2012 VOLKSWAGEN TRANSPORTER load capacity

Technical data
Technical data
Vehicle data
COJ Introduction
This chapter contains information on the following subjects:
Vehicle identification data . . . . . . . . . . . . . . . . . 451
Dimensions ........................... . 452
Unless otherwise specified, the technical data of the basic model apply. The values quoted here may differ if additional equipment is fitted, for differ-ent models, for special vehicles or if country-specif-ic equipment is fitted. All data in the official vehicle documents take precedence over these data.
Engine
The vehicle data sticker and the official vehicle documents show which engine is installed in your vehicle.
Weight
The values for the kerb weight in the following ta-bles apply for the road-ready vehicle with driver (75 kg), service fluids including fuel tank carrying 90% of its capacity and, if applicable, toolkit and spare tyre =>&.Additional equipment and retrofit-ted accessories increase the stated kerb weight and reduce the maximum permitted load accord-ingly.
The load comprises the weights of the following:
• Passengers
• Allluggage
• Roof load including the mounts or roof bars and the load carrier system
• Drawbar load when towing a trailer
Performance figures
The performance figures were measured without equipment which may influence performance, such as a roof carrier or mud flaps.
Gross combination weight rating
The gross combination weight ratings listed are on-ly applicable for altitudes up to 1 ,000 m above sea level. The maximum weight of the car and trailer must be reduced by approximately 10% for every further 1 ,000 m in altitude.
450 I Tcchn1cal data
Descriptions of the tables
Gearbox abbreviations: MG = manual gearbox, DSG® = dual clutch gearbox DSG®.
Additional information and warnings:
• Transporting =:o page 125
• Driving with respect for the environment =:.page 278
• Fuel =:.page 343
• Engine oil =:o page 353
• Engine coolant =:o page 358
• Wheels and tyres =>page 367
• Consumer information =>page 404
,A WARNING
Exceeding the maximum permissible weights, payload, dimensions, vehicle speed and axle weight rating could cause damage to the vehicle, accidents and serious Injuries.
• Do not exceed the permitted weights, loads, dimensions and maximum speeds.
• The actual axle loads must never exceed the maximum permissible axle loads.
• The payload and the distribution of the load In the vehicle have an effect on the driv-ing response and braking distance of the ve-hicle. Adjust your speed accordingly.
,A WARNING
Accidents and severe injuries can occur if the maximum permitted gross combination weight Is exceeded.
• Never exceed the specified gross combi-nation weight rating.
The payload should be distributed as evenly as possible in the vehicle. When transporting heavy objects in the luggage compartment, they should be placed either in front of or over the rear axle in order to minimise the effect on the vehicle's handling.

Diesel engines
62 kW, 4-cylinder TDI®, emission standard EU51l
Power output 62 kW at 3,500 rpm
Engine code CAAA
Capacity 1,968 ccm
Injection technology TO I®
Maximum torque 250 Nm at 1 ,250 -2,500 rpm
Gearbox MGS
Maximum speed km/h 146a)
Kerb weight kg 1,946-2,530
Gross vehicle weight rating I kg 3,000 I 3,080
Gross axle weight rat-kg 1,610 ing, front
Gross axle weight rat-kg 1,515-1,575 ing, rear
Trailer load, braked kg 2,200 gradients up to 12%
Trailer without brakes kg 750
Maximum permitted gross combination kg 4,800 weight
•l Maximum speed is reached 1n 5th gear. 62 kW, 4-cylinder TDI®, emission standard EU6
Power output 62 kW at 2,750-3,250 rpm
Engine code CXGA
Capacity 1,968 ccm
Injection technology TDI®
Maximum torque 220 Nm at 1,250-2,500 rpm
Gearbox MGS
Normal roof km/h 146a) Maximum speed Pop-up roof km/h 143a)
Multivan, Busi-kg 1,946-2,530 Kerb weight ne ss
California kg 2,274-2,557
Gross vehicle weight rating kg 3,000 /3,080
Gross axle weight rat-Multivan, Busi-kg 1,610 ne ss ing, front California kg 1,550
Gross axle weight rat-Multivan, Busi-kg 1,515-1,575 ne ss ing, rear California kg 1,550
11 The emissions class of this engine can also be EU3 or EU4 in some regions.
Technical data 455

