2012 VOLVO V60 headlamp

08 Maintenance and service
Lamps
08
322
Direction indicators/flashers
1. Detach the headlamp.
2. Detach the cover by pulling it straight out.
3. Pull the bulb holder in order to extract the
bulb.
4. Press and simultaneously turn the bulb to
detach it.
Reinstall the parts in reverse order.
Lamp housing, rear
The reversing, fog and direction indicator bulbs
in the rear lamp cluster are replaced from inside
the cargo area.
1. Open the panel.
2. Remove the insulation that is fitted in front
of the bulb holder by pulling it straight out.
3. Press down the catch and pull out the bulb
holder.
4. Remove the blown bulb by pressing it in
and turning anticlockwise.
5. Fit a new bulb, press down and turn clock-
wise.
6. Press down the catch when the bulb holder
is refitted.7. Refit the insulation and panel.
NOTE
If an error message remains after the broken
bulb has been replaced then we recom-
mend that you visit an authorised Volvo
workshop.
Location of rear bulbs
Lamp lens, right-hand side
Brake light (LED)
Direction indicators
Reversing lamp
Rear fog lamp (driver's side)
ProCarManuals.com

08 Maintenance and service
Wiper blades and washer fluid
08
326
Replacing the wiper blades, rear window
1. Fold out the wiper arm.
2. Grip the inner section of the blade (by the
arrow).
3. Turn anticlockwise to use the blade's end
position against the wiper arm as a lever to
detach the blade more easily.
4. Press the new wiper blade into position.
Check that it is firmly installed.
5. Lower the wiper arm.
CleaningFor cleaning wiper blades and windscreen, see
page 344 and onwards.
IMPORTANT
Check the wiper blades regularly.
Neglected maintenance shortens the serv-
ice life of the wiper blades.
Filling washer fluid
The windscreen and headlamp washers share
a common reservoir.
IMPORTANT
Use washer fluid with antifreeze during the
winter to avoid freezing in the pump, reser-
voir and hoses.
For capacities, see page 361.
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.335
General fuses, engine compartmentOn the inside of the cover there are tweezers
that facilitate the procedure for the removal
and fitting of fuses.
Positions (see preceding illustration)Engine compartment, upper
Engine compartment, front
Engine compartment, lower
These fuses are all located in the engine com-
partment box. The fuses in (C) are located
under (A).
On the inside of the cover is a label that shows
the location of the fuses.
•Fuses 1-7 and 42-44 are of the "Midi Fuse"
type and must only be replaced by a work-
shop
1.
•Fuses 8-15 and 34 are of the "JCASE" type
and should be replaced by a workshop1.
•Fuses 16-33 and 35-41 are of the "Mini
Fuse" type.
FunctionA
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
A
50
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox50
Primary fuse for central electri-
cal unit in cargo areaA60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
--
PTC element, air preheater*A100
Headlamp washers*20
Windscreen wipers30
FunctionA
Parking heater*25
Ventilation fanA40
--
ABS pump40
ABS valves20
--
Headlamp levelling*, Active
Xenon headlamps - ABL*10
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox20
ABS5
Speed related power steering*5
Engine control module, Trans-
mission control module, Air-
bags10
Heated washer nozzles*10
1An authorised Volvo workshop is recommended.
ProCarManuals.com

