2012 Ram 5500 Chassis Cab heater

NORMAL OPERATION – DIESEL ENGINE
Observe the following when the engine is operating.
•All message center lights are off.
•Malfunction Indicator Light (MIL) is off.
•Engine oil pressure is above 10 psi (69 kPa) at idle.
•Voltmeter operation:
•The voltmeter may show a gauge fluctuation at
various engine temperatures. This cycling operation
is caused by the post-heat cycle of the intake mani-
fold heater system. The number of cycles and the
length of the cycling operation is controlled by the
engine control module. Post-heat operation can run
for several minutes, and then the electrical system
and voltmeter needle will stabilize.
•The cycling action will cause temporary dimming of
the headlamps, interior lamps, and also a noticeable
reduction in blower motor speed.
Cold Weather Precautions
Operation in ambient temperature below 32°F (0°C) may
require special considerations. The following charts sug-
gest these options:
Fuel Operating Range
NOTE:Use “Ultra Low Sulfur Diesel Fuels” ONLY.
4
STARTING AND OPERATING 41

Do Not Operate The Engine With Failed Parts
Practically all failures give some warning before the parts
fail. Be on the alert for changes in performance, sounds,
and visual evidence that the engine requires service.
Some important clues are:
•engine misfiring or vibrating severely
•sudden loss of power
•unusual engine noises
•fuel, oil or coolant leaks
•sudden change, outside the normal operating range, in
the engine operating temperature
•excessive smoke
•oil pressure drop
ENGINE BLOCK HEATER — IF EQUIPPED
The engine block heater warms engine coolant and
permits quicker starts in cold weather. Connect the heater
cord to a ground-fault interrupter protected 110–115 Volt
AC electrical outlet with a grounded, three-wire exten-
sion cord.
The engine block heater cord is routed under the hood to
the right side and can be located just behind the grille
near the headlamp.
NOTE:The engine block heater cord is a factory in-
stalled option. If your vehicle is not equipped, heater
cords are available from your authorized MOPAR
dealer.
The block heater must be plugged in at least one hour to
have an adequate warming effect on the coolant.
4
STARTING AND OPERATING 49

WARNING!
Remember to disconnect the cord before driving.
Damage to the 110–115 Volt electrical cord could
cause electrocution.
NOTE: The block heater will require 110 Volts AC and
6.5 Amps to activate the heater element.
Block Heater Usage
For ambient temperatures below 0°F (-18°C), engine
block heater usage is recommended.
For ambient temperatures below –20°F (-29°C), engine
block heater usage is required.
DIESEL EXHAUST BRAKE (ENGINE BRAKING) —
IF EQUIPPED
The exhaust brake feature will only function when the
driver turns the exhaust brake switch to the ON position. Once the switch is in the ON position and the vehicle is
moving faster than 5 mph (8 km/h); the exhaust brake
will automatically operate when the driver removes
pressure from the accelerator pedal. Exhaust braking is
most effective when the engine RPM is higher. The
automatic transmission has been programmed in TOW/
Exhaust Brake Switch
50 STARTING AND OPERATING

JUMP STARTING
WARNING!
•To prevent personal injury or damage to clothing,
do not allow battery fluid to contact eyes, skin or
fabrics. Do not lean over a battery when connect-
ing jumper cables or allow cable clamps to touch
each other. Keep open flames or sparks away from
battery vent holes. Always wear eye protection
when working with batteries.
•Do not use a booster battery or any other booster
source that has a greater than 12 Volt system, i.e.,
do not use a 24 Volt power source.
NOTE: Replacement batteries should both be of equal
size to prevent damage to the vehicle’s charging system.
Your vehicle is equipped with two 12 Volt batteries. If it
becomes necessary to use a booster battery with jumper cables to start a vehicle’s engine because its batteries are
discharged, the following procedure should be used:
Set the parking brake and place an automatic transmis-
sion in PARK (or NEUTRAL for a manual transmission).
Turn off lights, heater and other electrical loads. Observe
charge indicator (if equipped) in both batteries. If the
indicator (if equipped) is light or yellow on either battery,
replace that battery.
CAUTION!
Use the jump start procedure only when the charge
indicator (if equipped) in both batteries is dark in the
center. Do not attempt jump starting when either
battery charge indicator (if equipped) is bright or
yellow. If the charge indicator (if equipped) has a
green dot in the center, failure to start is not due to a
discharged battery and cranking system should be
checked.
92 WHAT TO DO IN EMERGENCIES

Coolant Capacity..................... 133
Coolant Level .................... 1 15,119
Disposal of Used Coolant ............... 119
Drain, Flush, and Refill ................ 116
Inspection .......................... 119
Points to Remember .................. 120
Pressure Cap ........................ 118
Radiator Cap ........................ 118
Selection of Coolant (Antifreeze) ....... 116,134
Diesel Exhaust Brake ...................... 50
Diesel Fuel ............................. 82
Diesel Fuel Requirements ................... 82
Bulk Storage of ....................... 84
Diesel Fuel System, Re-Priming .............. 110
Dipsticks .............................. 100
Disposal .............................. 104
Antifreeze (Engine Coolant) ............. 119
Engine Oil ......................... 104 Draining Fuel/Water Separator Filter
.......... 106
Electronic Range Select (ERS) ..............60,71
Electronic Vehicle Information Center (EVIC) ..... 25
Emergency, In Case of Jump Starting ........................ 92
Engine ................................ 99
Air Cleaner ......................... 104
Block Heater ....................... 35,49
Break-In Recommendations .............. 12
Compartment ........................ 99
Coolant (Antifreeze) .................. 134
Identification ........................ 99
Idling ............................. 44
Jump Starting ........................ 92
Oil ............................ 100,134
Oil Filler Cap ....................... 103
Oil Synthetic ........................ 104
Runaway ........................... 81
8
INDEX 165

Signals, Turn............................ 15
Speedometer ............................ 16
Starting .............................. 8,34
Automatic Transmission ................ 34
Engine Block Heater ................. 35,49
Manual Transmission .................. 34
Remote ............................. 8
Starting Procedures ....................... 34
Starting Procedures (Diesel Engines) ........... 34
Steering Wheel Lock .......................... 8
Synthetic Engine Oil ...................... 104
System, Remote Starting .................... 8
Tachometer ............................. 15
Temperature Gauge, Engine Coolant ........... 15
Tip Start ............................... 34
Ti re s Pressure Warning Light ................. 21 Torque Converter Clutch
.................63,74
Tow/Haul ............................. 62
Traction Control ......................... 123
Traction Control Light ..................... 17
Transfer Case Fluid ............................. 136
Transmission Automatic ........................ 54,64
Fluid ............................. 136
Manual .......................... 34,75
Shifting ............................ 52
Trip Odometer ........................ 17,18
Turn Signals ............................ 15
Viscosity, Engine Oil ...................... 103
Voltmeter ............................ 18,41
Warning Lights (Instrument Cluster Description) . . 15
Water Separator, Diesel Fuel ................ 106
8
INDEX 169