2012 RAM CHASSIS CAB wheel

8. Reach through the access hole of the wheel house
splash shield and lift the slide lock upward far enough to
disengage it from the lock post on the back of the front
lamp unit housing.
9. Remove the headlamp assembly. Grasp the outboard
edge of the lamp and pull it straight forward to disen-
gage the ball stud from the plastic grommet. 10. Disconnect electrical connectors.
11. Replace bulb(s) as necessary.
CAUTION!• Do not contaminate the bulb glass by touching it
with your fingers or by allowing it to contact other
oily surfaces. Shortened bulb life will result.
• Always use the correct bulb size and type for
replacement. An incorrect bulb size or type may
overheat and cause damage to the lamp, the bulb
socket, or the lamp wiring.
NOTE: There are access covers over both headlamp
bulb access holes in the quad front lamp unit housing (if
equipped). These covers MUST be reinstalled after the
bulb has been replaced.444 MAINTAINING YOUR VEHICLE

24,000 Miles (39,000 km) or
18 Months Maintenance
Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
24,000 miles (39 000 km).
❏ Lube the front drive shaft fitting (4x4
only).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Inspect the front and rear axle fluid,
change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer
towing. Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center 32,000 Miles (52,000 km) or 24 Months Maintenance Service
Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
32,000 miles (52 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the spark plugs.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Inspect the transfer case fluid.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S 458 MAINTENANCE SCHEDULES

64,000 Miles (104,000 km) or 48 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 64,000 miles (104 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the spark plugs.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Inspect the brake linings; replace if necessary.
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Change the automatic transmission fluid and filter(s) if using your vehicle for any of the following: police, taxi, fleet, snow plowing, or
frequent trailer towing.
❏ Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play;
replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 461

96,000 Miles (156,000 km) or 72 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 96,000 miles (156 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the spark plugs.
❏ Inspect and replace PCV valve if necessary.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Inspect the transfer case fluid.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play;
replace if necessary.
❏ Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S 464 MAINTENANCE SCHEDULES

128,000 Miles (208,000 km) or 96 Months Maintenance Service
Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
128,000 miles (208 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the spark plugs.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Change the transfer case fluid.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center 136,000 Miles (221,000 km) or
102 Months Maintenance
Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
136,000 miles (221 000 km).
❏ Lube the front drive shaft fitting (4x4
only).
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 467

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel, than the minimum required by law. WARNING!The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.480 IF YOU NEED CONSUMER ASSISTANCE

Carbon Monoxide Warning ............... 78,339
Cargo Light ............................ 152
Cellular Phone ........................ 93,255
Center High Mounted Stop Light ............ 445
Center Lap Belts ......................... 48
Center Seat Storage Compartment ............ 176
Certification Label ....................... 342
Chart, Tire Sizing ........................ 310
Check Engine Light
(Malfunction Indicator Light) ............. 199,403
Checking Your Vehicle For Safety ............. 77
Checks, Safety ........................... 77
Child Restraint ........................ 64,65
Child Restraint Tether Anchors ............. 68,73
Child Seat .............................. 70
Cigar Lighter ........................... 169
Cleaning
Wheels ............................ 432
Climate Control ......................... 256 Clock ............................. 223,232
Cold Weather Operation ................... 274
Compact Disc (CD) Maintenance ............. 255
Compact Spare Tire ...................... 325
Compass .............................. 214
Compass Calibration ..................... 215
Compass Variance ....................... 215
Computer, Trip/Travel .................... 212
Connector
UCI .............................. 246
Universal Consumer Interface (UCI) ....... 246
Console, Overhead ....................... 163
Contract, Service ........................ 475
Coolant Pressure Cap (Radiator Cap) .......... 419
Cooling System ......................... 417
Adding Coolant (Antifreeze) ............. 418
Coolant Capacity ..................... 449
Coolant Level .................... 417,420
Disposal of Used Coolant ............... 420484 INDEX

Drain, Flush, and Refill ................ 417
Inspection .......................... 420
Points to Remember .................. 422
Pressure Cap ........................ 419
Radiator Cap ....................... 419
Selection of Coolant (Antifreeze) ....... 418,450
Cupholders ............................ 172
Customer Assistance ..................... 473
Data Recorder, Event ...................... 63
Daytime Running Lights ................... 153
Dealer Service .......................... 405
Defroster, Rear Window ................... 180
Defroster, Windshield ................ 80,258,264
Delay (Intermittent) Wipers ................. 155
Differential, Limited-Slip .................. 298
Dipsticks
Automatic Transmission ................ 428
Power Steering ...................... 303 Disabled Vehicle Towing ................... 395
Disposal
Antifreeze (Engine Coolant) ............. 420
Door Locks ............................. 30
Door Locks, Automatic .................... 32
Driving
Through Flowing, Rising, or Shallow
Standing Water ...................... 300
Dual Rear Wheels ..................... 334,384
Electric Rear Window Defrost ............... 180
Electrical Power Outlets ................... 165
Electronic Range Select (ERS) ............... 284
Electronic Speed Control (Cruise Control) ...... 160
Electronic Vehicle Information Center (EVIC) .... 203
Electronically Shifted Transfer Case ........... 292
Emergency Brake ........................ 304
10 INDEX 485