08 Maintenance and service
Fuses
08
336* Option/accessory, for more information, see Introduction.
FunctionA
Relay coil, relay, vacuum pump
(5-cyl. petrol)5
Headlamp control5
--
--
--
Internal relay coils5
Auxiliary lamps*20
Horn15
Relay coil, main relay, engine
management system, Engine
control module (5, 6-cyl. petrol)10
Transmission control module15
Compressor A/C (not 5-cyl. die-
sel), Coolant pump (5-cyl. diesel
Start/Stop)15
FunctionA
Relay coil, relay, compressor A/
C (not 5-cyl. diesel), Relay coil,
relay, coolant pump (5-cyl. die-
sel Start/Stop)
Relay coils in central electrical
unit in engine compartment cold
zone Start/Stop5
Actuator solenoid, starter
motorA30
Ignition coils (4-cyl. petrol),
Glow control module (5-cyl. die-
sel)10
Ignition coils (5, 6-cyl. petrol),
Capacitor (6-cyl.)20
Engine control module (petrol)10
Engine control module (diesel)15
FunctionA
Valves (1.6 l petrol), Mass air
flow sensor (1.6 l petrol)
Mass air flow sensor (D4162T),
Control valve, fuel flow
(D4162T)10
Mass air flow sensor (5, 6-cyl.),
Control valves (5-cyl. diesel),
Injectors (5, 6-cyl. petrol),
Engine control module (6-cyl.)15
Compressor A/C (5, 6-cyl.),
Engine valves, Engine control
module (6-cyl.) Solenoids (6-cyl.
without turbo), Actuator motors,
intake manifold (6-cyl. without
turbo), Mass air flow sensor (4-
cyl. 2.0 l petrol), Oil level sensor
(5-cyl. diesel)
Coolant pump (D4162T)10
Lambda-sonds (4-cyl. petrol),
Lambda-sond (diesel), Control
module, radiator roller cover
(manual 5-cyl. 2.0 l diesel)10
EVAP valve (5, 6-cyl. petrol),
Lambda-sonds (5, 6-cyl. petrol)15
ProCarManuals.com

08 Maintenance and service
Car care
08
344
Washing the car
Wash the car as soon as it becomes dirty.
Wash the car in a car wash with oil separator.
Use car shampoo.
•Remove bird droppings from the paintwork
as soon as possible. Bird droppings con-
tain chemicals that affect and discolour
paintwork very quickly. An authorised
Volvo workshop is recommended for the
removal of any discoloration.
•Hose down the underbody.
•Rinse the entire car to remove loose dirt.
Do not spray directly onto the locks.
•Wash using a sponge, car shampoo and
plenty of lukewarm water.
•Clean the wiper blades with a lukewarm
soap solution or car shampoo.
•Use cold degreasing agent on very dirty
surfaces.
•Dry the car using a clean, soft chamois or
a water scraper.
WARNING
Always have the engine cleaned by a work-
shop. There is a risk of fire if the engine is
hot.
IMPORTANT
Dirty headlamps have impaired functional-
ity. Clean them regularly, when refuelling for
example.
NOTE
Outside lighting such as headlamps, fog
lamps and rear lamps may temporarily have
condensation on the inside of the lens. This
is normal, all exterior lighting is designed to
withstand this. Condensation is normally
vented out of the lamp housing when the
lamp has been switched on for a time.
Cleaning the wiper bladesAsphalt, dust and salt residue on wiper blades,
as well as insects, ice etc. on the windscreen,
impair the service life of wiper blades.
For cleaning:
–Set the wiper blades in service position,
see page 325.
NOTE
Wash the wiper blades and windscreen reg-
ularly with lukewarm soap solution or car
shampoo.
Do not use any strong solvents.
Automatic car washesAn automatic car wash is a simple and quick
way of washing the car, but it cannot reach
everywhere. Handwashing the car is recom-
mended for achieving optimum results.
NOTE
During the first few months a new car must
only be handwashed. This is because the
paintwork is more sensitive when it is new.
High-pressure washingWhen using high-pressure washing, use
sweeping movements and make sure that the
nozzle does not come closer than 30 cm to the
surface of the car (the distance applies to all
exterior parts). Do not spray directly onto the
locks.
Testing the brakes
WARNING
Always test the brakes after washing the
car, including the parking brake, to ensure
that moisture and corrosion do not attack
the brake linings and reduce braking per-
formance.
Lightly depress the brake pedal now and then
when driving long distances in rain or slush.
The heat from the friction causes the brake lin-
ProCarManuals.com

09 Specifications
Fluids and lubricants 09
362
FluidSystemVolume (litres)Prescribed grade
Washer fluidCars with headlamp washing5.4Washer fluid recommended by Volvo - with frost protection during coldweather and below freezing point.
Cars without headlampwashing4.0
FuelPetrol engineapprox. 67Petrol: see page 274
Diesel engineapprox. 67Diesel: see page 275
AWater quality must fulfil the standard STD 1285.1.BDRIVeCManual gearboxDAutomatic gearbox
NOTE
Under normal driving conditions, the gear- box oil does not need to be changed duringits service life. However, this may be nec-essary under adverse driving conditions,see page 361.
ProCarManuals.com

