2012 VOLVO XC60 headlight bulb

08 Maintenance and specifications
Replacing bulbs
08
322* Option/accessory, for more information, see Introduction.
Introduction
All bulb specifications are listed on page 328.
The following bulbs should only be replaced by
a trained and qualified Volvo service techni-
cian:
•Dome lighting, reading lights
•Glove compartment lighting
•Footwell lighting
•Turn signals in the door mirrors
•Approach lighting in the door mirrors
•Brake lights/rear fog light/taillights
•Rear parking lights
•Active Bending Lights
•LED bulbs
See page 328 for a list of bulb specifications.
NOTE
For information regarding any other bulbs
not mentioned in this section, please con-
tact your Volvo retailer or a trained and
authorized Volvo service technician.
WARNING
•The engine should not be running when
changing bulbs.
•If the engine has been running just prior
to replacing bulbs in the headlight hous-
ing, please keep in mind that compo-
nents in the engine compartment will be
hot.
WARNING
•Active Bending Lights* – due to the high
voltage used by these headlights, these
bulbs should only be replaced by a
trained and qualified Volvo service tech-
nician.
•Turn off the lights and remove the
remote key from the ignition before
changing any bulbs.
Headlight housing
The entire headlight housing must be lifted out
when replacing all front bulbs.
CAUTION
Never touch the glass of bulbs with your fin-
gers. Grease and oils from your fingers
vaporize in the heat and will leave a deposit
on the reflector, which will damage it.

08 Maintenance and specifications
Replacing bulbs
08

323
NOTE
•Always switch off the ignition before
starting to replace a bulb.
•The optional Active Bending Light bulbs
contain trace amounts of mercury.
These bulbs should always be disposed
of by a trained and qualified Volvo serv-
ice technician.
Removing the headlight housing1. Switch off the ignition by briefly pressing
the START/STOP ENGINE button.
2. Remove the remote key from the ignition
slot
1.
3. (Upper illustration under "Headlight hous-
ing")
Withdraw the headlight housing's lock-
ing pins.
Pull the headlight housing straight out.
CAUTION
When disconnecting the connector, pull on
the connector itself and not on the wiring.
4. (Lower illustration under "Headlight hous-
ing")
Unplug the wiring connector by holding
down the clip with your thumb.
Pull out the connector with the other
hand.
5. Lift out the housing and place it on a soft
surface to avoid scratching the lens.
6. Replace the defective bulb(s).
Reinserting the headlight housing
When reinserting the housing, be sure that the
long locking pin (to the left in the illustration) is
securely in place in both of its retaining clamps.1. Plug in the connector until it clicks into
place.
2. Reinstall the headlight housing and locking
pins. Check that they are correctly
inserted. The headlight housing must be
properly inserted and secured in place
before the lighting is switched on or the
remote key is inserted into the ignition slot.
3. Check that the lights function properly.
The headlight wiring must be connected and
the housing must be securely in place before
the ignition is switched on.
Removing the cover to access the
bulbs
1Does not apply to vehicles with the optional keyless drive.

08 Maintenance and specifications
Replacing bulbs
08
324
NOTE
Before starting to replace a bulb, see
page 322.
1. Open the retaining clamps by pressing
them to the sides.
2. Pull the cover straight out.
Reinstall the cover in the reverse order.
Low beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 322).
2. Remove the cover over the bulbs (see
page 323).3. Unplug the connector from the bulb.
4. Remove the bulb by pressing the holder
downward.
5. Press the new bulb into the socket until it
snaps into place. It can only be secured in
one position.
6. Put the cover back into position and rein-
stall the headlight housing.
High beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 322).
2. Remove the cover over the bulbs (see
page 323).3. Remove the bulb by turning it counter-
clockwise and pulling it straight out.
4. Remove the connector from the bulb.
5. Press the new bulb into the socket and turn
it clockwise to put it in place. It can only be
secured in one position.
6. Reinsert the bulb holder into the headlight
housing.
7. Put the cover back into position and rein-
stall the headlight housing.
Extra high beam2
1. Remove the headlight housing from the
vehicle (see page 322).
2Models with optional Active Bending Lights only.

