2012 VOLKSWAGEN GOLF PLUS flat tire

cannot become involved in indi­
vidual
problems between you,
your dealer, or Volkswagen of
America, Inc.
To contact
9153);
go to http: / /www.safe rcar.gov;
UTQG
Please first read and the introductory information and heed the on page311.
imum section width. Exam ple:
Treadwear (number)
Traction: B or
Te mperature:
Fo r exa mple: Tread wear Traction AA TemperaturA
All passenger car tires must conform to Fed eral Hequirements in addition to these grades.
Tread wear (TREADWEAR}
The tread wear grade is a co mparativ e rating base d
o n th e wear rate of the tire when te sted under trolled conditi ons on a specified government test cour se.
F o r exa mpl
e, a tire grad ed (Trea dwear-value would wear one-and-one-half o n th e governme nt cou rse as a tire graded
Band Those grades represent the tire's abilit y
t o s to p on wet pave ment as measu re d unde r tr olled conditions on specified government test
may have poor tra ction p erformance
Temperature resistance {TEMPERATURE}
T he temperature grades are A ( the high est), B. and representing the tire 's res istance to the tion of heat, and its ability to dissipate heat when teste d under co ntrolled condition s on a specified
indoor l aboratory test wheel.
S ustain ed high
temperature can ca use the
B and A represent higher leve ls of
imum re quired by law
The traction grade ass igned to thi s tire is based on s traight-ahead braking traction tests, and does not include acceleration, cornering,
The temperature grade for this tire is established for a tire that is properl y inflated and not loaded. Excess ive speed, underinflation or
tion, can cause heat buildup and possib le ti re
failure

Tire
Introduction
In thi s section you'll fin d information on th e lowing:
Cont ent s o f the tire mobi lity set . . . 337
Prep ara tio ns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338
minu tes of drivin g . . . . . . . . . . . . . .
tures up to abo ut 3/16 in (4 mm) in diam ete r c an
b e re liabl y se ale d using the tir e mobility The
foreign obje ct (sc rew or fo r example) must
n ot be re m ove d from the tire!
Afte r the sealant is th e tire , driv e for abou t minut es and check tir e pressure ag ain.
Never use th e
tire m obility se t to a tire un less you
-have park ed ve hicl e at a safe s po t,
- are fami liar with the nec ess ary pro ce -dures and safe ty pre cautio ns, and
-have th e correc t tir e mobilit y Otherw ise . ge t exp ert ass is tan ce .
Tir e sealant mu st not be used:
If th e w heel rim is damaged.
i\t out side tempe ratur es below
If th e c ut or punctu re da mag e of th e tir e is
g rea te r than 3/16 in (4 mm) in diameter.
I f you were drivin g wi th very lo w tire press ure
o r flat tir e.
If th e tir e inflation cyli nder h as passe d its ration elate.
More information:
Vehicle key page 34
Braking, s to ppin g and page 188
T ires and page 276
In an em erge ncy pag e
page 328
D o it yoursel f
rious personal injury:
Alway s stop the ve hicle as soon as it is sa fe to
d o so and move the ve hicl e
Always make sur e that th e ground is leve l a n d
firm.
passen gers and espec iall y childr en must stay
Turn on the emerge ncy flas hers and set up an oth er warnin g dev ice about 25 yards (25
m ete rs) behind the ve hicl e to warn approaching
traffic .
the tire mobility set only if yo u are mili ar with the n ecessa ry s tep s. Othenvisc, get
expe rt ass is tance.
yo u can get profe ssional h elp.
Sea lant is harmful and mus t immedi atel y be removed in case of skin contact.
Alway s store th e tire mobilit y se t o u t of reach of children .
Never usc a vehicl e jack, even if th e jack is proved for use with your vehicle.
Always apply the parkin g brake and shift the
t ran smi ssio n Par k (P) (automati c

