2012 TOYOTA AURIS HYBRID headlights

218
2-3. Operating the lights and wipers
UK_AURIS_HV_EE
Headlight cleaner switch
The headlight cleaner can be operated when
The “POWER” switch is in ON mode and the headlight switch is turned on.
Windshield washer linked operation (vehicles with discharge head-
lights)
When the windshield washer is operated with the “POWER” switch in ON
mode and the headlights on, the headlight cleaner will operate once.
(P. 212)
NOTICE
When the washer fluid tank is empty
Do not use this function when the washer fluid tank is empty. This may
cause the washer fluid pump to overheat.
: If equipped
Washer fluid can be sprayed on the headlights.
Press the switch to clean the
headlights.

419 4-3. Do-it-yourself maintenance
4
Maintenance and care
UK_AURIS_HV_EE
Discharge headlights (if equipped)
If voltage to the discharge bulbs is insufficient, the bulbs may not come on,
or may go out temporarily. The discharge bulbs will come on when normal
power is restored.
LED light bulbs
The high mounted stoplight, side turn signal lights and daytime running lights
consist of a number of LEDs. If any of the LEDs burn out, take your vehicle
to any authorized Toyota dealer or repairer, or another duly qualified and
equipped professional to have the light replaced.
Condensation build-up on the inside of the lens
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional, for more information in the following situations.
Temporary condensation build-up on the inside of the headlight lens does
not indicate a malfunction.
Large drops of water are built up on the inside of the lens.
Water has built up inside the headlight.
When replacing light bulbs
P. 410
Installing the fender liner clip
Install the clip.

420 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
CAUTION
Replacing light bulbs
Turn off the lights. Do not attempt to replace the bulb immediately after
turning off the lights.
The bulbs become very hot and may cause burns.
Do not touch the glass portion of the light bulb with bare hands. Hold the
bulb by the plastic or metal portion.
If the bulb is scratched or dropped it may blow out or crack.
Fully install light bulbs and any parts used to secure them. Failing to do so
may result in heat damage, fire, or water entering the headlight unit. This
may damage the headlights or cause condensation to build up on the lens.
Discharge headlights (if equipped)
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional, before replacing discharge headlights (includ-
ing light bulbs).
Do not touch the high-intensity discharge headlight’s high voltage socket
when the headlights are turned on.
An extremely high voltage of 20000 V will be discharged and could result
in serious injury or death by electric shock.
Do not attempt to take apart or repair the low beam discharge headlight
bulbs, connectors, power supply circuits, or related components.
Doing so could result in electric shock and serious injury or death.
To prevent damage or fire
Make sure bulbs are fully seated and locked.

5
471
5-2. Steps to take in an emergency
When trouble arises
UK_AURIS_HV_EE
If the hybrid system will not start
If the hybrid system still does not start after following the correct
starting procedure (P. 175), confirm the following points.
The hybrid system will not start even if you are carrying the
correct key.
One of the following may be the cause of the problem.
The electronic key may not be functioning properly.*
(P. 474)
There may not be sufficient fuel in the vehicle’s tank. Refuel
the vehicle.
The electronic key battery may be discharged. (P. 474)
There may be a malfunction in the P position control system.
The hybrid system may be malfunctioning due to an electrical
problem such as an open circuit or a blown fuse. However,
depending on the type of malfunction, an interim measure is
available to start the hybrid system. (P. 472)
There may be a malfunction in the immobilizer system.*
(P. 107)
*: It may not be possible to shift out of P.
The interior lights and headlights are dim, or the horn does
not sound or sounds at a low volume.
One of the following may be the cause of the problem.
The 12-volt battery may be discharged. (P. 476)
The 12-volt battery terminal connections may be loose or cor-
roded.