08 Maintenance and specifications
Replacing bulbs
08

325
2. Remove the cover over the bulbs (see
page 323).
3. Disconnect the wiring connector from the
bulb holder.
4. Remove the bulb holder from the headlight
housing by pulling it straight out.
5. Insert a new bulb in the holder until it snaps
in place. It can only be inserted in one way.
6. Press the bulb holder into position in the
headlight housing.
7. Reconnect the wiring connector to the bulb
holder.
8. Put the cover back into position and rein-
stall the headlight housing.
Turn signals
1. Remove the headlight housing from the
vehicle (see page 322).
2. Remove the bulb holder by turning it coun-
terclockwise and pulling it out of the head-
light housing.
3. Pull out the holder to access the bulb.
4. Remove the burned out bulb by pressing it
in slightly and turning it counterclockwise.
5. Press the new bulb into the holder and turn
it clockwise.
6. Reinsert the bulb holder into the headlight
housing and turn it clockwise.
7. Reinstall the headlight housing.
Side marker lights
NOTE
Before starting to replace a bulb, see
page 322.
1. Remove the headlight housing from the
vehicle (see page 322).
2. Remove the bulb holder by turning it coun-
terclockwise and pulling it out of the head-
light housing.
3. Pull out the burned out bulb and install a
new one. It can only be inserted in one
position.
4. Reinsert the bulb holder into the headlight
housing and turn it clockwise.
5. Reinstall the headlight housing.

10 Index
10
365
general information............................. 119
Hill Descent Control............................ 125
warning light......................................... 78
Bulbs
cargo area lighting.............................. 327
headlights...........................322, 323, 324
introduction......................................... 322
license plate lights.............................. 327
side marker lights...............................325
specifications...................................... 328
taillight................................................ 326
C
Camera, Park Assist................................ 190
Capacity weight....................................... 295
Cargo area
changing bulbs................................... 327
steel grid............................................. 275
Cargo area cover..................................... 275
Cargo area net......................................... 276
Catalytic converter................................... 269
Cell phone, hands-free connection......... 233
Cell phone voice control.......................... 241
Central locking system, introduction......... 56Chains...................................................... 298
Check engine light..................................... 76
Child restraints
recalls and registration......................... 39
Child restraint systems.............................. 40
booster cushions.................................. 46
convertible seats.................................. 44
infant seats........................................... 42
ISOFIX/LATCH anchors........................ 47
top tether anchors................................ 48
Child safety................................................ 37
booster cushions.................................. 46
child restraint systems.......................... 40
convertible seats.................................. 44
infant seats........................................... 42
Child safety locks...................................... 52
City Safety™............................................ 167
Climate system........................................ 144
air distribution............................. 140, 146
air vents.............................................. 141
Interior Air Quality System.................. 140
introduction......................................... 139
passenger compartment filter............ 139
refrigerant........................................... 139
Clock, setting............................................. 80
Cold weather driving................................ 264Collision warning system.................172, 173
Compass in rearview mirror..................... 105
Conserving electrical current................... 263
Controls, center console.......................... 256
Convertible seats....................................... 44
Coolant............................................320, 357
Cooling system, general information....... 263
Courtesy lighting.................................. 95, 96
Crash mode............................................... 36
Cruise control..................................152, 153
adaptive.............................................. 154
Curb weight............................................. 295
Current, conserving................................. 263
D
Defroster.................................................. 144
Detachable key blade................................ 61
Dimensions.............................................. 352
Disconnecting the front passenger’s air-
bag....................................................... 26, 27
Dome lighting....................................... 95, 96
Door mirrors............................................. 103

10 Index
10
367
H
Hazard warning flashers............................ 94
HD digital radio........................................ 216
Headlights
Active Bending Lights........................... 93
changing bulbs...........................323, 324
high/low beams.................................... 92
high beam flash.................................... 92
Headlight washers..................................... 99
Headphones............................................ 246
Head restraints, rear seat.......................... 87
Heated oxygen sensors........................... 270
Heated rear seats.................................... 143
High beams................................................ 92
indicator light........................................ 77
Hill Descent Control................................. 125
Hoisting the vehicle.................................315
HomeLink
® Wireless Control System...... 109
Home safe lighting..................................... 96
Hood, opening/closing............................317
Horn........................................................... 91
I
Ignition modes........................................... 82
Immobilizer................................................ 57
Important information.................................. 8
Indicator lights.........................75, 76, 77, 78
Infant seats................................................ 42
Inflatable Curtain........................................ 32
Inflation pressure..................................... 289
Inflation pressure table............................291
Information and warning symbols, table
of.............................................................. 359
Information lights.....................75, 76, 77, 78
Information symbol.................................... 77
Infotainment system................................ 204
AUX/USB sockets............................... 227
Bluetooth
Ÿ devices............................. 230
Bluetooth® hands-free system........... 233
general functions................................ 211
getting started.................................... 206
media player....................................... 223
menus................................................. 256
radio functions.................................... 214
rear seat entertainment....................... 245rear seat entertainment system, remote
control................................................. 254
sound settings.................................... 212
voice control....................................... 241
Inspection readiness................................ 315
Instrument lighting..................................... 92
Instrument overview............................74, 75
Instrument panel...................................... 131
Integrated two-stage booster cushion...... 49
Interior Air Quality System....................... 140
Interior lighting..................................... 95, 96
iPodŸ connector (audio system)............. 227
ISOFIX/LATCH anchors............................. 47
J
Jack
attaching.............................................306
location of........................................... 306
Jump starting........................................... 114