2012 TOYOTA AYGO gas type

70 1-5. Refueling
AYGO_WE_99E96E
Closing the fuel tank cap
After refueling, turn the fuel tank
cap until you hear a click. (The
key is not required.)
Hang the fuel tank cap on the
back of the fuel filler door.
Fuel types
EU area:
Unleaded gasoline conforming to European standard EN228, Research
Octane Number of 95 or higher
Except EU area:
Unleaded gasoline, Research Octane Number of 95 or higher
Use of ethanol blended gasoline in a gasoline engine
Toyota allows the use of ethanol blended gasoline where the ethanol content
is up to 10%. Make sure that the ethanol blended gasoline to be used has a
Research Octane Number that follows the above.

84 1-7. Safety information
AYGO_WE_99E96EThe main SRS airbag system components are shown above. The
SRS airbag system is controlled by the airbag sensor assembly. As
the airbags deploy, a chemical reaction in the inflators quickly fills the
airbags with non-toxic gas to help restrain the motion of the occu-
pants.
If the SRS airbags deploy (inflate)
Bruising and slight abrasions may result from contact with a deploying
(inflating) SRS airbag.
A loud noise and white powder will be emitted.
Vehicles without SRS curtain shield airbags: Parts of the airbag module
(steering wheel hub, airbag cover and inflator) as well as the front seats
may be hot for several minutes. The airbag itself may also be hot.
Vehicles with SRS curtain shield airbags: Parts of the airbag module
(steering wheel hub, airbag cover and inflator) as well as the front seats,
parts of the front and rear pillars, and roof side rails, may be hot for sev-
eral minutes. The airbag itself may also be hot.
The windshield may crack.
SRS airbag deployment conditions (SRS front airbags)
The SRS front airbags will deploy in the event of an impact that exceeds
the set threshold level (the level of force corresponding to an approxi-
mately 20 - 30 km/h [12 - 18 mph] frontal collision with a fixed wall that
does not move or deform).
However, this threshold velocity will be considerably higher in the following
situations:
• If the vehicle strikes an object, such as a parked vehicle or sign pole,
which can move or deform on impact
• If the vehicle is involved in an underride collision, such as a collision in
which the front of the vehicle “underrides”, or goes under, the bed of a
truck
Depending on the type of collision, it is possible that only the seat belt
pretensioners will activate.

247 4-1. Maintenance and care
4
Maintenance and care
AYGO_WE_99E96E
NOTICE
Cleaning detergents
Do not use the following types of detergent, as they may discolor the vehi-
cle interior or cause streaks or damage to painted surfaces:
• Non-seat portions: Organic substances such as benzene or gasoline,
alkaline or acidic solutions, dye, and bleach
• Seats: Alkaline or acidic solutions, such as thinner, benzene, and alco-
hol
Do not use polish wax or polish cleaner. The instrument panel’s or other
interior part’s painted surface may be damaged.
Preventing damage to leather surfaces
Observe the following precautions to avoid damage to and deterioration of
leather surfaces:
Remove any dust or dirt from leather surfaces immediately.
Do not expose the vehicle to direct sunlight for extended periods of time.
Park the vehicle in the shade, especially during summer.
Do not place items made of vinyl, plastic, or containing wax on the uphol-
stery, as they may stick to the leather surface if the vehicle interior heats
up significantly.
Water on the floor
Do not wash the vehicle floor with water.
Vehicle systems such as the audio system may be damaged if water comes
into contact with electrical components such as the audio system above or
under the floor of the vehicle. Water may also cause the body to rust.
Cleaning the inside of the rear window
Do not use glass cleaner to clean the rear window, as this may cause
damage to the rear window defogger heater wires. Use a cloth dampened
with lukewarm water to gently wipe the window clean. Wipe the window in
strokes running parallel to the heater wires.
Be careful not to scratch or damage the heater wires.