Sun visors ........................... 115
Supplementary heater . . . . . . • . . . . . . 332, 345 Automatic switch-off . . . . . .. . . . . . . . . . . 341
Supplementary heaters Remote control: range . . . . . . . . . . . . . . . 337
Supplementary heater, California . . . . . . . 251 Programming . . . . . . . . . . . . . . . . . . . . . . 251
Supplementary heating system Activating . . . . . . . . . . . . . . . . . . . . . . • . . 338 Automatic switch-off . . . • . . . . . . . . . . . . . 341 Child proof lock . . . . . . . . . . . . . . . . . . . . . 339 Controls . . . . . . . . . . . . . . . . . . . . . . . . . . 333 Operation . . . . . . . . . . . . . . . . . . . . . . . . . 339 Programming . . . . . . . . . . • • . . . . . . . • . . 338 Remote control . . . . . . . . . . . . . . . . . . . . . 335 Switching off . . . . . . . . . . . . . . . . . . . . . . . 334 Switching on . . . . . . . . . . . • • . . . . . . 333, 334 Things to note . . . . . . . . . . . . . . . . . . . . . 334
Supposed faults...................... 410
Switch-off of electrical consumers . . . . . . 366
Switching off consumers . . . . . . . . . . . . . . 365
Symbols see Warning and indicator lamps . . . . . . . . 16
Systems
T
ASS ............................. 275 Anti-lock brake system (ABS) . . . . . . . . . 275 Automatic headlight control . . . . . . . . . . . . 11 0 BAS ............................. 275 Brake Assist system (BAS) . . . • . . . . . . . 275 ccs ............................. 295 Cruise control system . . . . . . . . . . . . . . . 295 EDL . . . . . . . . . . . . . . . . . . . . . . 275 Electronic differential lock (EDL) . . . . . . . 275 Electronic stability control (ESC) . . . . . . . 274 ESC ............................. 274 Hill Hold Assist . . . . . . . . . . . . . . . . . . . . . 284 Lane change assist system . . . . . . . . . . . 312 Parking aid (front and rear) . . . • . . . . . . . 289 Parking aid (only at rear) . . . . . . . . . . . . . 288 ParkPilot . . . . . . . . . . . . . . . . • . • . . . . . . . 287 ParkPilot (front and rear) . . . . . . . . . . . . . 289 ParkPilot (only at rear) . . . . . . . . . . . . . . . 288 Rear Assist (reversing camera) . . . . . . . . 291 Reversing camera . . . . . . . . . . . . . . . . . . 291 Side Assist (lane change assist system) . 312 Start/stop . . . . . . . . . . . . . . . . . . . . . . . . . 283 TCS . . . . . . . . . . . . . . . . . . . . . . . . . 275, 276 Traction control system (TCS) . . . . . 275, 276 Tyre monitoring system . . . . . . . . . . 318, 321
T-shaped fastening ring . . . . . . . . . . . . . . . 135
Tables . . . . . . . . . . . . . . . . . . . . . . . . . • . . . . 155 California . . . . . . . . . . . . . . . . . . . . . . . . . 229 Central table . . . . . . . . . . . . . . . . . . . . . . . 155
480 I Index
Folding table in the side panel . . . . . . . . . 155 Folding table in the sliding door . . . . . . . . 229
Tachograph . . . . . . . . . . . . . . . . . . . . • . . . . 172
Tallgate . . . . . . . . . . . . • . . . . . . . . . . • . . . . . . 49 Child proof lock . . . . . . . . . . . . . . . . • . . . . . 52 Closing . . . . . . . . . . . . . . . . . . . . . • • . . . . . 50 Drivlng with an open tallgate . . . . . . . . . . 129 Locking............................ 40 Locking from the inside . . . . . . . . . . . . 50, 51 Manual opening and closing . . . . . . . . . . 414 Opening ........................... 50 Power closing . . . . . . . . . . . . . . • . . . . . . . . 50 see Tailgate . . . . . . . . . . . . . . . . . . • . . . . . 40 Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . 40 Unlocking from the inside . . . . . . . . . . . . . . 51 Warning lamp . . . . . . . . . . . . . . . . . • . . . . . 50
Tall lights (LED) . . . . . . . . . . . . . . . . . . . . . . 434
Tank cap Closing . . . . . . . . . . • . . . . . . . . . . . . . . . . 342 Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 342 Opening . . . . . . . . . . . . . . . . . . . . . . . . . . 342 Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . 342
TCS see Brake assist system . . . . . . . . . . . . . 276 see Brake support systems . . . • . . . . . . . 275 Switching on and off . . . . . . . . . . . . . . . . . 276
Technical data Axle weight rating . . . . . . . . • . . • . . . . . . . 450 Capacities . . . . . . . . . . . • . . . . . . . . 121. 343 Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . 450 Dimensions . . . . . . . . . . . . . . . . . . . . . . . 452 Drawbar load . . . . . . . . . . . . . . . . . . . . . . 140 Engine oil specification . . . • . . . . . . . . . . 354 Engine specifications . . . . . . . . . . . . • . . . 450 Factory plate . . . . . . . . . . . . . . • . . . . . . . 451 Gross vehicle weight rating . . . . . . . . . . . 450 Kerb weight . . . . . . . . . . . . . . . . . . . . . . . 450 Living area . . . . . . . . . . . . . . . . . . . . . . . . 255 Maximum speed . . . . . . . . . . . . . . . . . . . . 450 Output ........................... 450 Performance figures . . . . . . . . . . . . . . . . . 450 Roof load . . . . . . . . . . . . . . . . . . . . . . . . . 139 Trailer weight . . . . . . . . . . . . . . . . . . . . . . 450 Type plate . . . . . . . . . . . . . . . . . . . . . . . . 451 Tyre pressure . . . . . . . . . . . . . . . . . . . . . . 371 Vehicle data sticker . . . . . . . . . . . . . . . . . 451 Weights . . . . . . . . . . . . . . . . . . . . . . . . . . 450
Technical modifications . . . . . . . . . . . . . . . 396 Lifting platform . . . . . . . . . . . . . . . . . . . . . 401 Plates ............•............... 405 Stickers . . . . . . . . . . . . . . . . . . . . . . . . . . 405
Telematlc services see Volkswagen Car-Net . . . . . . . . . . . . . 402
Telephone handset, rear-seat telephony, Business . . . . . . . . . . . . . . . . . . . . . . . . . . 191