2012 Ram 5500 Chassis Cab radiator

•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, contents of
coolant recovery bottle must also be protected against
freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine coolant (antifreeze)
performance, poor gas mileage, and increased
emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
7
MAINTAINING YOUR VEHICLE 427

BULB REPLACEMENT
Dual Or Quad Headlamp/Front Park And Turn
Signal – If Equipped
1. Open the hood.
2. Disconnect and isolate the negative battery cable.
3. Remove the four plastic push-in fasteners that secure
the upper radiator seal to the grille support and both
fender ledges.
4. Remove the two plastic push-in rivets that secure the
upper radiator seal to the radiator.
5. Remove the upper radiator seal from the vehicle.
6. Remove the two headlamp assembly attachment
screws.7. Reach into the front wheel house ahead of the front
wheel, remove the fastener, and lift the cover over the
access hole in the front of the wheel house splash shield.
Access to the rear of the lamp can be gained through this
access hole.
7
MAINTAINING YOUR VEHICLE 447

Automatic Transmission
Adding Fluid....................... 433
Fluid and Filter Changes............... 434
Fluid Level Check.................432,433
FluidType ......................432,455
Shifting ........................... 284
Special Additives..................... 432
AxleFluid .......................430,431,455
Axle Lubrication (Axle Fluid)............430,431
B-Pillar Location........................ 320
Battery............................... 414
Keyless Transmitter Replacement (RKE)..... 25
Saving Feature (Protection).............. 152
Belts, Seat............................ 40,80
Body Builders Guide....................... 6
Body Mechanism Lubrication............... 417
Brake Fluid.........................428,455Brake System........................312,427
Anti-Lock (ABS)..................... 313
Fluid Check........................ 428
Master Cylinder..................... 428
Parking........................... 310
Warning Light....................... 198
Brake/Transmission Interlock............... 284
Bulb Replacement....................... 447
Bulbs,Light .......................... 82,446
Cab Top Clearance Lights.................. 451
Calibration, Compass..................... 216
Capacities, Antifreeze (Engine Coolant)........ 453
Capacities, Fluid........................ 453
Caps, Filler
Oil (Engine)........................ 412
Power Steering...................... 309
Radiator (Coolant Pressure)............. 424
Car Washes............................ 435
10
INDEX 487

Carbon Monoxide Warning............... 79,345
CargoLight ............................ 152
Cellular Phone........................ 93,262
Center High Mounted Stop Light............ 449
Center Lap Belts......................... 49
Center Seat Storage Compartment............ 176
Certification Label....................... 347
Chart, Tire Sizing........................ 316
Check Engine Light
(Malfunction Indicator Light).............200,407
Checking Your Vehicle For Safety............. 78
Checks, Safety........................... 78
Child Restraint.......................... 65
Child Restraint Tether Anchors............. 69,74
Child Seat............................ 65,71
Cigar Lighter........................... 169
Cleaning
Wheels............................ 437
Climate Control......................... 262Clock .............................225,234
Cold Weather Operation................... 280
Compact Disc (CD) Maintenance............. 262
Compact Spare Tire...................... 331
Compass.............................. 215
Compass Calibration..................... 216
Compass Variance....................... 217
Computer, Trip/Travel.................... 213
Connector
UCI .............................. 249
Universal Consumer Interface (UCI)....... 249
Console, Overhead....................... 163
Contract, Service........................ 479
Coolant Pressure Cap (Radiator Cap).......... 424
Cooling System......................... 421
Adding Coolant (Antifreeze)............. 423
Coolant Capacity..................... 453
Coolant Level....................421,425
Disposal of Used Coolant............... 425
488 INDEX

Drain, Flush, and Refill................ 422
Inspection.......................... 425
Points to Remember.................. 426
Pressure Cap........................ 424
Radiator Cap....................... 424
Selection of Coolant (Antifreeze).......422,454
Cupholders............................ 172
Customer Assistance..................... 477
Data Recorder, Event...................... 64
Daytime Running Lights................... 153
Dealer Service.......................... 409
Defroster, Rear Window................... 180
Defroster, Windshield................ 80,265,271
Delay (Intermittent) Wipers................. 155
Differential, Limited-Slip.................. 304
Dipsticks
Automatic Transmission................ 433
Power Steering...................... 309Disabled Vehicle Towing................... 399
Disposal
Antifreeze (Engine Coolant)............. 425
Door Locks............................. 29
Door Locks, Automatic.................... 31
Driving
Through Flowing, Rising, or Shallow
Standing Water...................... 306
Dual Rear Wheels.....................340,388
Electric Rear Window Defrost............... 180
Electrical Power Outlets................... 165
Electronic Range Select (ERS)............... 290
Electronic Speed Control (Cruise Control)...... 160
Electronic Vehicle Information Center (EVIC).... 204
Electronically Shifted Transfer Case........... 298
Emergency Brake........................ 310
10
INDEX 489

Sliding Rear Window.................. 181
Steering........................308,309
Windows........................... 35
Power Steering Fluid..................... 455
Pregnant Women and Seat Belts.............. 53
Programmable Electronic Features............ 218
Programming Transmitters
(Remote Keyless Entry).................... 20
Radial Ply Tires......................... 330
Radiator Cap (Coolant Pressure Cap).......422,424
Radio Operation........................ 262
Radio, Satellite (Uconnect™ studios).......... 256
Rear Axle (Differential).................430,431
Rear Window Features.................... 180
Rear Window, Sliding..................... 181
Reclining Front Seats..................... 138
Recorder, Event Data...................... 64Recreational Towing...................... 368
Shifting into Transfer Case Neutral (N) . . 371,373
Shifting out of Transfer
Case Neutral (N)..................372,376
Reformulated Gasoline.................... 342
Refrigerant............................ 416
Reminder, Seat Belt....................... 52
Remote Control
Starting System....................... 26
Remote Keyless Entry (RKE)................. 20
Remote Sound System (Radio) Controls........ 260
Remote Starting System.................... 26
Replacement Keys........................ 17
Replacement Parts....................... 408
Replacement Tires....................... 334
Reporting Safety Defects................... 480
Resetting Oil Change Indicator...........196,212
Restraint, Head......................... 139
Restraints, Child....................... 65,71
10
INDEX 497