346 6-1. Specifications
AYGO_WE_99E96E
Engine
*: Drive belt deflection with 98 N (10 kgf, 22 lbf) thumb force (used belt)
Model 1KR-FE
Type 3-cylinder in line, 4-cycle, gasoline
Bore and stroke 71.0  84.0 mm (2.79  3.30 in.)
Displacement 998 cm3 (60.9 cu.in.)
Valve clearance
(engine cold)Intake: 0.145 0.235 mm (0.006 0.009 in.)
Exhaust:
0.275 0.365 mm (0.011 0.014 in.)
Drive belt tension9.0 11.0 mm (0.35 0.43 in.)
*
Vehicles without an air conditioning system:
Vehicles with an air conditioning system:
Generator
Water pump
Crankshaft
CrankshaftWater pumpGenerator
Air
conditioning
compressor

347 6-1. Specifications
6
Vehicle specifications
AYGO_WE_99E96E
Fuel
Lubrication system
*: The engine oil capacity is a reference quantity to be used when changing the
engine oil. Warm up and turn off the engine, wait more than 5 minutes, and
check the oil level on the dipstick.
Fuel typeEU area:
Unleaded gasoline conforming to European stan-
dard EN228 only
Except EU area:
Unleaded gasoline only
Research octane num-
ber95 or higher
Fuel tank capacity
(Reference)35 L (9.2 gal., 7.7 Imp.gal.)
Oil capacity
(Drain and refill
 reference
*)
With filter
Without filter3.3 L (3.5 qt., 2.9 Imp.qt.)
3.1 L (3.3 qt., 2.7 Imp.qt.)

361 Alphabetical index
AYGO_WE_99E96E
If your vehicle becomes
stuck ................................... 339
If your vehicle has to be
stopped in an emergency ... 341
If your vehicle needs to be
towed .................................. 305
If your vehicle overheats ....... 336
Engine
Compartment ........................ 260
Engine switch ........................ 130
Hood ..................................... 254
How to start the
engine ................................. 130
Identification number............. 344
If the engine will not start ...... 329
Ignition switch ....................... 130
Overheating .......................... 336
Engine coolant
Capacity ................................ 350
Checking ............................... 264
Preparing and checking
before winter ....................... 163
Engine immobilizer system ...... 73
Engine oil
Capacity ................................ 347
Checking ............................... 261
Preparing and checking
before winter ....................... 163
Engine switch........................... 130
EPS............................................ 158
Floor mat .................................. 238
Fluid
Washer.................................. 269
Fog lights
Replacing light bulbs ............. 292
Switch ................................... 152
Wattage................................. 354
Front fog lights
Replacing light bulbs ............. 292
Switch ................................... 153Wattage ................................ 354
Front passenger’s seat belt
reminder light ........................ 316
Front position lights
Replacing light bulbs............. 292
Switch ................................... 148
Wattage ................................ 354
Front seats
Adjustment .............................. 52
Front turn signal lights
Replacing light bulbs............. 292
Switch ................................... 140
Wattage ................................ 354
Fuel
Capacity ................................ 347
Fuel gauge ............................ 143
Fuel pump shut off system.... 311
Gas station information ......... 368
Information ............................ 355
Refueling................................. 69
Type ...................................... 347
Fuel door .................................... 69
Fuel filler door............................ 69
Fuel pump shut off system ..... 311
Fuses ........................................ 282
Gas station information .......... 368
Gauges ..................................... 143
Hands-free phone system....... 214
Hazard lights
Switch ................................... 304
Head restraints
Adjusting ................................ 57
Headlights
Replacing light bulbs............. 292
Switch ................................... 148
Wattage ................................ 354
Hood ......................................... 254
Horn .......................................... 142
F
G
H

368
AYGO_WE_99E96E
GAS STATION INFORMATION
Auxiliary catch lever
P. 254Fuel filler door
P. 6 9
Hood lock release lever
P. 254Tire inflation pressure
P. 353
Fuel tank capacity (Reference) 35 L (9.2 gal., 7.7 Imp.gal.)
Fuel typeEU area:
Unleaded gasoline conforming to
European standard EN228, Research
Octane Number of 95 or higher
Except EU area:
Unleaded gasoline, Research Octane
Number of 95 or higher
Cold tire inflation pressure P. 353
Engine oil capacity
(Drain and refill  reference)L (qt., Imp.qt.)
With filter 3.3 (3.5, 2.9)
Without filter 3.1 (3.3, 2.7)
Engine oil type P. 348