Improper use of th e tire set can cause a
temporary tire to fail and lead to loss of veh icle
contro l and seriou s personal injuries.
Always remember that a tire filled with ant does not handle as well as an undamaged tire without sealant.
Never drive faster than mph
Neve r use the tire set if the outside temperature is below
Never drive with a tire that has cuts or when they are larger than3/16
in(4mm).
se t only for emergencies yo u can get profe ssional he lp .
to at least 36 psi
(2.5 bar) , do not drive the vehicle. Contact the nearest authorized Volk swagen dealer,
minutes, do not drive the ve hicl e any farth er. Contact the nearest authorize d Volkswagen dealer, rize d Volkswagen Service Facility, or qualified
works hop.
of the tire set
Fig . 187 Basic diagram: Contents of th e tire mobility set.
May a ls o be inte grated in th e c ompr essor.
(continued)
Alwa ys replace a tire
Avoid full throttl e acceleration , hard,
braking, and fas t cornering.
Drive at s low speed for
of u se d or expir ed seala n t.
New tire inflation cylind ers a re avai lable from authorized Volksw age n dealer s a nd thoriz e d Volkswage n
Rea d th e sepa rate use r manual o f the facturer of th e tire mobility
first read and not e the information and hee d the on pag e 336.
Th e tir e mobilit y se t i s s tor ed in th e luggag e
partment under th e floor covering. It contai ns the fig. 18 7 :
Label w ith sp ee d or
Fillin g hose w ith sealing plug
Air com pre ssor
Tire inflation hose
Tire pressure gau ge4l
A ir valve5l
s w itch
In stead of this. a buuonm ay be in cluded in the co mpressor.
tips 336 337

Tire inflatio n cy lind er w ith sealant4l
Replacem ent va lve cor e
Th e valv e
core wrench has a sl it on th e lowe r
end wh ich fits the va lve co re. Thi s is th e only way
Pr eparations
to unsc rew the v alve core from the tir e va lve and t o
sc rew it in aga in. T his a ls o applies for the replace­
m ent va lv e co re @ .
first read and no te th e in troduc tory in for mation and hee d th e on page 336.
Checklist
188 .
3 . Autom atic transmi
ssio n: S hift th e tra nsmi ssio n into 179.
4 . Sto p th e e ng in e
and re m ove the key from th e ig ni tio n page 172.
5. Man ua l
tra nsmi ssion: Engage page 179.
6. Have all passengers exit and go to a safe place, su ch as behind th e g uard rail.
7. Swi tc h on em erge ncy flashers and put up th e wa rning page 320.
whe ther a repa ir th e tir e mob ility set is p age 336.
9. If towin g a trailer: Unhi tch th e trailer f rom th e ve hicl e and pa rk the trailer properly.
p age 337, fig. 187 ® from the tire mobility set o n the in strument panel in the driver's fie ld of vis io n.
1 3. The fore ig n o
bject (screw or nail, for example) sh o ul d not be re m ove d from th e tire!
Di sregarding the safe ty-r elat ed checkli st may
lead t o accidents and serious injurie s.
Always rev ie w and follow the c hecklist.
F ollow accepted safety practices and use common sense .
Do it yo ur self

Please first read and note the introdu ctory information and heed the on page 336 .
the valve core from th e tir e valve
u sin g th e valve core page 337 , fig . 187 and place it on a clean surface.
Vigorous ly shake th e tir e inflation cylinder page 337, fig. 187
Tigh tly sc rew the filling page 337, fig. 187 to the tire inflation bo ttl e ( turn
He mov e the sealing plug from th e page 337, fig. 18 7 and slid e th e open end th e way onto the tire va lve.
H old the cylinder with the bottom po inting up and the entire contents of th e tir e inflati on inder int o th e tir e.
Detach the empty tir e inflation cylinder from
th e va lve.
p age337,fig. 187 sc rew the v al ve core back into the tir e valve.
the tire
the tire inflation page 337, fig. 187 o f th e air compressor tightl y to th e tir e va lve .
whether the air release pag e 337, 187 is screwe d on tightly.
page 337, fig. 187 into a soc ket of the page
Switch th e ai r compresso r on using th e page 337, fig. 187
Le t th e air compre ssor run until 2 .5 ) bar is re ach ed
Switch off the air compressor.
an air press ure of29-36 psi 2.5 bar)
cannot b e reac hed, unscrew the tire inflation hose from the tire v alve.
tips
Dr ive about feet m ete rs) backward s o r
f o rward s so that the sealant ca n be distributed sid e th e tire .
th e tire inflat ion hose of th e air pr esso r aga in to the tir e va lve and r epeat th e
th e required tir e pressure still cannot be reached. the tir e is too badly damaged. The t ir e
canno t b e sealed us ing th e tire mobilit y set. Do not
d rive the v ehicle. Get expert
Disconnect th e air compresso r and unscrew the tire infl ation hose from the tir e va lve .
mph km/h).
page340.
The tire inflation hose and ai r compresso r ca n
get hot during inflation.
Protec t hands and skin fro m hot parts.
Do not p lace th e hot tire inflation hose or hot air compressor on flammable material.
Let th e equipment cool off almost plet ely before sto wing it.
bar), th e damage is to o great to be repaired
wi th the tire mobility set. The sealant is not able to seal the tire. Do not drive the ve hicle. Get pert assistance.
Note
Do not let the compressor run for more than 8 minutes to help prevent overheating damage.
Let the compressor cool down for a few minutes
befor e switching it on again. Let it cool down most completely before stowing it in the re p a ir
kit.
338 339

