2012 TOYOTA AYGO flat tire

5
321 5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99E96E
Replacing a flat tire
Chock the tires.
Vehicles with a steel wheel:
Remove the wheel ornament
using the wrench.
To protect the wheel ornament,
place a rag between the wrench
and the wheel ornament, as
shown in the illustration.
Flat tireWheel chock
positions
FrontLeft-
hand
sideBehind the
rear right-
hand side
tire
Right-
hand
sideBehind the
rear left-
hand side
tire
RearLeft-
hand
sideIn front of
the front
right-hand
side tire
Right-
hand
sideIn front of
the front
left-hand
side tire

324 5-2. Steps to take in an emergency
AYGO_WE_99E96EFirmly tighten each wheel bolt
two or three times in the order
shown in the illustration.
Tightening torque:
103 N·m (10.5 kgf·m, 76 ft·lbf)
Do not use other tools or any
additional leverage other than
your hands, such as a hammer,
pipe or your foot.
Vehicles with a steel wheels
Reinstall the wheel ornament.
Align the cutout of the wheel
ornament with the valve stem as
shown.
Vehicles with an aluminum wheels
Remove the center wheel orna-
ment by pushing from the
reverse side.
Be careful not to lose the wheel
ornament.
Stow the flat tire, tire jack and all tools.

326 5-2. Steps to take in an emergency
AYGO_WE_99E96E
CAUTION
Using the tire jack
Improper use of the tire jack may cause the vehicle to suddenly fall off the
jack, leading to death or serious injury.
Do not use the tire jack for any purpose other than replacing tires or install-
ing and removing tire chains.
Only use the tire jack that comes with this vehicle for replacing a flat tire.
Do not use it on other vehicles, and do not use other tire jacks for replac-
ing tires on this vehicle.
Always check that the tire jack is securely set to the jack point.
Do not put any part of your body under the vehicle while it is supported by
the jack.
Do not start or run the engine while your vehicle is supported by the jack.
Do not raise the vehicle while someone is inside.
When raising the vehicle, do not put an object on or under the jack.
Do not raise the vehicle to a height greater than that required to replace
the tire.
Use a jack stand if it is necessary to get under the vehicle.
Take particular care when lowering the vehicle to ensure that no one working
on or near the vehicle may be injured.

5
327 5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99E96E
CAUTION
Replacing a flat tire
Observe the following precautions.
Failure to do so may result in serious injury:
• Do not try to remove the wheel ornament by hand. Take due care in
handling the ornament to avoid unexpected personal injury.
• Do not touch the disc wheels or the area around the brakes immedi-
ately after the vehicle has been driven.
After the vehicle has been driven the disc wheels and the area around
the brakes will be extremely hot. Touching these areas with hands, feet
or other body parts while changing a tire, etc. may result in burns.
Failure to follow these precautions could cause the wheel bolts to loosen
and the tire to fall off, resulting in death or serious injury.
• Never use oil or grease on the wheel bolts.
Oil and grease may cause the wheel bolts to be excessively tightened,
leading to bolt or disc wheel damage. Remove any oil or grease from
the wheel bolts.
• Have the wheel bolts tightened with a torque wrench to 103 N·m (10.5
kgf·m, 76 ft·lbf) as soon as possible after changing wheels.
• When installing a tire, only use wheel bolts that have been specifically
designed for that wheel.
• If there are any cracks or deformations in the bolt screws, nut threads
or bolt holes of the wheel, have the vehicle inspected by any autho-
rized Toyota dealer or repairer, or another duly qualified and equipped
professional.
On vehicles with steel wheels, never
use tools, such as an Allen wrench, that
are used by applying them to a hexago-
nal concave portion of a bolt head.
Doing so could cause bolt deformation
and improper installation, and may
result in serious injury.

328 5-2. Steps to take in an emergency
AYGO_WE_99E96E
NOTICE
Do not drive the vehicle with a flat tire
Do not continue driving with a flat tire.
Driving even a short distance with a flat tire can damage the tire and the
wheel beyond repair.