472 5-2. Steps to take in an emergency
UK_AURIS_HV_EE
Emergency start function
When the hybrid system does not start, the following steps can be
used as an interim measure to start the hybrid system if the
“POWER” switch is functioning normally.
Set the parking brake.
Set the “POWER” switch to the ACCESSORY mode.
Push and hold the “POWER” switch for about 15 seconds
while depressing the brake pedal firmly.
Even if the hybrid system can be started using the above steps, the
system may be malfunctioning. Have the vehicle checked by any
authorized Toyota dealer or repairer, or another duty qualified and
equipped professional.
The interior lights and headlights do not turn on, or the horn
does not sound.
One of the following may be the cause of the problem.
One or both of the 12-volt battery terminals may be discon-
nected.
The 12-volt battery may be discharged. (P. 476)
Contact any authorized Toyota dealer or repairer, or another duly
qualified and equipped professional, if the problem cannot be
repaired, or if repair procedures are unknown.
STEP1
STEP2
STEP3

478 5-2. Steps to take in an emergency
UK_AURIS_HV_EE
Starting the hybrid system when the 12-volt battery is discharged
The hybrid system cannot be started by push-starting.
Avoiding a discharged 12-volt battery
Turn off the headlights and the audio system while the hybrid system is
turned off.
Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic, etc.
When the 12-volt battery is removed or discharged
If the 12-volt battery is depleted with the shift position in P, it will not be
possible to shift out of P. In this case, the vehicle cannot be towed without
lifting both front wheels because the front wheels are locked by the park-
ing lock. (P. 423)
The hybrid system may not start. (P. 384)
Charging the 12-volt battery
The electricity stored in the 12-volt battery will discharge gradually even
when the vehicle is not in use, due to natural discharge and the draining
effects of certain electrical appliances. If the vehicle is left for a long time, the
12-volt battery may discharge, and the hybrid system may be unable to start.
(The 12-volt battery recharges automatically while the hybrid system is oper-
ating.)
Once the hybrid system has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
Close the exclusive jump starting terminal cover and rein-
stall the fuse box cover.
Once the hybrid system starts, have the vehicle checked at any
authorized Toyota dealer or repairer, or another duly qualified and
equipped professional, as soon as possible.STEP7
STEP8

503 6-1. Specifications
6
Vehicle specifications
UK_AURIS_HV_EE
Light bulbs
A: HB3 halogen bulbs B: D4S discharge bulbs
C: H11 halogen bulbs D: Single end bulbs (amber)
E: Wedge base bulbs (clear) F: Wedge base bulbs (amber)
G: Double end bulbs
*
1: Vehicles without intrusion sensor
*
2: Vehicles with intrusion sensor
Light BulbsWTy p e
ExteriorHeadlights
High beam
Low beam (discharge bulbs)
Low beam (halogen bulbs)60
35
55A
B
C
Front turn signal lights 21 D
Front position lights 5 E
Front fog lights 55 C
Rear turn signal lights 21 F
Back-up lights 16 E
Rear fog light 21 E
Stop lights 16 E
Tail lights 5 E
License plate lights 5 E
InteriorVanity lights 8 E
Interior light 8 G
Personal lights6*1
5*2E
Luggage compartment light 5 G

515 Alphabetical index
UK_AURIS_HV_EE
Gas station information .......... 524
Gauges...................................... 193
Glove box ................................. 340
Hands-free phone system
(for cellular phone) ................ 309
Hazard lights
Switch ................................... 422
Head restraints
Adjusting ................................ 84
Headlight cleaner ..................... 218
Headlights
Discharge headlight
precautions ......................... 420
Replacing light bulbs ............. 411
Switch ................................... 206
Wattage................................. 503
Heaters
Seat heaters.......................... 350
Side mirror ............................ 251
Hood.......................................... 369
Horn .......................................... 192
Hybrid system
Emergency shut off system..... 35
Energy monitor........................ 36
High-voltage components ....... 34
If the hybrid system will not
start..................................... 471
Ignition switch ....................... 175
Indicator ................................ 195
Overheating .......................... 481
“POWER” switch ................... 175Identification
Engine................................... 493
Vehicle .................................. 493
Ignition switch ......................... 175
Illuminated entry system ........ 336
Immobilizer system ................. 107
Indicator lights ......................... 197
Inside rear view mirror .............. 92
Interior light
Interior light ........................... 336
Switch ................................... 337
Wattage ................................ 503
Jack
Positioning a floor jack .......... 371
Vehicle-equipped
jack ............................. 447, 459
Jack handle ...................... 447, 459
Keyless entry ............................. 44
Keys
Electronic key ......................... 42
Engine switch........................ 175
If the electronic key does
not operate properly ........... 474
If you lose your keys ............. 473
Ignition switch ....................... 175
Key number plate.................... 42
Keyless entry .......................... 44
Keys ........................................ 42
Mechanical key ....................... 42
“POWER” switch ................... 175
Wireless remote control key ... 70G
H
I
J
K