Reve rse camera .........................
Roof rack .............................. 149
Run -flat tires
Code ................................ 291
s
.................................. 178
belt height adjusters ............... 75
b elt load limit er ................... 78
belt position ...................... 74
b elt preten sioncr .................. 78
belt retractor ...................... 78
belts .............................. 67
Belt pos ition .......................... 74
Belt sta tu s display.................... 68
Checklist ............................. 72
C leaning ............................ 275
Extende r ............................. 76
Faste ning ............................ 73
Lockab le sa fe ty belt ................... 72
No t fas tened......................... b elt height adjuste rs ............ 75
b elt load limiter. ................ 78
belt prete nsioner ............... 78 belt retractor ................... 78 Twisted belt .......................... 72
Unfa stening .......................... 73
U sin g ................................ 72
Wa rnin g light. . . . . . . . . . . . . . . . . . . . . . . . 68
b elt s protect . . . . . . . . . . . . . . . . . . . . . . 7 1
continents ........ 312
heating............................ 65
position
Imp roper seating positions ............ 57
.................................. 56
Secu ri
ng a load
Roof rack. . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 1
Selector lever lock ..
.................... 183
th e vehicl e . . . . . . . . . . . . . . . . . . . . . . . 4
reminder display. . . . . . . . . . . . . . . .
Settin gs
A ir
conditioner ...................... 231
paddles
T ipt ronic
............................ 185
Alphabetical index
Shiftin g ................................ 179
Auto matic transmis sion .............. 182
Eme rge ncy relea sing of the selector leve r. .
325
Gea rs hif t lever (
manual transmi ssion) . 182
Manual tra nsmiss ion ................. 182
Selector lever (automati c trans missio n) 182
Warnin g and indicator lights ..........
Curtain Protection
see Airbag system . . . . . . . . . . . . . . . . . . . . 98
Sitt in
g................................. 56
Adjust ing hea d restra ints .............. 61
Adjusting th e s teeri ng w heel position.. 63
Electrically adjus table front seat.... . . .
In stalling head restrai nts . . . . . . . . . . . . . 62
Mecha nica l front
seat . . . . . . . . . . . . . . . . 59
Number of seats . . . . . . . . . . . . . . . . . . . . . 56 sea tin g pos ition... . . . . . . . . . . . . 58
Rear backre st
........................ 143
Remov ing head restra ints . . . . . . . . . . . . . 62
heating. . . . . . . . . . . . . . . . . . . . . . . . . 65
chains . . . . . . . . . . . . . . . . . . . . . . . . . . 295
Compact spare w heel . . . . . . . . . . . . . . . 295
parts. . . . . . . . . . . . . . . . . . . . . . . .
consid era tion s
Car wash . . . . . . . . . . . . . . . . . . . . . . . . . . . 263
Dr iving with a trailer
................. 156
Foldi ng m irror in
.................... 136
....... .................. 189, 192
park ing
.............................. 33
e mi ssion ..................... 241 Towi ng. . . . . . . . . . . . . . . . . . . . . . . . . 357, 358
Vehi cle was hing . . . . . . . . . . . . . . . . . . . . 263 W ashing ve hicle . . . . . . . . . . . . . . . . . . . . . 42

