2012 PEUGEOT 107 engine oil

18
Limit the causes of excess
consumption
Spread loads throughout the vehicle; placethe heaviest items in the bottom of the boot,as close as possible to the rear seats.Limit the loads carried in the vehicle andreduce wind resistance (roof bars, roof rack, bicycle carrier, ...). Use a roof box inpreference.Remove roof bars and roof racks after use.

At the end of winter, remove snow tyres and refit your summer tyres.


Observe the recommendations
on maintenance

Check the tyre pressures regularly, when cold, referring to the label in the door aper ture, driver's side.
Carry out this check in par ticular:


- before a long journey,

- at each change of season,

- after a long period out of use.
Don't forget the spare wheel.


Have your vehicle ser viced regularly (engine oil, oil filter, air filter...) and obser ve the schedule of operations recommended by themanufacturer.


When refuelling, do not continue after the 3rd
cut-off of the nozzle to avoid any overflow.

At the wheel of your new vehicle, it is onlyafter the first 1 800 miles (3 000 kilometres) that you will see the fuel consumption settle down to a consistent average.

Instruments and controls
20





Warning lamps
Warning lampis onCauseAction/Observations



Parking brake

fixed. The parking brake is applied or not properly released. With
your foot on the brake pedal, release the parking brake
to switch off the warning lamp.
Observe the safety recommendations.
For more information, refer to the "Parkin
g brake" section.



STOP

fixed, associated
with another warning lamp.It is associated with the en
gine
oil pressure or the engine coolant temperature. Stop as soon as it is safe to do so.
Park, switch off the ignition and call a PEUGEOT dealer or qualified workshop.



Engine oilpressure

fixed, associated
with the STOP warning lamp.The en
gine oilpressure is too low.
Stop as soon it is safe to do so.
Park, switch off the ignition and contact a PEUGEOT dealer or a qualified workshop.



Braking


fixed. The braking system fluid level has dropped significantly. Top up with brake
fluid recommended by PEUGEOT.
If the problem persists, have the system checked by a
PEUGEOT dealer or a qualified workshop.
+

fixed, associated
with the ABSwarning lamp.The braking systemhas a fault. Stop as soon as it is safe to do so. Park, switch off the ignition
and contact a PEUGEOT dealer or a qualified workshop.

10
85 Checks
1. Coolant header tank2.Screenwash fluid reservoir 3.Brake fluid reservoir 4.Fusebox
5.Battery6. Air filter 7.Engine oil dipstick8.
Engine oil filler cap












Engine

86Checks






Checking levels
There are two marks on thedipstick:A= maximum
If you fill past this mark, contact a PEUGEOT dealer or a qualified workshop. B= minimum
Never allow the level to fallbelow this mark.
Dipstick
Brake fluid level

The brake fluid level should be close to the
"MA X" mark. If it is not, check the brake pad
w
ear. If a level drops si
gnificantly, have the corresponding system checked by a PEUGEOT dealer or a
qualified workshop.
Check all of these levels re
gularly and top them up if necessary, unless other wise indicated.
Take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns).
Oil level
The check is carried out either when the ignition is switched on using the oil level indicator on the instrument panel, or using the
dipstick.
This manual check will only be correct if the
vehicle is on level ground and the engine has
been off for more than 30 minutes.
It is normal to top up the oil level between two ser vices (or oil changes). PEUGEOT recommends that you checkthe level, and top up if necessary, every 3 000 miles (5 000 kms). After topping up the oil, the check whenswitching on the ignition with the oillevel indicator in the instrument panelis not valid during the 30 minutes after topping up.


Engine oil change

Refer to the servicing booklet for details of the
interval for this operation.
In order to maintain the reliabilit
y of the engine
and emission control system, the use of
additives in the engine oil is prohibited.

Oil specifi cation

The oil must be the correct grade for your engine and conform to the manufacturer'srecommendations.



Changing the fl uid

Refer to the servicing booklet for details of the
interval for this operation.

10
87 Checks
Screenwash fluid level
Top up the level when necessary.
Coolant level
Fluid specifi cation
For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.



Fluid specifi cation

The brake fluid must conform to themanufacturer's recommendations and meet the
D
OT4 standard.


The coolant level should be close to the "MAX" mark but should never exceed it.
When the engine is warm, the temperature of
the coolant is regulated by the fan. This can
operate with the ignition off.
In addition, as the cooling system is pressurised, wait at least one hour after switching off the engine before carrying out anywork.
To avoid any risk of scalding, unscrew the cap by two turns to allow the pressure to drop.
When the pressure has dropped, remove thecap and top up the level.
Changing the coolant
The coolant does not have to be changed.
Fluid specifi cation
The coolant must conform to the
manufacturer's recommendations.









Used products
Avoid prolonged contact of used oil or fluids
with the skin.
M
ost of these fluids are harmful to health or indeed very corrosive.
Do not discard used oil or fluids intosewers or onto the ground.Take used oil to a PEUGEOT dealer or a qualified workshop (France) or to an authorised waste disposal site.

