2012 Lexus CT200h Battery

43
1
1-1. Hybrid system
Before driving
CT200h_OM_OM76067E_(EE)
Hybrid system precautions
Take care when handling the hybrid system, as it contains a high volt-
age system (about 650V at maximum) as well as parts that become
extremely hot when the hybrid system is operating. Obey the caution
labels attached to the vehicle.
Air conditioning compressor
Power control unit
Hybrid battery (traction bat-
tery)
Service plug High voltage cables
(orange)
Electric motor (traction
motor)
Caution label

44
1-1. Hybrid system
CT200h_OM_OM76067E_(EE)
Hybrid battery air vent
There is an air intake vent on
the side of the rear right seat-
back for the purpose of cooling
the hybrid battery (traction bat-
tery). If the vent become
blocked, the hybrid battery may
overheat, leading to a reduction
in hybrid battery output.
Emergency shut off system
When a certain level of impact is detected by the impact sensor, the
emergency shut off system blocks off the high voltage current and
stops the fuel pump to minimize the risk of electrocution and fuel
leakage. If the emergency shut off system activates, your vehicle
will not restart. To restart the hybrid system, contact any autho-
rized Lexus dealer or repairer, or another duly qualified and
equipped professional.

45
1-1. Hybrid system
1
Before driving
CT200h_OM_OM76067E_(EE)
Hybrid warning message
A message is automatically displayed when a malfunction occurs
in the hybrid system or an improper operation is attempted.
If a warning message is shown
on the multi-information dis-
play, read the message and fol-
low the instructions.
(P. 578)
If a warning light comes on, a warning message is displayed, or the 12-volt
battery is disconnected
The hybrid system may not start. In that case, try to start the system again. If
the “READY” indicator does not come on, contact any authorized Lexus
dealer or repairer, or another duly qualified and equipped professional.
Running out of fuel
When the vehicle has run out of fuel and the hybrid system cannot be
started, refuel the vehicle with at least enough gasoline to make the low fuel
level warning light (P. 575) go off. If there is only a small amount of fuel,
the hybrid system may not be able to start. (The minimum amount of fuel to
add to make the low fuel level warning light go out is about 11.8 L [3.1 gal.,
2.6 Imp.gal.], when the vehicle is on a level surface. This value may vary
when the vehicle is on a slope.)

46
1-1. Hybrid system
CT200h_OM_OM76067E_(EE)
Electromagnetic waves
High voltage parts and cables on the hybrid vehicles incorporate electro-
magnetic shielding, and therefore emit approximately the same amount
of electromagnetic waves as conventional gasoline powered vehicles or
home electronic appliances.
Your vehicle may cause sound interference in some third party-produced
radio parts.
Hybrid battery (traction battery)
The hybrid battery (traction battery) has a limited service life. The lifespan
of the hybrid battery (traction battery) can change in accordance with driv-
ing style and driving conditions.
Declaration of conformity
This model conforms to hydrogen emissions according to regulation
ECE100 (Battery electric vehicle safety).
CAUTION
High voltage precautions
The vehicle has high voltage DC and AC systems as well as a 12-volt sys-
tem. DC and AC high voltage is very dangerous and can cause severe burns
and electric shock that may result in death or serious injury.
Never touch, disassemble, remove or replace the high voltage parts,
cables or their connectors.
The hybrid system will become hot after starting as the system uses high
voltage. Be careful of both the high voltage and the high temperature, and
always obey the caution labels attached to the vehicle.
Never try to open the service plug
access hole located in the luggage com-
partment. The service plug is used only
when the vehicle is serviced and is sub-
ject to high voltage.

47
1-1. Hybrid system
1
Before driving
CT200h_OM_OM76067E_(EE)
CAUTION
Road accident cautions
If your vehicle is involved in an accident, observe the following precautions
to reduce the risk of death or serious injury:
Stop the vehicle in a safe place to prevent subsequent accidents.
While depressing the brake pedal, apply the parking brake and shift the
shift position to P to stop the hybrid system. Then, slowly release the
brake pedal.
Do not touch the high voltage parts, cables and connectors.
If electric wires are exposed inside or outside your vehicle, an electric
shock may occur. Never touch exposed electric wires.
If a fluid leak occurs, do not touch the fluid as it may be strong alkaline
electrolyte from the hybrid battery (traction battery). If it comes into con-
tact with your skin or eyes, wash it off immediately with a large amount of
water or, if possible, boric acid solution. Seek immediate medical atten-
tion.
If a fire occurs in the hybrid vehicle, leave the vehicle as soon as possible.
Never use a fire extinguisher that is not meant for electric fires. Using
even a small amount of water may be dangerous.
If your vehicle needs to be towed, do so with front wheels raised. If the
wheels connected to the electric motor (traction motor) are on the ground
when towing, the motor may continue to generate electricity. This may
cause an electricity leakage leading to a fire. (
P. 563)
Carefully inspect the ground under the vehicle. If you find that liquid has
leaked onto the ground, the fuel system may have been damaged. Leave
the vehicle as soon as possible.
Hybrid battery (traction battery)
Your vehicle contains a sealed nickel-metal hydride battery. If disposed of
improperly, it is hazardous to the environment and there is a risk of severe
burns and electrical shock that may result in death or serious injury.

48
1-1. Hybrid system
CT200h_OM_OM76067E_(EE)
NOTICE
Hybrid battery air vent
Do not put foreign objects near the air vent. The hybrid battery (traction
battery) may overheat and be damaged.
Clean the air vent regularly to prevent the hybrid battery (traction battery)
from overheating.
Do not wet or allow foreign substances to enter the air vent as this may
cause a short circuit and damage the hybrid battery (traction battery).
Do not carry large amounts of water such as water cooler bottles in the
vehicle. If water spills onto the hybrid battery (traction battery), the bat-
tery may be damaged. Have the vehicle inspected by any authorized
Lexus dealer or repairer, or another duly qualified and equipped profes-
sional.

51
1-1. Hybrid system
1
Before driving
CT200h_OM_OM76067E_(EE)
Navigation system screenMulti-information
display
When the vehicle
is powered by the
electric motor
(traction motor)
When the vehicle
is powered by
both the gasoline
engine and the
electric motor
(traction motor)
When the vehicle
is powered by the
gasoline engine
When the vehicle
is charging the
hybrid
battery (traction
battery)
When there is no
energy flow

52
1-1. Hybrid system
CT200h_OM_OM76067E_(EE)
These images are examples only, and may vary slightly from actual condi-
tions.
Consumption (vehicles with a navigation system)
Press the “MENU” button on the Remote Touch and select “Car”
on the “Menu” screen.
If the “Consumption” screen does not appear, select “Fuel consump-
tion” on the “Energy monitor” screen or “Consumption” on the “Past
record” screen.
Fuel consumption per minute
Regenerated energy per min-
ute
: One symbol indicates 50
Wh.
Cruising range
The image is example only, and may vary slightly from actual condi-
tions.
Hybrid battery
(traction battery)
statusLowFullLowFull
Navigation system screenMulti-information
display