2012 TOYOTA HIGHLANDER load capacity

490
4-3. Do-it-yourself maintenance
Wheels
If a wheel is bent, cracked or heavily corroded, it should be
replaced.
Otherwise, the tire may separate from the wheel or cause loss of
handling control.
■Wheel selection
When replacing wheels, care should be taken to ensure that
they are equivalent to those removed in load capacity, diameter,
rim width, and inset
*.
Replacement wheels are available at your Toyota dealer.
*: Conventionally referred to as “offset”.
Toyota does not recommend using:
● Wheels of different sizes or types
● Used wheels
● Bent wheels that have been straightened
■ Aluminum wheel precautions
●Use only Toyota wheel nuts and wrenches designed for use
with your aluminum wheels.
● When rotating, repairing or changing your tires, check that the
wheel nuts are still tight after driving 1000 miles (1600 km).
● Be careful not to damage the aluminum wheels when using
tire chains.
● Use only Toyota genuine balance weights or equivalent and a
plastic or rubber hammer when balancing your wheels.

576 6-1. Specifications
Lubrication system (2.7 L 4-cylinder [1AR-FE] engine)
*: The engine oil capacity is a reference quantity to be used when exchanging.
Warm up and turn off the engine, wait more than 5 minutes, and check the oil
level on the dipstick.
■Engine oil selection
“Toyota Genuine Motor Oil” is used in your Toyota vehicle. Use
Toyota approved “Toyota Genuine Motor Oil” or equivalent to satisfy
the following grade and viscosity.
Oil grade: ILSAC multigrade engine oil
Recommended viscosity: SAE 5W-20 or 0W-20
SAE 5W-20 or 0W-20 engine oil
may be used. However, SAE
0W-20 is the best choice for
good fuel economy and good
starting in cold weather.
Oil viscosity (0W-20 is explained here as an example):
●The 0W in 0W-20 indicates the characteristic of the oil which allows
cold startability. Oils with a lower value before the W allow for easier
starting of the engine in cold weather.
● The 20 in 0W-20 indicates the viscosity characteristic of the oil when
the oil is at high temperature. An oil with a higher viscosity (one with a
higher value) may be better suited if the vehicle is operated at high
speeds, or under extreme load conditions.
Oil capacity
(Drain and refill 
reference*) Without filter
With filter 4.2 qt. (4.0 L, 3.5 Imp. qt.)
4.6 qt. (4.4 L, 3.9 Imp. qt.)
Outside temperature

578 6-1. Specifications
Lubrication system (3.5 L V6 [2GR-FE] engine)■ Engine oil selection
“Toyota Genuine Motor Oil” is used in your Toyota vehicle. Use
Toyota approved “Toyota Genuine Motor Oil” or equivalent to satisfy
the following grade and viscosity.
Oil grade: ILSAC multigrade engine oil
Recommended viscosity: SAE 0W-20
SAE 0W-20 is the best choice for
good fuel economy and good
starting in cold weather.
If SAE 0W-20 is not available,
SAE 5W-20 oil may be used.
However, it must be replaced
with SAE 0W-20 at the next oil
change.
Oil viscosity (0W-20 is explained here as an example):
●The 0W in 0W-20 indicates the characteristic of the oil which allows
cold startability. Oils with a lower value before the W allow for easier
starting of the engine in cold weather.
● The 20 in 0W-20 indicates the viscosity characteristic of the oil when
the oil is at high temperature. An oil with a higher viscosity (one with a
higher value) may be better suited if the vehicle is operated at high
speeds, or under extreme load conditions.
Oil capacity
(Drain and refill 
reference) Without filter
With filter 6.0 qt. (5.7 L, 5.0 Imp. qt.)
6.4 qt. (6.1 L, 5.4 Imp. qt.)
Outside temperature

596 6-1. Specifications
Warning: The temperature grades for this tire are established for a
tire that is properly inflated and not overloaded.
Excessive speed, underinflation, or excessive loading, either sepa-
rately or in combination, can cause heat buildup and possible tire fail-
ure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pres-
sure Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressure The maximum cold inflated
pressure to which a
tire may be inflated, s hown on the sidewall of
the tire
Recommended infla-
tion pressure Cold tire inflation pressure recommended by a
manufacturer
Accessory weight The combined weight (in excess of those stan-
dard items which may be replaced) of auto-
matic transmission, power steering, power
brakes, power windows, power seats, radio
and heater, to the extent that these items are
available as factory-installed equipment
(whether installed or not)
Curb weight The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded vehi-
cle weight The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

597
6-1. Specifications
6
Vehicle specifications
Tire related termMeaning
Normal occupant
weight 150 lb. (68 kg) times the number of occupants
specified in the second column of Table 1
* that
follows
Occupant distribution Distribution of occupants in a vehicle as speci-
fied in the third column of Table 1
* below
Production options
weight The combined weight of installed regular pro-
duction options weighing over 5 lb. (2.3 kg) in
excess of the standard items which they
replace, not previously considered in curb
weight or accessory weight, including heavy
duty brakes, ride levelers, roof rack, heavy duty
12-volt battery, and special trim
Rim A metal support for a tire or a tire and tube
assembly upon which the tire beads are seated
Rim diameter
(Wheel diameter) Nominal diameter of the bead seat
Rim size designation Rim diameter and width
Rim type designation The industry manufacturer's designation for a
rim by style or code
Rim width Nominal distance between rim flanges
Vehicle capacity
weight (Total load
capacity) The rated cargo and luggage load plus 150 lb.
(68 kg) times the vehicl
e's designated seating
capacity
Vehicle maximum load
on the tire The load on an individual tire that is determined
by distributing to each axle its share of the
maximum loaded vehicle weight, and dividing
by two
Vehicle normal load
on the tire The load on an individual tire that is determined
by distributing to each axle its share of curb
weight, accessory weight, and normal occu-
pant weight (distributed in accordance with
Ta b l e 1
* below), and dividing by two