10 Alphabetical Index
10
386
A
ACC – Adaptive cruise control................. 175
Active Bending Lights (ABL)...................... 89
Active chassis – FOUR-C........................170
Active Xenon headlamps........................... 89
Adaptation............................................... 115
Adapting driving characteristics.............. 170
Adaptive cruise control............................ 175
fault tracing......................................... 182
radar sensor........................................ 181
Adaptive cruise control fault tracing........ 182
Additional heater (Diesel)......................... 165
Adjusting headlamp pattern...................... 93
halogen headlamp................................ 94
Adjusting the steering wheel...................... 87
Airbag
activating/deactivating, PACOS........... 22
driver's and front passenger side......... 20
key switch off........................................ 22
AIRBAG ..................................................... 20
Airbag system ........................................... 19
Air conditioning........................................ 159
general................................................ 152Air conditioning, AC................................. 159
Air distribution.................................. 154, 161
Air quality system IAQS .......................... 159
Air vents................................................... 154
Alarm.......................................................... 65
alarm indicator...................................... 65
alarm signals......................................... 66
arming................................................... 65
checking the alarm............................... 49
deactivate............................................. 65
deactivating a triggered alarm.............. 66
reduced alarm level.............................. 66
Alcolock................................................... 108
Allergy and asthma inducing sub-
stances.................................................... 153
All-wheel drive, AWD............................... 130
All Wheel Drive (AWD).............................. 130
Approach light, duration......................48, 93
Audio
settings....................................... 226, 227
surround.....................................220, 227
audio system .......................................... 222
Audio system........................................... 220
functions............................................. 226
overview.............................................. 222Audio volume .......................................... 223
phone.................................................. 254
phone/media player............................ 254
ring signal, phone............................... 254
Auto
climate control settings...................... 158
Automatic car washes.............................344
Automatic gearbox.................................. 117
manual gear positions (Geartronic)..... 118
towing and recovery........................... 289
trailer................................................... 284
Automatic locking...................................... 61
Automatic relocking................................... 59
Auxiliary heater........................................ 165
AUX input......................................... 222, 240
AWD, All-wheel drive............................... 130
B
Backrest..................................................... 82
front seat, lowering............................... 82
Backrest rear seat, lowering...................... 85
Bag holder .............................................. 279
ProCarManuals.com

10 Alphabetical Index
10
388
seatbelts............................................. 347
upholstery........................................... 346
Clean Zone Interior Package (CZIP)........ 153
Climate control........................................ 152
general................................................ 152
sensors............................................... 152
Clock, setting............................................. 78
CO
2 emissions ........................................ 363
Collision..................................................... 30
Collision warning.............................192, 193
Collision warning system
radar sensor........................ 181, 188, 193
Collision Warning with Auto Brake*......... 192
Colour code, paint................................... 348
Combined instrument panel.................... 142
Comfort inside the passenger compart-
ment......................................................... 215
Comfort lighting......................................... 93
Compass................................................. 105
calibration........................................... 105
Condensation in headlamps.................... 344
controls
centre console ...........................223, 263Controls
centre console.................................... 144
Controls, lights........................................... 88
Cooling system........................................ 270
Corner Traction Control .......................... 168
Crash, see Collision................................... 30
Cruise control.......................................... 171
CZIP (Clear Zone Interior Package)......... 153
D
DAB Radio............................................... 233
Deadlock
deactivation.......................................... 62
temporary deactivation......................... 63
Deadlocks.................................................. 62
Defroster.................................................. 159
Diesel.......................................................275
Diesel particle filter..................................276
Dipstick, electronic.................................. 315
Direction indicators.................................... 91
Disengaging the gear selector inhibitor. . . 120
Display lighting.......................................... 88Distance Warning....................................185
Dolby Surround Pro Logic II.................... 220
Door mirrors............................................. 102
Driveable punctured tyres........................ 304
Driver Alert Control.................................. 199
Driver Alert System.................................. 199
Driving...................................................... 270
cooling system.................................... 270
with the tailgate open.........................271
with trailer........................................... 283
Driving in water........................................ 270
Driving with a trailer
towball load........................................ 355
towing capacity..................................355
DSTC, see also Stability control system.. 169
DVD ......................................................... 236
E
ECC, electronic climate control...............155
Economical driving.................................. 270
ECO pressure.......................................... 301
Eco Start/Stop DRIVe.............................. 123
ProCarManuals.com