160-170 ABARTH 500 GB 24-05-2012 14:39 Pagina 168
112