601
6-1. Specifications
6
Vehicle specifications
*: Table 1
 Occupant loading and distri bution for vehicle normal load
for various designated seating capacities
Tire related termMeaning
Tread That portion of a tire that comes into contact
with the road
Tread rib A tread section running circumferentially
around a tire
Tread separation Pulling away of the tread from the tire carcass
Treadwear indicators
(TWI) The projections within the principal grooves
designed to give a visual indication of the
degrees of wear of the tread
Wheel-holding fixture The fixture used to hold the wheel and tire
assembly securely
during testing
Designated seating
capacity, Number of occupantsVehicle normal load,
Number of occupantsOccupant distribution in a normally loaded vehi- cle
2 through 4 2 2 in front
5 through 10 3 2 in front, 1 in second
seat
11 through 15 5 2 in front, 1 in second
seat, 1 in third seat, 1
in fourth seat
16 through 20 7 2 in front, 2 in second
seat, 2 in third seat, 1
in fourth seat

629
Alphabetical index
Jack
Positioning a floor jack ......... 459
Vehicle-equipped jack .......... 540
Jack handle.............................. 540
Keyless entry ............................. 48
Keys Electronic key ......................... 32
Engine switch ............... 170, 174
If the electronic key does not operate properly ........... 558
If you lose your keys/ wireless remote control
transmitter .......................... 557
Ignition switch ............... 170, 174
Key number ............................ 32
Keyless entry .......................... 48
Keys ....................................... 32
Mechanical key....................... 32
Wireless remote control key ....................................... 48
License plate lights Replacing light bulbs ............ 510
Wattage ................................ 586
Light bulbs Replacing ............................. 510
Wattage ................................ 586
Lights Door courtesy lights.............. 396
Emergency flasher switch .... 518
Fog light switch..................... 206
Hazard light switch ............... 518
Headlight switch ................... 200
Interior light switch........ 397, 398
Outer foot lights .................... 396
Personal light switch............. 397
Replacing light bulbs ............ 510
Turn signal lever ................... 182
Vanity lights .......................... 413
Wattage ................................ 586
Load capacity .......................... 242 Lock steering column ......172, 175
Luggage cover .........................425
Maintenance
Do-it-yourself maintenance .......................453
General maintenance ............449
Maintenance data..................572
Maintenance requirements....446
Maintenance data .....................447
Meter
Instrument panel light control .................................186
Meters ...................................185
Mirrors Conversation mirror...............415
Inside rear view mirror.............95
Side mirror heaters................289
Side mirrors .............................98
Vanity mirrors ........................413
Moon roof .................................104
MP3 disc ...................................312
Multi-information display ....................................191
Noise from under vehicle ..........24
Odometer ..................................185
Off-road precautions ...............233
Oil Engine oil ..............................466
Opener
Back door ................................60
Fuel filler door .......................109
Glass hatch .............................70
Hood......................................457
Outside rear view mirrors Adjusting and folding ...............98
Outside temperature display ....................................191
Overhead console ....................402
Overheating, Engine ................564J
K
L
M
N
O

632 Alphabetical index
TiresChains ................................... 243
Checking ............................... 478
If you have a flat tire .............. 540
Inflation pressure................... 487
Information ............................ 590
Replacing .............................. 540
Rotating tires ......................... 478
Size ....................................... 584
Snow tires ............................. 243
Tire pressure warning
system ........................ 478, 531
Tools ......................................... 540
Total load capacity................... 242
Towing Dinghy towing........................ 265
Emergency towing................. 520
Trailer towing......................... 247
Traction control........................ 223
TRAC ......................................... 223
Trip information ....................... 191
Trip meter ................................. 185
Turn signal lights Replacing light bulbs ............. 510
Switch.................................... 182
Wattage ................................. 586
Valet key .....................................32
Vanity lights Vanity lights ........................... 413
Wattage ................................. 586
Vanity mirrors........................... 413
Vehicle identification number ................................... 573
Vehicle stability control........... 223
VSC............................................ 223
Warning buzzers Brake system ........................ 528
Open door ............................. 531
Seat belt reminder ................. 531 Warning lights
Anti-lock brake system .......... 529
Brake assist system .............. 529
Brake system ........................ 528
Charging system .... ............... 529
Electric power steering system ................................ 529
Electronic engine control
system ................................ 529
Engine oil pressure ............... 529
Malfunction indicator lamp .... 529
Master warning light .............. 531
Open door ............................. 531
Pretensioners ........................ 529
Seat belt reminder light ......... 531
SRS airbags .......................... 529
Tire pressure warning light.... 531
Warning messages .................. 539
Washer Checking ............................... 477
Preparing and checking
before winter ....................... 243
Switch ........................... 208, 212
Washing and waxing ............... 440
Weight Cargo capacity ...................... 238
Load limits ............................. 242
Weight ................................... 572
Wheels ...................................... 490
Window glasses ...................... 101
Window lock switch................. 101
Windows
Power windows ..................... 101
Rear window defogger .......... 289
Washer.......................... 208, 212
Windshield wiper de-icer ........ 291
Windshield wipers ................... 208
Wireless remote control key Replacing the battery ............ 496
Wireless remote control key.... 48
WMA disc.................................. 312
V
W