2012 PEUGEOT 4008 particle filter

1
39
Instruments and controls
Screen 1Screen 2CauseSolution - ActionObservations
Fault with the CVT gearbox. Contact a PEUGEOT dealer or
a qualified workshop.
The temperature of the four wheel
drive transmission system is toohigh. Stop the vehicle and contact
a PEUGEOT dealer or a qualified workshop. The vehicle chan
ges automatically
to two wheel drive (2WD).
Th
e fuel level is low. Refuel as soon as possible.
The low level o
f the particleemissions filter additive reservoir has been reached.
Have the reser voir topped up as
soon as possible by a PEUGEOT
dealer or a qualified workshop.
Only for the 1.6 litre HDi engine.
+Star t of saturation of the par ticle
emissions filter. As soon as the driving conditions
allow, regenerate the filter by driving at
a speed of at least 25 mph (40 km/h)
for around 20 minutes (with the 1.6 litre HDi engine the minimum speed is
36 mph (60 km/h)). If the messa
ge remains on, contact a PEUGEOT or a qualified
workshop.
The par ticle emissions filter is fault
y. Stop as soon as it is safe to do so. Contact a PEUGEOT dealer or
a qualified workshop as soon as
possible.

213
8
Checks
Avoid prolonged contact of used oil or fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.

Do not discard used oil or fluids into sewers or onto the ground.
Take used oil to a PEUGEOT dealer or a qualified workshop (France) or to anauthorised waste disposal site.








Used products
To p p i ng up
The reser voir must be topped up without delay
by a PEUGEOT dealer or a qualified workshop.
Additive level (1.6 HDi
110 Diesel versions with
particle emissions filter
)
The additive reser voir low level is indicated bythe display of this message.

Fluid specifi cation

For optimum cleaning and to avoid freezing,
this fluid must not be topped up with or
replaced with plain water.
Screenwash and headlamp
wash fluid
In the case of vehicles fitted withheadlamp washers, the low fluid levelis indicated by an audible signal anda message in the instrument panelscreen.
Top up the reser voir when you next stop the
vehicle.

215
8
Checks
Manual gearbox
Refer to the servicing booklet for maintenance of the gearbox.
"CVT" gearbox
Refer to the servicing booklet for maintenance of the "CVT" gearbox.
Particle emissions filter (Diesel)

The star t of saturation of the particle filter is
indicated by the temporary illumination of this
warning lamp accompanied by a message in
the instrument panel screen.
As soon as the traffic conditions permit,regenerate the filter by driving at a speed of at least 25 mph (40 km/h) for about 20 minutes (with the 1.6 litre HDiengine the minimum speed is 36 mph(60 km/h)). If the warning lamp stays on, this indicates a low additive level.
On a new vehicle, the first particle filter regeneration operations may be accompanied by a "burning" smell, which is perfectly normal.Following prolonged operation of the vehicle at very low speed or at idle,
you may, in exceptional circumstances,notice the emission of water vapour at the exhaust on acceleration. This doesnot affect the behaviour of the vehicle or the environment.

9
219
Technical data
DIESEL ENGINES1.6 HDi 1101.8 HDi 150
Model codes:BU...9HD8/S9HDB/S6HZ8/S6HZB6HZB/S
Transmission mode2WD4WD2WD4WD
Cubic capacity (cc)
1 560
1 798
Bore x stroke
(mm)
77 x 88.3
83 x 83.1
Max power: EU standard
(kW) 84 110

Max power engine speed (rpm) 3 600

4 000

Max torque: EU standard
(Nm)

270 300
Max torque en
gine speed (rpm) 1 750

2 000 to 3 000

F
uel
Diesel Diesel
Catal
ytic converter Yes

Yes

Particle emission
filter (PEF) Yes

Yes

GEARBOXE
S Manual(6-speed)
Manual(6-speed)
OIL CAPACITY (in litres)

Engine (with filter replacement) 3.75
5.3
.../S: model fitted with the Stop & Star t (AS&G) function.














Engines and gearboxes

.
323
Alphabetical index
Key in ignition warning..................................106Keyless Entry and Star ting...............64-67, 107Key with remote control ....................60, 62,110
Labels, identification.....................................222Lamps, front..................................................180Lamps, rear...................................................r184Lamps, warning and indicator...................r25-42LED daytime running lamps..........................182Level, brake fluid...........................................212Level, headlamp wash..................................213Levels and checks.................................205-216Lighting, guide-me home .............................. 135Lighting, interior.....................................r142-144Lighting bulbs (replacement).................180-185Lighting control stalk.....................................131Lighting dimmer..............................................r59Lighting on reminder.....................................r133Loading............................................................22Long objects, transpor ting..............................84
Low fuel level................................................208Luggage retaining strap ................................ 104
Main beam .................................... 136, 180,182Maintenance....................................................22Map (colour screen)......................................227Map reading lamps .......................................142Markings, identification.................................222Mat..................................................................99Match telephone ...................................269, 312
Navigation.............................................226-235Number plate lamps ..............................184, 185
Oil filter..........................................................r214Oil level..........................................................211Opening the bonnet......................................205Opening the boot................................60, 64,71Opening the doors ..............................60,64, 70Opening the fuel filler flap .............................208Operation indicator lamps.........................25-42
Radio .....................................................236,291Range..............................................................46RCA sockets .................................................304Rear foglamp.................................13 3, 184,185Rear screen (demisting)..................................97Recharging the battery.................................194Recirculation / exterior air intake..............91, 9 4Regeneration of the particleemissions filter............................................r215Remote control..........................................60-69Removing a wheel........................................176Removing the mat...........................................99Repair kit, puncture.......................................170Replacing bulbs.....................................180-185Replacing fuses.....................................186-191Replacing the air filter...................................r214Replacing the oil filter...................................r214Replacing the passenger compartment filter......................................r214Replacing wiper blades .................................195Rev counter.....................................................r24Reversing camera.........................................130Roof bars.......................................................201Roof blind ........................................................78Routine checks ......................................214-216Running out of fuel (Diesel)..........................210
L
M
N
O
R
Menus (audio)...............................................225Mirror, rear view..............................................87Mirrors, door....................................................r85Motorway function (direction indicators) ....... 145Mountings for ISOFIX seats.................164,167MP3 CD.................................................240, 299Music server..........................................r240-251
Player, CD MP3.....................................240, 299Port, USB.............................102,264, 304, 305Priming the fuel system ................................210Protecting children........................ 155, 159 -169Puncture........................................................170
Panoramic glass sunroof................................f78Parcel shelf, rear...........................................r105Parking brake........................................110, 216Parking sensors, front...................................129Parking sensors, rear............................r127, 128Particle emission filter..........r205,212,213, 215Passenger compartment filter......................r214
P

328
Visual search
Maintenance - Technical data
Engine compartmentfuses 18 6, 189 -191


Running out of fuel, Diesel 210
Checking levels 211-213 - oil - brake fluid - coolant - screenwash/headlamp wash fluid

Changing bulbs 180 -185 - front - rear




Petrol engines 217
Petrol weights 218
Diesel engines 219
Diesel weights 220
Dimensions 221
Identification markings 222


Bonnnet 205
Petrol engine compartment 206
Diesel engine compar tment 207
Battery 192-19 4
Automatic cut of powersupply to accessories 195
Checking components 214 -216 - battery electrolyte - air filter - oil filter - particle emissions filter (Diesel) - brake pads / discs