88Checks






Checks






2 Tronic gearbox















Brake pads
Unless other wise indicated, check thesecomponents in accordance with the servicingbooklet and according to your engine.
Other wise, have them checked by a PEUGEOT
dealer or a qualified workshop.
12 V battery
Oil filter
Manual gearbox
Only use products recommended byPEUGEOT or products of equivalent quality and specification.
In order to optimise the operation of units as impor tant as the brakingsystem, PEUGEOT selects and offers very specific products. To avoid damaging the electrical units, the use of a high pressure washer in the engine compar tment is strictlyprohibited.
Air filter and passenger compartment filter

Brake disc wear
Parkin
g brake
The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
When carrying out work on the battery, refer to the "Practical information" section for details of the precautions
to be taken before disconnecting the battery and following its reconnection.

Refer to the ser vicing booklet for
details of the replacement intervals
for these components.
Dependin
g on the environment (e.g.
dusty atmosphere) and the use of the vehicle (e.g. city driving), replace them twice as often if necessary.y A clogged passenger compar tment filter mayhave an adverse effect on the performance
of the air conditioning system and generate undesirable odours.
Replace the oil
filter each time theengine oil is changed.
Refer to the ser vicing booklet for
details of the replacement inter val for
this component.
The gearbox does not require any maintenance (no oil change).
Refer to the ser vicing booklet for the
details of the level checking intervalfor this component.
The
2 Tr o n i c gearbox does not require
any maintenance (no oil change).
Refer to the servicing booklet for
details of the checking inter val for
this unit.
Brake wear depends on the st
yle
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It ma
y be necessary to
have the condition of the brakes checked
, even between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake pads are worn. For information on checkin
g brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.

I
f excessive travel or a loss of effectiveness of this system is
noticed, the parking brake must be checked, even between two services.
Checking this system must be done by a
PEUGEOT dealer or a qualified workshop.

11
89 Technical data








Engine
Engine
1.0 litre (≈ 68 hp)
Manual gearbox(5-speed)2 Tronic gearbox(5-speed)
Model codes PM, PNCFB0 / CFB4
CFB0/P

Cubic capacity (cc)
998

Bore x stroke (mm) 71 x 84

EU standard maximum power (kW)
50

Max power engine speed (rpm)
6 000


EU standard max torque (Nm)93

Max torque engine speed (rpm) 3 600


Fuel
Unleaded

Catalytic converter

Yes


Engine oil capacity (with filter replacement)
3.2

.
133 Alphabetical index
2 Tronic gearbox .............16, 19, 22, 24, 42, 43,77,88Backup starting .............................................76Battery...............................................76-78, 88Battery, charging ...........................................77Bluetooth (hands-free)................................104Bonnet...........................................................84Boot...............................................................41Brake discs....................................................88Brake lamps ..................................................69Brake pads ....................................................88Brakes ...........................................................88
Capacity, fuel tank........................................30CD changer..........................................r124-127CD MP3.................................................98-100Central locking..............................................26Changing a bulb ......................................67,68Changing a fuse ............................................71Changing a wheel .........................................65Changing the remotecontrol battery.............................................27Changingthe time...............................................25, 117Checking levels.......................................86,87Checking the engineoil level ........................................................86Checks ..........................................................88Child lock.......................................................28Children...................................................28, 63Child seats.......................................57,59, 60Child seats,conventional................................................59Coolant level .................................................87Courtesy mirror.............................................r40Cup holder.....................................................r40
B
C
Deactivatingthe passenger airbag..................................55Defrosting ......................................................33Demisting......................................................33Dimensions...................................................91Dipped beam.....................................44, 67, 68Dipstick..........................................................86Direction indicators...........................44, 67-69Display screen..............................................23Doors.............................................................28Driver''s seat belt notfastened warning lamp.........................22, 52Driving mode.................................................42
Easy mode(automatic mode) ........................................42Eco-driving...................................................17Eco-driving (advice)......................................17Economicaldriving ........................................................17Electronic engineimmobiliser..................................................27Electronic stability control (ESP)...........................................................50Engine...............................................85, 89,90Engine, petrol ................................................31Engine compartmentfusebox.......................................................71Engine oil ................................................85,86Engine oil levelindicator......................................................r86Engines.........................................................89Environment ..................................................17ESP ...............................................................50
E
ABS...............................................................49Accessories..............................................4, 82Access to rear seats(3-door) .......................................................38Adjusting headlamps....................................46Adjusting the steering wheel.........................37Airbag fault..............................................54, 55Airbags ..............................................21, 54, 55Airbags, curtain .......................................55,56Airbags, front.................................................56Airbags, lateral........................................55,56Airbag warning lamp.....................................54Air conditioning.......................................12, 17Air conditioning, manual.........................13, 35Air conditioning on/off...................................f35Air distribution adjustment......................34, 35Air filter..........................................................r88Air flow..............................................17,34, 35Air flow adjustment .................................34, 35Air vents..................................................33-35Anti-lock braking system (ABS)....................49Anti-theft........................................................26ASR...............................................................50Assistance, emergency braking...................49Audible warning............................................48Audio equipment(general).......................................25, 117,118Audio streaming(Bluetooth)................................................103Audio system (CD/CD changer)..........124-127Audio system (radio)................... 119,120,122Auxiliary socket ..............................40, 117,118
A
D