353 6-1. Specifications
6
Vehicle specifications
AYGO_WE_99E96E
Tires and wheels
Tire size 155/65R14 75T
Tire inflation pressure
(Recommended cold
tire inflation pressure)Vehicle speedFront wheel
kPa (kgf/cm
2 or
bar, psi)Rear wheel
kPa (kgf/cm2 or
bar, psi)
More than 160
km/h (100 mph)230 (2.3, 34) 230 (2.3, 34)
160 km/h (100
mph) or less220 (2.2, 32) 220 (2.2, 32)
Wheel size 14  4 1/2J
Wheel bolt torque 103 N·m (10.5 kgf·m, 76 ft·lbf)

360 Alphabetical index
AYGO_WE_99E96E
Care
Exterior.................................. 242
Interior ................................... 245
Seat belts .............................. 246
CD player .......................... 185, 200
Chains ....................................... 163
Child-protectors ......................... 46
Child restraint system
Baby seats, definition .............. 95
Baby seats, installation ......... 106
Child seats, definition .............. 95
Child seats, installation ......... 106
Installing CRS with ISOFIX
rigid anchor ......................... 110
Installing CRS with seat
belts .................................... 107
Installing CRS with top
straps .................................. 110
Junior seats, definition ............ 95
Junior seats, installation........ 106
Child safety
Airbag precautions .................. 88
Battery precautions ....... 268, 334
Child-protectors....................... 46
Child restraint system ............. 95
How your child should wear
the seat belt .......................... 60
Installing child restraints........ 106
Power window precautions ..... 66
Removed key battery
precautions ......................... 281
Seat belt precautions .............. 61
Cleaning
Exterior.................................. 242
Interior ................................... 245
Seat belts .............................. 246
Clock ......................................... 234
Condenser ................................ 266
Cooling system
Engine overheating ............... 336
Cup holders .............................. 231Curtain shield airbags ............... 82
Daytime running light
system .................................... 150
Defogger
Rear window ......................... 178
Dimension ................................ 344
Do-it-yourself maintenance .... 251
Doors
Back door................................ 48
Door glasses ........................... 66
Door lock........................... 36, 44
Door windows ......................... 66
Rear door child protector ........ 46
Side doors............................... 44
Side mirrors ............................ 65
Driver’s seat belt reminder
light......................................... 316
Driving
Break-in tips .......................... 121
Correct posture ....................... 80
Procedures ........................... 118
Winter driving tips ................. 163
Electric power steering ........... 158
Emergency flashers
Switch ................................... 304
Emergency, in case of
If the engine will not start ...... 329
If the shift lever cannot be
shifted ................................. 330
If the vehicle battery is
discharged .......................... 332
If the warning buzzer
sounds ................................ 312
If the warning light
turns on .............................. 312
If you have a flat tire ............ 318
If you lose your keys ............. 331
If you think something is
wrong.................................. 310C
D
E

363 Alphabetical index
AYGO_WE_99E96E
Radiator .................................... 266
Radio ................................. 181, 196
RDS (Radio data system) ........ 182
Rear fog light
Replacing light bulbs ............. 292
Switch ................................... 152
Wattage................................. 354
Rear seat
Folding down........................... 54
Rear turn signal lights
Replacing light bulbs ............. 292
Wattage................................. 354
Rear window defogger ............ 178
Rear window wiper .................. 156
Replacing
Fuses .................................... 282
Key battery ............................ 280
Light bulbs............................. 292
Tires ...................................... 318
Seat belts
Adjusting the seat belt............. 59
Child restraint system
installation........................... 106
Cleaning and maintaining
the seat belts ...................... 246
Emergency Locking
Retractor (ELR) .................... 60
How to wear your seat belt ..... 59
How your child should wear
the seat belt .......................... 60
Pregnant women,
proper seat belt use .............. 61
Reminder light ....................... 316
Seat belt pretensioners ........... 60Seats
Adjustment .............................. 52
Adjustment precautions .......... 53
Child seats/child restraint
system installation .............. 106
Cleaning................................ 245
Front seat adjustment ............. 52
Front seat adjustment
precautions ........................... 53
Head restraint ......................... 57
Properly sitting in the seat ...... 80
Shift lever
If the shift lever cannot be
shifted ................................. 330
Manual transmission ............. 138
Multi-mode manual
transmission ....................... 133
Shift lock system ..................... 330
Side airbags ............................... 82
Side mirror
Adjusting and folding .............. 65
Side turn signal lights
Wattage ................................ 354
Spare tire
Inflation pressure .................. 353
Storage location .................... 318
Spark plug ................................ 351
Specifications .......................... 344
Speedometer ............................ 143
Steering
Column lock release ............. 131
Steering wheel
Adjustment .............................. 63
Stop lights
Replacing light bulbs............. 292
Wattage ................................ 354
Storage feature ........................ 230
Storage precautions ................ 161
Stuck
If your vehicle becomes
stuck ................................... 339R
S