TIN .................................. .
292
Tiptronic ............................... 185
Tire damage.. . . . . . . . . . . . . . . . . . . . . . . . . . 286
Tire inflati on pressure . . . . . . . . . . . . . . . . . 283
. . . . . . . . . . . . . . . . . . . . . . . . . . 283
spare wheel . . . . . . . . . . . . . . . 284 Spare wheel . . . . . . . . . . . . . . . . . . . . . . . . 284
Tire mobility set . . . . . . . . . . . . . . . . . . . . . . . 336
minutes . . . . . . . . . . . . . .
tire m ob ilit y set . . . . . . . . . . . . . . . . . 336
no t to use . . . . . . . . . . . . . . . . . . . . 336
Tire Monitoring Sys tem
Tire inflati on
pressu re. . . . . . . . . . . . . . . 283
Tire Pressure Monitoring Sys te m . . . . . . .
Tire re p a ir set
tir e m ob ility se t . . . . . . . . . . . . . . . . . 336
Tire wear.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 287
Tires
T ires and w hee ls . . . . . . . . . . . . . . . . 276
Tires a
nd wheels....................... 276
Avoiding
damage . . . . . . . . . . . . . . . . . . . 278
Br eak- in period
...................... 281
spare w heel ............... 288
Determine load limit . . . . . . . . . . . . . . . .
Imbal ance.......................... 287
In co rrect wheel a lignment........... 287
I nflat io n pr essure
sensor . . . . . . . . . . . . 284
La beli n g . . . . . . . . . . . . . . . . . . . . . . . . . . .
Load rating code of th e tir es. . . . . . . . . . 293
New
tires .......................... .. 28 1
rat ing code letter . . . . . . . . . . . . . 293
the replaced w hee l . . . . . . . . . . 288
Technical data. . . . . . . . . . . . . . . . . . . . . . Tire an d wheel handling. . . . . . . . . . . . . 278
Tir e damage. . . . . . . . . . . . . . . . . . . . . . . . 286
T ire identifi ca
tion number (TIN) . . . . . 292
Ti re infl ation pressure............... 283
Alphabetical ind ex
Tir e lab eling. . . . . . . . .. .. . . . . .. . . . . .
balancing ..................... 287 rims. . . . . . . . . . . . . . . . . . . . . . . . .
tires. . . . . . . . . . . . . . . . . . . . . . . . . 294
Tongue load ............................ 152 Trailer loading ....................... 155
Tools
F ront tow ing eye.. . . . . . . . . . . . . . . . . . . 358
Rear towing
eye.. . . . . . . . . . . . . . . . . . . . 359
S pec ia l
consideratio ns. . . . . . . . . . . 357, 358
Tow b
ar ............................. 357
Tow rope ............................ 357
Towi ng prohibi
tion .................. 357 traile r hit ch ..................... 357
Towing
capacity
T railer loading ....................... !55
Tow- starting ........................... 357
Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 292
Trailer Driving .............................. !56
D
riv ing w ith a trailer ................. !56
E lec tri
cal socke t ..................... !54 H ea dligh t settin gs .................... 156
L E D r
ear ligh ts. . . . . . . . . . . . . . . . . . . 153, !54
Loading ............................. 155
Malfunction ......................... 155
Pa rking System. . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
Rear ligh ts ....................... 153, 154 Retrofitting a rrailer hitch ............. 158
Safety ch a ins . . . . . . . . . . . . . . . . . . . . !53, !54
Tongue load . . . . . . . . . . . . . . . . . . . . . . . . . 152 Tongue weight ....................... !55 Towing capacity ..................... 155
Trailer towing ....................... !52
Trail er hitch
Ball mount . . . . . . . . . . . . . . . . . . .. . . . . . . 157
Malfun ction ......................... 155
H etrofit ............................. 158
trail er . ................. ......... !52